2012 Toyota FJ CRUISER: complaints, problems and recalls

VEHICLE SHIMMY BETWEEN 60MPH AND 70MPH. TIRE BALANCE AND ALIGNMENT WERE PERFORMED BUT THIS DID NOT CORRECT THE PROBLEM. VEHICLE HAS BEEN DOING THIS SINCE NEW (4 MILES). *KB

Owner-reported narrative. Look up ODI 10437470 at NHTSA ↗

STEERING WHEEL BEGINS SHAKES AT SPEEDS OF 50 TO 60 MPH. HAVE BALANCED, ROAD BALANCED TIRES AND STILL THE STEERING WHEEL SHAKES, AT THIS SPEED I AM CONCERNED THERE IS SOMETHING WITH THE SUSPENSION/TIRES THAT MAY CAUSE A CRASH IN THE FUTURE. *TR

Owner-reported narrative. 6,600 miles reported. Look up ODI 10470297 at NHTSA ↗

STEERING WHEEL SHIMMY BETWEEN 50-60MPH. HAVE TAKEN TO DEALER WHICH HAVE BALANCED THE WHEELS AND TIRES BUT I AM STILL EXPERIENCING THE SAME PROBLEM. VEHICLE FEEL VERY UNSAFE WITH THE STEERING WHEEL SHAKING AT HIGHWAYS SPEEDS. OTHER FJ OWNERS HAVE BEEN EXPERIENCING THE SAME PROBLEM. *TR

Owner-reported narrative. 300 miles reported. Look up ODI 10476992 at NHTSA ↗

DURING SPEEDS OF 55-65 THE STEERING WHEEL STARTS TO SHIMMY. WE TOOK VEHICLE INTO OUR LOCAL SERVICE DEALER (NOT TOYOTA) AND WAS TOLD IT WAS A REAR CONTROL ARM BUSHING. WE THEN TRAVELED 2 HOURS TO THE NEAREST TOYOTA DEALERSHIP (THE ONE WHERE WE BOUGHT THE VEHICLE) AND WERE TOLD IT NEEDED A ROAD FORCE BALANCING AND IT WOULD NOT BE COVERED UNDER WARRANTY BECAUSE THEY WERE NOT STOCK TIRES. AFTER EXPLAINING TO THE DEALERSHIP THAT THIS WAS A WELL NOTED PROBLEM WITH THESE VEHICLES WE WERE TOLD THAT THEY WOULD NOT PERFORM THE ROAD FORCE BALANCING AT A…

Owner-reported narrative. 7,000 miles reported. Look up ODI 10478002 at NHTSA ↗

I HAVE PURCHASED AN FJ CRUISER FROM CITY TOYOTA IN DALY CITY, CA ON 7/12/2012. DURING MY 15,000 MI MAINTENANCE CHECK UP, THE SERVICE MANAGER DISCOVERED THAT THE LUG NUT STUDS ON THE WHEELS BROKE WHEN HE WAS TORQUING. HE ADMITTED THAT THEY WERE MADE IN CHINA AND THAT HE HAS FORWARDED THIS ISSUE TO TOYOTA CORP BECAUSE HE SAID IT'S FACTORY-RELATED AND HAVE ENCOUNTERED SIMILAR ISSUES. I AM VERY CONCERNED WHETHER THE NEW REPLACEMENT STUDS THEY WILL PUT IN MY TRUCK WOULD BE SAFE OR AS DANGEROUS AS THE PREVIOUS. I HAVE RESEARCHED ONLINE AND HAVE SEEN…

Owner-reported narrative. 10,600 miles reported. Look up ODI 10480039 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 TOYOTA FJ CRUISER. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHEN THE STEERING WHEEL BEGAN TO VIBRATE. THE FAILURE RECURRED SPORADICALLY. IN ADDITION, THE VEHICLE WOULD PULL TO THE RIGHT INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER NUMEROUS TIMES FOR THE DEFECT. A FOUR WHEEL ALIGNMENT WAS PERFORMED ON THE VEHICLE HOWEVER, THE FAILURE PERSISTED AND BECAME PROGRESSIVELY WORSE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 10.

Owner-reported narrative. 10 miles reported. Look up ODI 10494685 at NHTSA ↗

VEHICLE AFFECTED SINCE NEW. STEERING SHIMMY OCCURS AS VEHICLE APPROACHED 63 AND 68 MPH ON A VARIETY OF ROADWAYS. AT PEAK VIBRATION OR SHIMMY, THE STEERING WHEEL MOVES ROTATIONALLY ONE TO TWO INCHES. ATTEMPTS TO "HOLD" THE WHEEL STEADY ARE UNSUCCESSFUL. THE ENERGY INPUT TO THE STEERING SYSTEM IS BEYOND MY ABILITY TO HOLD. VEHICLE HAS BEEN TAKEN TO DEALERS FOR SERVICE. TIRES HAVE BEEN BALANCED BY TOYOTA AND GOODYEAR. GOODYEAR STATES THE TIRES BALANCE OKAY, BUT BALANCE CHANGES WITH 1000 MILES USE. ALIGNMENT HAS BEEN CHECKED AND FOUND WITHIN SP…

Owner-reported narrative. 300 miles reported. Look up ODI 10499349 at NHTSA ↗

A VEHICLE PULLED OUT IN FRONT OF ME. I APPLIED BRAKES TO AVOID AN ACCIDENT. APPLICATION OF BRAKES LED TO RIGHT FRONT TIRE LOCK UP AND SKID, WITH STRONG VEER TO LEFT. NO ANTILOCK BRAKE ACTIVITY OCCURRED. WITHIN A WEEK OF THE PANIC STOP ABOVE, THE BRAKES NOW ACTING ODDLY; SMALL BUMPS IN PAVEMENT (FREEWAY EXPANSION JOINTS) WILL CAUSE ABS TO ENGAGE. BRAKE PEDAL BECOMES NON-RESPONSIVE. I CALLED THE DEALER WHO SAID THIS WAS NORMAL BRAKE BEHAVIOR. I PLAN ON SCHEDULING A SERVICE CALL TO DOCUMENT THE ISSUE. I'VE OWNED MANY CARS AND SUV'S - AL…

Owner-reported narrative. 6,700 miles reported. Look up ODI 10499350 at NHTSA ↗

Reported: 2013-03-15 (March 15, 2013)

Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.

Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.

Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.

Reported: 2013-04-09 (April 9, 2013)

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Reported: 2013-04-25 (April 25, 2013)

Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."

Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.

Reported: 2014-08-04 (August 4, 2014)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."

Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.

Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.