2012 Volkswagen GOLF: complaints, problems and recalls

VOLKSWAGEN OF AMERICA FAILS TO PROVIDE THEIR CUSTOMERS A FUSE DIAGRAM, MAKING IT IMPOSSIBLE TO SAFELY IDENTIFY AND REPLACE A SIMPLE BLOWN FUSE. *TR WITHOUT A BASIC FUSE DIAGRAM, THE ONLY CHOICE FOR VW OWNERS NEEDING TO REPLACE A FUSE IS TO PULL FUSES ONE-BY-ONE AS THEY SEARCH FOR THE BLOWN FUSE. WITH MANY UNUSED SLOTS, SHOULD A FUSE BE INADVERTENTLY REPLACED IN THE INCORRECT SLOT, A CRITICAL SAFETY SYSTEM SUCH AS BRAKE LIGHTS, TAIL LIGHTS, HEADLIGHTS, ABS BRAKE CONTROL, WINDSHIELD WIPERS, HORN, ETC. CAN BE ACCIDENTALLY DISABLED WITHOUT ANY…

Owner-reported narrative. 4,250 miles reported. Look up ODI 10454965 at NHTSA ↗

WATER COMES TO THE INTERIOR OF THE VEHICLE THROUGH THE GAP BETWEEN THE LOWER EDGE OF THE PLASTIC INTERIOR DOOR PANEL AND THE METAL DOOR. THIS LEAK NOW OCCURS ON THE RIGHT REAR DOOR OF THIS 2012 VW GOLF. ON OTHER DOORS, WATER COMES OUT THROUGH THE PURPOSELY DESIGNED DRAIN HOLES ON THE BOTTOM SIDE OF THE DOOR, AND THUS WATER DOES NOT COME INTO THE INTERIOR. THIS INCORRECT WATER FLOW INSIDE THE RIGHT REAR DOOR MAY CAUSE BODY DAMAGE AND ELECTRICAL HAZARD. WHEN I SPRAY LOW PRESSURE WATER TO THE BELT LINE AT A SELF CAR WASH BAY TO REPLICATE RAIN, WAT…

Owner-reported narrative. 4,500 miles reported. Look up ODI 10461255 at NHTSA ↗

LEAVING A PARKING LOT, PUT THE GEAR INTO REVERSE AND WAS GOING FORWARD. PUT THE GEAR IN PARKING 3 X AND BACK TO REVERSE 3 X, BUT STILL GOING FORWARD. COULDN'T TURN OFF THE ENGINE. OPENED THE DOOR, AND AFTER MAYBE 10 MINUTES WAS ABLE TO TURN OFF THE ENGINE, GAVE IT A MINUTE AND THEN USE THE REVERSE GEAR AND IT WORKED. *TR

Owner-reported narrative. 1,100 miles reported. Look up ODI 10470073 at NHTSA ↗

AT 6,519 MILES, WHILE ABOUT TO ENTER THE ON-RAMP OF A LOCAL HIGHWAY, THE CHECK ENGINE LIGHT AND GLOW PLUG INDICATOR LIGHT BEGAN TO FLASH. I WAS ABLE TO VEER OFF THE ENTRANCE RAMP AND CONTINUE DOWN THE DOWN TO THE NEAREST SAFE PARKING LOT AREA; AS I PULLED INTO THE PARKING LOT AREA, THE VEHICLE SHUDDERED AND SUDDENLY SHUT OFF. IT WOULD NOT RE-START, AND WE HAD TO ARRANGE FOR A TOW TO A FAMILY MEMBERS HOUSE THROUGH OUR INSURANCE COMPANY. IN THE MORNING WE HAD A TOW TO OUR DEALER SET UP THROUGH VOLKSWAGEN ROADSIDE SERVICE, WHO WOULD NOT COVER THE …

Owner-reported narrative. 6,519 miles reported. Look up ODI 10470560 at NHTSA ↗

FUEL PUMP FAILURE, RANDOM POWER CUT OUT DUE TO FAULT MODE. SYSTEM FLASHES A GLOW PLUG LIGHT INSTEAD OF A CHECK ENGINE LIGHT NOT SIGNALING A OBVIOUS FAILURE. *TR

Owner-reported narrative. 15,550 miles reported. Look up ODI 10472079 at NHTSA ↗

AT 2766 MILES I WAS CRUISING DOWN THE HIGHWAY AT 70 MPH ON MY WAY TO WORK WHEN THE ENGINE SUDDENLY LOST POWER AND THE EPC LIGHT CAME ON. THE ENGINE WAS COMPLETELY UNRESPONSIVE, I PULLED OFF TO THE SHOULDER, CALLED ROADSIDE ASSISTANCE AND WAS TOWED TO THE NEAREST DEALER THE SERVICE MANAGER TOLD ME THE WATER PUMP SEIZED AND SERIOUSLY DAMAGED THE ENGINE. I WENT TO LOOK AND THERE WAS A BIG HOLE IN THE SIDE OF THE ENGINE. HE TOLD ME THEY HAD TO ORDER NEW PISTON HEADS, RODS, ETC... BASICALLY, NEEDED TO REBUILD THE ENGINE. SPEAKING TO THE MECHANIC …

Owner-reported narrative. 2,766 miles reported. Look up ODI 10480604 at NHTSA ↗

I WAS DRIVING DOWN THE ROAD HAD JUST SHIFTED INTO 4TH GEAR CAME UP TO A RED LIGHT. I PRESSING IN THE CLUTCH AND STARTED TO SLOW DOWN STILL IN 4TH GEAR. THE RED LIGHT TURNED GREEN BEFORE I COULD SLOW DOWN MUCH AT ALL. I RELEASED THE CLUTCH WHEN I DID THIS THE ENGINE AND RPM INCREASED. I WAS STILL IN 4TH GEAR AND HARDLY ACCELERATING BUT IT FELT AS THOUGH I WAS IN SECOND GEAR. I KINDA FREAKED AND LOOKED TO MAKE SURE I WAS IN 4TH AND I WAS.THE CAR BEGAN TO RUN NORMAL SO I JUST BRUSHED IT OFF. I CAME TO ANOTHER RED LIGHT AND MADE A COMPLETE STOP. TH…

Owner-reported narrative. 11,000 miles reported. Look up ODI 10486272 at NHTSA ↗

THE CAR IS A 2012 VW GOLF TDI, PURCHASED AROUND APRIL OF 2012. IT HAD APPROXIMATELY 7500 MILES AT THE TIME OF THE INCIDENT. I WAS ON A SHORT DRIVE TO THE STORE AND BACK (5 MILES ROUND TRIP FROM HOME). ON THE WAY BACK, I HEARD A METAL GRINDING SOUND COMING FROM THE ENGINE COMPARTMENT AND NOTICED A LACK OF POWER. I TURNED OFF THE RADIO TO CONFIRM THAT THE SOUND WAS COMING FROM MY NEW CAR AND IT WAS. AT THE NEXT STOP LIGHT, THE CAR DIED AND COULD NOT BE RESTARTED. I CONFIRMED THAT I STILL HAD DIESEL FUEL, AND SURE ENOUGH, I STILL HAD 1/4 T…

Owner-reported narrative. 7,500 miles reported. Look up ODI 10489003 at NHTSA ↗

Reported: 2011-10-03 (October 3, 2011)

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Reported: 2015-08-04 (August 4, 2015)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Volkswagen CC, and Passat, 2010-2013 Eos, 2011-2014 Golf, GTI, Jetta, and Tiguan, and 2012-2014 Jetta Sportwagen vehicles. In the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. This contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.

Consequence: A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.

Remedy: Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. If the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Volkswagen customer service at 1-800-822-8987.

Reported: 2016-02-10 (February 10, 2016)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.

Reported: 2018-03-06 (March 6, 2018)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q9. Note: This recall partially supersedes recall 16V-078.

Reported: 2018-05-16 (May 16, 2018)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.

Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.

Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.

Reported: 2019-12-04 (December 4, 2019)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.