2012 Toyota SIENNA: complaints, problems and recalls

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA. THE CONTACT STATED THAT WHEN ATTEMPTING TO BRAKE OR ACCELERATE, BOTH PEDALS WOULD BE DEPRESSED SIMULTANEOUSLY. THE CONTACT STATED THAT THE TWO PETALS WERE TOO CLOSE IN PROXIMITY. THE MANUFACTURER AND THE DEALER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAVEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60 AND THE CURRENT MILEAGE WAS 1,300.

Owner-reported narrative. 60 miles reported. Look up ODI 10444924 at NHTSA ↗

JOINING HIGHWAY IN A SITUATION WHERE VEHICLES GIVING WAY CAUSE HESITATION AND THEN GIVE WAY CAUSING BRAKING THEN ACCELERATION REPEATEDLY, TRANSMISSION REFUSED TO DOWNSHIFT ON KICK DOWN, VEHICLE WOULD NOT ACCELERATE, ACTUALLY SLOWED SIGNIFICANTLY FORCING FOLLOWING VEHICLES TO BRAKE .VEHICLE EVENTUALLY BEGAN TO PICK UP SPEED.GENERALLY POOR RESPONSE FROM TRANSMISSION IN ALL MODES. TRANSMISSION DROPS OUT OF DRIVE AT LOW SPEEDS CAUSING ENGINE TO RACE BEFORE TAKING UP DRIVE, VERY HARD TO OPERATE VEHICLE SMOOTHLY.. EXCESSIVE ENGINE VIBRATION AND NO…

Owner-reported narrative. 1,500 miles reported. Look up ODI 10456744 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED WHILE THE BRAKES WERE APPLIED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS ADVISED THAT THERE WAS NO FAILURE FOUND WITHIN THE VEHICLE. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THERE WOULD BE NO FURTHER INSPECTIONS OF THE VEHICLE BECAUSE THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 5,000.

Owner-reported narrative. 5,000 miles reported. Look up ODI 10457870 at NHTSA ↗

BRAND NEW VEHICLE LASTED ABOUT A WEEK, WIFE PARKED CAR, WENT INTO STORE, CAME OUT AND VAN WOULD NOT START, WIFE AND KIDS WERE STRANDED IN ROUGH PART OF NEIGHBORING CITY, BATTERY DEAD, TOYOTA SERVICE TESTED CHARGING SYSTEM AND FOUND NOTHING WRONG, THEY DIDN'T REPLACED BATTERY AS A PRECAUTION. *TR

Owner-reported narrative. 420 miles reported. Look up ODI 10464253 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA XLE. THE CONTACT STATED THAT AS HE APPROACHED A STOP LIGHT, HE SUDDENLY EXPERIENCED SUDDEN ACCELERATION AND THERE WAS AN INCREASE IN THE ENGINE RPMS UP TO 8,000. THE CONTACT FORCEFULLY APPLIED THE BRAKES AND SHIFTED INTO NEUTRAL. THE VEHICLE THEN DECELERATED AND THE CONTACT DROVE HOME SLOWLY. THE DEALER WAS NOTIFIED AND TOWED THE VEHICLE IN FOR A DIAGNOSTIC TEST. THEY WERE UNABLE TO DIAGNOSE A FAILURE AND ATTRIBUTED IT TO A DRIVER'S ERROR. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAI…

Owner-reported narrative. 900 miles reported. Look up ODI 10468304 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA. THE CONTACT STATED THAT WHEN ENGAGING THE BRAKES THE FRONT DRIVER SEAT WOULD SLIGHTLY SLIDE FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE VEHICLE WAS PERFORMING UP TO MANUFACTURER SPECIFICATIONS. AS A RESULT, THEY DID NOT OFFER ANY ASSISTANCE SINCE THEY WERE UNABLE TO ALTER THE DESIGN OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 12.

Owner-reported narrative. 12 miles reported. Look up ODI 10470762 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA. THE CONTACT WAS DRIVING 15 MPH WHEN THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT ATTEMPTED TO STOP THE VEHICLE BUT THE BRAKES WOULD NOT RESPOND. THE CONTACT HAD TO SHUT THE VEHICLE OFF WHILE IT WAS MOVING TO STOP THE VEHICLE FROM ACCELERATING AND AVOIDING A POSSIBLE CRASH. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER. THE DEALER WAS INVESTIGATING THE ACCELERATION ISSUE. THE FAILURE MILEAGE WAS 2,800. THE VIN WAS NOT AVAILABLE.

Owner-reported narrative. 2,800 miles reported. Look up ODI 10471799 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 TOYOTA SIENNA . THE CONTACT STATED THAT WHILE TRAVELING 30 MPH, THE HEADLIGHTS FAILED TO FULLY ILLUMINATE THE ROADWAY. THE VEHICLE WAS TAKEN TO THE DEALER.THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 400.

Owner-reported narrative. 400 miles reported. Look up ODI 10472883 at NHTSA ↗

Reported: 2011-11-30 (November 30, 2011)

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.

Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2012-03-23 (March 23, 2012)

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2012 4RUNNER AND SIENNA VEHICLES, EQUIPPED WITH NON-ORIGINAL EQUIPMENT REMOTE ENGINE STARTERS. A MALFUNCTION IN THE AUDIOVOX ELECTRONICS BRAND REMOTE ENGINE STARTER MODULE CAN PREVENT NORMAL COMMUNICATION OF THE VEHICLE’S CONTROLLER AREA NETWORK (CAN).

Consequence: IF THIS CONDITION OCCURS, ANTILOCK BRAKING AND STABILITY CONTROL MAY BE LOST, INCREASING THE RISK OF A CRASH. DRIVERS SHOULD RECEIVE DASHBOARD WARNING LIGHTS WARNING THEM OF A MALFUNCTION.

Remedy: GULF STATES TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REMOTE ENGINE STARTER WITH A NEW ONE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 4, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-444-1074.

Reported: 2013-01-16 (January 16, 2013)

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Reported: 2013-04-09 (April 9, 2013)

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Reported: 2016-11-29 (November 29, 2016)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.

Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.

Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.

Reported: 2017-01-09 (January 9, 2017)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain 2009 Toyota Corolla, Corolla Matrix, Yaris, Yaris HB, Scion xB, Pontiac Vibe, Lexus, ES350, IS250, IS350, and IS-F vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Toyota is recalling certain 2006-2008 Lexus IS250 and IS350, 2007-2008 Lexus ES350, Toyota Yaris, Yaris HB, and 2008 Lexus IS-F and Scion xB vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on February 1, 2017. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), H0A (Toyota Zone C), GLG (Lexus Zone A), GLH (Lexus Zone B) and HLA (Lexus Zone C).

Reported: 2019-01-09 (January 9, 2019)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.

Reported: 2019-07-25 (July 25, 2019)

Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.

Consequence: The contact may cause failure of the rear brake hoses, resulting in a loss of vehicle control and reduced braking ability, increasing the risk of a crash.

Remedy: Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.

Reported: 2019-10-17 (October 17, 2019)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.