2003 Toyota COROLLA: complaints, problems and recalls

CONSUMER CALLED COMPLAINING ABOUT BEING IN A FRONTAL COLLISION AT 25 MPH AND THE AIR BAGS DID NOT DEPLOY. ALSO STATED THAT DEALER WERE CONTACTED AND HAS DECLINED TO GIVE ANY SERVICE TO THE CONSUMER BECAUSE THERE IS NO RECALLS ON THE VEHICLE. ALSO STATED THAT HAS SPOKEN TO THE MANUFACTURE AND THEY ARE GIVING HIM THE RUN AROUND. TS

Owner-reported narrative. 600 miles reported. Look up ODI 10001164 at NHTSA ↗

CONSUMER STATED THAT WHEN TRYING TO ACCELERATE THE PEDAL WILL STICK IN THE IDLE POSITION CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS

Owner-reported narrative. Look up ODI 10001799 at NHTSA ↗

ENGINE - SULFUR SMELL CONTINUOUS SINCE PURCHASE OF '03 TOYOTA, COROLLA. MOSTLY WHEN STOPPED AND ENGINE COOL, BUT ALSO HAPPENS WHEN WARM. HAVE GONE 17,000 SINCE PURCHASE IN JULY, 2002 AND SMELL HAS ALWAYS BEEN THERE. DEALER HAS SO FAR NOT BEEN ABLE TO SOLVE EMMISSIONS PROBLEM.

Owner-reported narrative. Look up ODI 10002662 at NHTSA ↗

PURCHASED 2003 TOYOTA COROLLA IN SEPTEMBER OF 2002. CAR IS EMITTING A VERY NOTICEABLE SULFUR ODOR ESPECIALLY WHEN COMING TO A STOP AT TRAFFIC LIGHTS AFTER DRIVING AT HIGHWAY SPEEDS. CONTACTED DEALER AND WAS TOLD THE PROBLEM IS THE GASOLINE I PURCHASE. I POINTED OUT THAT I HAVE A 2002 TOYOTA CAMRY THAT I PURCHASED IN APRIL OF 2002, THAT I FILL BOTH CARS WITH THE SAME GASOLINE, AND THAT I HAVE NEVER EXPERIENCED ANY SUCH PROBLEM WITH THE CAMRY. AGAIN I WAS TOLD THE PROBLEM IS WITH THE GASOLINE. THE INTERNET ABOUNDS WITH DISCUSSION GROUPS WHER…

Owner-reported narrative. 2,176 miles reported. Look up ODI 10005392 at NHTSA ↗

STRONG SULFUR ODOR FROM EXHAST. SERVICE DEPARTMENT HAS SAID IT CANNOT BE REPAIRED, AND BLAMES BAD GAS. DID SAY TOYOTA HAS ACKNOWLEDGED THE PROBLEM. I HAVE TESTED SEVERAL BRANDS AND GRADES OF GAS WITH NO IMPROVEMENTS. DIRECTLY CONTACTED TOYOTA, WHO REFERRED ME BACK TO THE DEALER, WHO SAID IT CANNOT BE FIXED. SAID CAR COMPUTER IS FUNCTIONING NORMALLY.

Owner-reported narrative. 2,000 miles reported. Look up ODI 10005530 at NHTSA ↗

MY CAR IS A 2003 COROLLA, I BOUGHT IT IN DECEMBER, I HAD TO REPLACE THE WINDSHIELD IN JANUARY AND NOW IT HAS BEEN A MONTH AND IT IS CRACKED AGAIN AND WILL NEED TO BE FIXED. MY BELIEF IS THAT THE WINDSHIELDS BEING MANUFACTURED FOR THE NEW COROLLA'S CANNOT STAND NORMAL ROAD CONDITIONS, AND CRACKS WHEN EVEN A SMALL ROCK HITS IT. THIS WILL BE MY SECOND WINDSHIELD AND I HAVE ONLY HAD THE CAR 2 MONTHS.

Owner-reported narrative. 2,450 miles reported. Look up ODI 10005838 at NHTSA ↗

WHEN THE HEAT WAS TURNED ON, THERE WAS AN ODOR COMING FROM THE VENTS.*JB

Owner-reported narrative. Look up ODI 10006905 at NHTSA ↗

THE VEHICLE BECAME HESITANT AND DID HOLD IN IDLE, THE MANUFACTURER WAS AWARE THAT A PROBLEM EXISTED WITH THE NEW MODEL ENGINES.*JB

Owner-reported narrative. 8 miles reported. Look up ODI 10008942 at NHTSA ↗

Reported: 2002-03-11 (March 11, 2002)

ON PASSENGER VEHICLES WITH VEHICLE IDENTIFICATION NUMBERS (VIN) STARTING WITH 1NX ONLY AND BUILT FROM JANUARY 8 THROUGH FEBRUARY 13, 2002, IT IS POSSIBLE FOR THE BOLTS THAT JOIN THE REAR BRAKE AND HUB ASSEMBLY TO THE REAR AXLE CARRIER TO BE LOOSE DUE TO INSUFFICIENT TIGHTENING DURING THE ASSEMBLY PROCESS.

Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, ONE OR MORE OF THE FOUR BOLTS COULD COME LOOSE, CAUSING AN ABNORMAL NOISE FROM THE REAR AXLE AREA. IN THE EVENT THAT ALL FOUR BOLTS LOOSEN COMPLETELY, SEPARATION OF THE REAR BRAKE AND HUB ASSEMBLY FROM THE REAR AXLE CARRIER COULD OCCUR, WHICH COULD LEAD TO A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL PROPERLY TIGHTEN THE BOLTS. OWNER NOTIFICATION BEGAN MARCH 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2008-04-10 (April 10, 2008)

TOYOTA IS RECALLING 662,178 MY 2003-2004 COROLLA, COROLLA MATRIX AND PONTIAC VIBE VEHICLES EQUIPPED WITH POWER WINDOWS. THE DRIVER AND FRONT PASSENGER DOOR GLASS BOLTS MAY LOOSEN AND COME OFF, CAUSING THE DOOR GLASS TO SEPARATE FROM THE WINDOW REGULATOR. DUE TO THE COMPONENTS BECOMING LOOSE AND POSSIBLY RATTLING, AN ABNORMAL NOISE MAY BE HEARD FROM THE DRIVER AND /OR FRONT PASSENGER DOOR WHEN OPERATING THE POWER WINDOWS.

Consequence: THE DOOR GLASS MAY SEPARATE FROM THE WINDOW REGULATOR, BIND AND SHATTER DURING OPERATION OF THE POWER WINDOWS, CAUSING DRIVER DISTRACTION AND/OR INJURY.

Remedy: DEALERS WILL REPLACE THE DRIVER AND FRONT PASSENGER DOOR GLASS BOLTS WITH NEWLY DESIGNED BOLTS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 16, 2008 TO TOYOTA OWNERS. THE RECALL BEGAN ON MAY 21, 2008, FOR PONTIAC OWNERS. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371 OR PONTIAC AT 1-800-620-7668.

Reported: 2013-01-30 (January 30, 2013)

Toyota is recalling certain model year 2003-2004 Corolla and Corolla Matrix vehicles and 2003-2004 Pontiac Vibe vehicles. The supplemental restraint system (SRS) circuits are susceptible to internal shorting. The electrical short may create an abnormal current flow and increased heat which can damage the circuits. This could result in an inadvertent deployment of the front airbags and/or seat belt pretensioners.

Consequence: Inadvertent deployment of the airbags or the seat belt pretensioners may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Toyota will re-notify their owners who have already had their vehicles repaired with a noise filter, but did not receive a new airbag control module, and General Motors will re-notify theirs. Dealers previously installed a supplemental harness containing an electrical filter between the airbag control module and its wire harness, free of charge. Dealers will replace the airbag control module, free of charge. The recall began on March 13, 2013. The manufacturer has not yet provided a schedule for second notices. For more information, Toyota owners may call 1-800-331-4331 and Pontiac owners may call 1-800-620-7668.

Reported: 2015-01-28 (January 28, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2004 Toyota Corolla vehicles manufactured December 28, 2001, to May 2, 2004, 2003-2004 Toyota Corolla Matrix vehicles manufactured January 6, 2002, to April 29, 2004, 2003-2004 Avalon vehicles manufactured June 5, 2002, to December 20, 2004, and 2003-2004 Pontiac Vibe vehicles manufactured January 18, 2002, to April 27, 2004. Due to electrical noise, a component in the air bag control module may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the air bags or the seat belt pretensioners increases the risk of an injury or crash.

Remedy: Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the air bag control module, free of charge. The recall began on August 24, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. GM issued an interim notification to owners on March 27, 2015. The recall began on August 24, 2015. Pontiac owners may call 1-800-620-7668. Note: This recall supersedes recalls 13V-029 and 14V-147. Vehicles that had a noise filter installed as the remedy for one of those campaigns need to have the air bag control module replaced under this campaign.

Reported: 2015-05-13 (May 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.

Reported: 2015-05-13 (May 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.

Reported: 2018-12-12 (December 12, 2018)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.

Reported: 2019-08-28 (August 28, 2019)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2003-2008 Corolla, 2005-2008 Corolla Matrix, and Pontiac Vibe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. The air bag may not unfold as designed during inflation under high temperature conditions, possibly resulting in the air bag not inflating properly.

Consequence: An improperly inflated air bag increases the risk of injury during a crash.

Remedy: Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag assembly or sub-assembly, free of charge. Toyota owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are K1Q and K0Q. Pontiac owners may contact GM customer service at 1-800-762-2737. GM's number for this recall is N192273760.

Reported: 2019-10-17 (October 17, 2019)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.