2005 Toyota TUNDRA: complaints, problems and recalls

I JUST SENT THE FOLLOWING EMAIL TO TOYOTA. I HOPE THAT NHTSA CAN FOLLOW UP AS THIS IS VERY CONCERNING: I WAS HORRIFIED BY THE SPANISH SPEAKING TOYOTA TUNDRA COMMERCIAL I JUST SAW. IT IS INCONCEIVABLE THAT TOYOTA WOULD HAVE A COMMERCIAL SHOWING LITTLE CHILDREN CRAWLING UNDER A CAR TO TRY TO GET A BALL OUT FROM UNDER IT. CHILDREN SHLOULD NEVER GO UNDER A CAR, WHETHER IT IS MOVING OR NOT. THEY CAN'T TELL THE DIFFERENCE! THIS IS ABSOLUTELY SHAMEFUL. TOYOTA SHOULD IMMEDIATELY PULL THIS COMMERCIAL. PLEASE DO NOT BE RESPONSIBLE FOR THE DEATH O…

Owner-reported narrative. Look up ODI 10114796 at NHTSA ↗

1. FROM A STOP, AUTO TRANSMISSION SLIPPED OUT OF FIRST GEAR. WHILE TRYING TO BACK UP, REVERSE WOULD NOT ENGAGE. 2. WHILE DRIVING, FOURTH GEAR DID NOT ENGAGE. THE CHECK ENGINE LIGHT CAME ON, THEN IT SLIPPED OUT OF THIRD. AS A RESULT, I WAS ALMOST REAR ENDED DUE TO THE LOSS OF POWER. 3. VEHICLE WAS TOWED TO DEALERSHIP. ACCORDING TO THEM, THE TRANSMISSION FAILED AND WAS REPLACED. OLD UNIT NOT AVAILABLE.*AK

Owner-reported narrative. 563 miles reported. Look up ODI 10116301 at NHTSA ↗

WHILE DRIVING AT VARIOUS SPEED OF 20-50 MPH AUTOMATIC TRANSMISSION WOULD INTERMITTENTLY JUMP OUT OF DRIVE INTO NEUTRAL. THIS CONDITION ALMOST CAUSES\D CONSUMER'S VEHICLE TO BE INVOLVED IN A REAR END CRASH. THE VEHICLE HAS BEEN TO THE DEALER ON TWO SEPARATE OCCASIONS. THE FIRST TIME THE DEALER INFORMED THE CONSUMER THAT NOTHING COULD BE FOUND. ON THE SECOND OCCASION THE DEALER REPLACED THE TRANSMISSION.*AK

Owner-reported narrative. 4,000 miles reported. Look up ODI 10117641 at NHTSA ↗

DT: WHEN THE ENGINE IS STARTED COLD IT IDLES VERY HIGH. WHEN TAKING FOOT OFF BRAKE OR PUTTING VEHICLE IN GEAR IT ACCELERATES QUICKLY. NO ACCIDENTS REPORTED. ALSO, NO OTHER PROBLEMS. TAKEN TO DEALER TO INQUIRE ABOUT THIS, DEALER STATED THAT THIS IS NORMAL. IT SEEMED TWICE AS FAST AS A NORMAL VEHICLE IN IDLE. WHEN THE ENGINE IS HOT THIS PROBLEM GOES AWAY. *AK *NM

Owner-reported narrative. 2 miles reported. Look up ODI 10122206 at NHTSA ↗

I HAD MY 2005 TUNDRA BED LOADED TO THE MAXIMUM ADVERTISED WEIGHT CAPACITY. ONCE I ENTERED THE HWY AND REACHED A SPEED OF 45 THE VEHICLE WENT OUT OF CONTROL. I HAVE BEEN DRIVING FOR MANY YEARS AND HAVE NEVER EXPERIENCED A LOSS OF CONTROL LIKE THIS. THE VEHICLE LEFT THE ROAD AND FLIPPED UPSIDE DOWN. THE CAB HELD UP GREAT AND EVERYONE WAS WEARING THEIR SEATBELT THEREFOR THERE WERE NOT SIGNIFIGANT INJURIES. ATLEAST ONE OF THE TIRES WERE OFF THE RIM BUT I'M NOT SURE IF THIS WAS A RESULT OF THE ACCIDENT OR A CAUSE.

Owner-reported narrative. 3,000 miles reported. Look up ODI 10129729 at NHTSA ↗

AIRBAG DID NOT DEPLOY IN A SIGNIFICANT FRONTAL IMPACT. *JB

Owner-reported narrative. Look up ODI 10136065 at NHTSA ↗

I WAS DRIVING IN THE LOCAL STREETS, AND WHILE MAKING A RIGHT TURN AFTER STOPPING AT A RED LIGHT, THE FRONT PASSENGER SIDE OF THE VEHICLE SUDDENLY COLLAPSED WITH NO WARNING. I WAS TRAVELING AT MOST 10 MPH. THE VEHICLE HAS NEVER SHOWED ANY SIGN OF FAILURE OR NOISE UNTIL THAT DAY. AFTER I PULLED OVER TO THE SIDE OF THE ROAD, I GOT OUT OF THE VEHICLE TO INSPECT THE CAR AND FOUND THE BALL JOINT IN UPPER CONTROL ARM HAD COMPLETELY TEAR ITSELF APART FROM THE WHEEL HUB. FORTUNATELY FOR ME, NO SERIOUS DAMAGE TO THE CAR OTHER THAN THE FAILED COMPONENTS A…

Owner-reported narrative. 133,000 miles reported. Look up ODI 10136424 at NHTSA ↗

WE OWN "TWO" 2005 TOYOTA TUNDRA DOUBLE CABS THAT ARE EQUIPPED THE SAME. BOTH OF THESE VEHICLES EXHIBIT THE SAME SAFTEY ISSUE. THE ISSUE: WHEN DRIVING WITH CRUISE CONTROL "ON" AT SPEEDS OF 70 MPH, ON SLIGHTLY UPHILL TRACK, THE CRUISE CONTROL WILL COMMAND THE VEHICLE TO MAXIMUM THROTTLE, SHIFING THE TRANSMISSION INTO PASSING GEAR. THIS ACTION ON THE 287 HORSEPOWER VEHICLE, CAUSES THE REAR TIRES TO BREAK LOOSE ON WET ROADS AND CAN CAUSE LOSS OF CONTROL OF THE VEHICLE, SENDING IT OFF THE ROAD OR INTO A SPIN. BOTH VEHICLES WE OWN EXHIBIT THIS BEHAVI…

Owner-reported narrative. 9,950 miles reported. Look up ODI 10138533 at NHTSA ↗

Reported: 2005-03-30 (March 30, 2005)

CERTAIN PICKUP TRUCKS EQUIPPED WITH BOTH VEHICLE STABILITY CONTROL (VSC) AND THE TRD DUAL EXHAUST SYSTEMS. THE TRD DUAL EXHAUST SYSTEM MET ALL CLEARANCE SPECIFICATIONS ON MODELS WITHOUT VSC, HOWEVER THE DRIVER'S SIDE EXHAUST LOCATED IN A POSITION WHERE CONTACT BETWEEN A BRAKE LINE FOUND ONLY ON VEHICLES WITH VSC AND THE TRD EXHAUST PIPE MIGHT OCCUR.

Consequence: IN THIS CONDITION, THE EXHAUST PIPE FLANGE MAY RUB AGAINST THE RIGHT REAR BRAKE LINE, WHICH COULD CAUSE BRAKE FLUID LEAKAGE. THIS COULD LEAD TO AN INCREASE OF VEHICLE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT AND, IF SO EQUIPPED, WILL REPLACE THE TRD DUAL EXHAUST SYSTEM FREE OF CHARGE. DURING THIS REPLACEMENT, THE DEALER WILL ALSO INSPECT THE SPECIFIC BRAKE LINE TO ASSURE IT HAS NOT BEEN DAMAGED AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON MAY 31, 2005. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2005-06-02 (June 2, 2005)

CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE A MANUAL AIR BAG ON-OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE A CHILD RESTRAINT LOWER ANCHORAGE SYSTEM IN THE FRONT PASSENGER SEAT. THIS SPECIFICATION DOES NOT MEET THE STANDARD REQUIREMENTS.

Consequence: THIS STANDARD ESTABLISHES REQUIREMENTS FOR CHILD RESTRAINT ANCHORAGE SYSTEMS TO ENSURE THEIR PROPER LOCATION AND STRENGTH FOR THE EFFECTIVE SECURING OF CHILD RESTRAINTS, TO REDUCE THE LIKELIHOOD OF THE ANCHORAGE SYSTEMS' FAILURE, AND TO INCREASE THE LIKELIHOOD THAT CHILD RESTRAINTS ARE PROPERLY SECURED AND THUS MORE FULLY ACHIEVE THEIR POTENTIAL EFFECTIVENESS IN MOTOR VEHICLES.

Remedy: DEALERS WILL REMOVE THE MANUAL AIR BAG ON-OFF SWITCH, REPLACE THE OWNER'S MANUAL, AND AFFIX A NEW SUN VISOR AIR BAG WARNING LABEL. THE RECALL BEGAN IN EARLY JANUARY 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2005-07-20 (July 20, 2005)

CERTAIN PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND OPTIONAL FABRIC FRONT CAPTAIN'S CHAIRS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THESE VEHICLES WERE BUILT WITH AN INCORRECT FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM INDICATOR LIGHT LENS WHICH WILL NOT DISPLAY THE STATUS OF THE FRONT PASSENGER AIR BAG.

Consequence: AS A RESULT, THE VEHICLE OCCUPANTS WILL NOT BE MADE AWARE OF WHETHER OR NOT THE AIR BAG IS ACTIVATED AND READY TO PROTECT THE OCCUPANT AS APPROPRIATE.

Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM INDICATOR LENS. THE RECALL BEGAN AUGUST 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2007-01-19 (January 19, 2007)

ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.

Consequence: IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2010-02-03 (February 3, 2010)

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Reported: 2010-02-03 (February 3, 2010)

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Reported: 2015-05-13 (May 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.

Reported: 2015-05-13 (May 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.

Reported: 2016-02-05 (February 5, 2016)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.

Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.

Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.

Reported: 2016-06-02 (June 2, 2016)

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Reported: 2018-12-12 (December 12, 2018)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.

Reported: 2019-10-17 (October 17, 2019)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.