2003 Toyota 4RUNNER: complaints, problems and recalls

FOUL SMELLING EXHAUST - AMMONIA SMELL - VERY STRONG ON ACCELERATIONS UPHILL OR FREEWAY ON RAMPS. *JB

Owner-reported narrative. Look up ODI 10155849 at NHTSA ↗

SUNROOF BROKE IN OPEN POSITION. COST $1600 TO REPAIR. CAR WAS PURCHASED IN FEBRUARY 2006. *JB

Owner-reported narrative. 58,586 miles reported. Look up ODI 10167230 at NHTSA ↗

DT*: THE CONTACT STATED WHILE DRIVING 40 MPH UPHILL, A STRONG ODOR WAS NOTICED. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR TO THE INCIDENT. THE DEALERSHIP WAS CONTACTED, WHO DETERMINED THE CATALYTIC CONVERTER WAS PRODUCING THE ODOR. THE EXTENDED WARRANTY COVERED THE REPLACEMENT. ALSO, THE CONTACT WAS ALERTED BY AN INDEPENDENT MECHANIC ABOUT THE FRONT BRAKES. THE MECHANIC MACHINED THE FRONT ROTORS AND INSTALLED NEW PADS. AS A RESULT OF THE BRAKES REPAIR, THE PEDAL WAS TOO LOW WHEN DEPRESSED. THE BRAKES WERE RECHECKED AND THE MECHANIC …

Owner-reported narrative. 28,000 miles reported. Look up ODI 10175810 at NHTSA ↗

1. FLAT TIRE, NEEDED TO GET SPARE OUT FROM UNDER VEHICLE. 2. BRAND NEW SPARE TIRE HAD NEVER BEEN TAKEN DOWN, NEW SPARE TIRE HAS BRANDING MARKING ON THE SIDEWALL OF THE TIRE, FROM THE HEAT UNDER THE VEHICLE AND WHERE IT IS ATTACHED TO HAS COMPROMISED THE SAFTY OF THE TIRE. 3. WENT TO TOYOTA DEALER AND THEY SAID THERE WAS NOTHING THEY COULD DO. *NM

Owner-reported narrative. Look up ODI 10176189 at NHTSA ↗

TL* - THE CONTACT OWNS A 2003 TOYOTA AVALON XLS. WHILE ATTEMPTING TO CHANGE A FLAT TIRE THE JACK MALFUNCTIONED. THE VEHICLE WAS RELEASED FROM THE JACK AND INJURED THE CONTACT'S HAND, CAUSING NERVE DAMAGE. IN ADDITION, IT DAMAGED THE DRIVER SIDE QUARTER PANEL. PER THE CONTACT, THE BASE OF THE JACK HAD A NARROW WIDTH OF 1 3/4 INCHES AND WAS INCHES IN LENGTH. THE JACK WAS SUPPOSE TO BE ABLE TO LIFT LARGER TOYOTA VEHICLES. THE CONTACT FELT THAT THE JACK WAS TOO FLIMSY TO SECURE THE VEHICLE AND WAS REQUESTING AN INVESTIGATION TO REPLACE…

Owner-reported narrative. 40,200 miles reported. Look up ODI 10178358 at NHTSA ↗

THE DOOR LOCKS ON FRONT-RIGHT AND REAR-LEFT SIDES ARE MALFUNCTIONING. THE DEALER AT BELL TOYOTA INDICATES THAT THERE ARE BAD ACTUATORS. CONSIDERING THAT THE FRONT-RIGHT AND REAR-LEFT LOCKS ARE NOT OPERABLE, I'M VERY CONCERNED ABOUT THE ABILITY TO ESCAPE THE VEHICLE IN AN EMERGENCY SITUATION. ALSO, THE FRONT-RIGHT AND REAR-LEFT DOORS ARE SPARINGLY UTILIZED INDICATING THAT THERE IS A QUALITY ISSUE ASSOCIATED WITH THE MALFUNCTION. *NM

Owner-reported narrative. Look up ODI 10182891 at NHTSA ↗

2003 TOYOTA 4 RUNNER, LIMITED V8 4WD- VEHICLE IMPACTED A BUMPER BARREL ON FREEWAY EXIT AT HIGH RATE OF SPEED APPROXIMENTLY 50 MPH. POINT OF IMPACT WAS DRIVER'S SIDE FRONT QUARTER PANEL AND DRIVER'S SIDE FRONT END. TOTAL DAMAGE TO VEHICLE EXCEEDED $5000.00. HOWEVER, NEITHER THE FRONT OR SIDE AIRBAGS DEPLOYED. THE LACK OF AIRBAG DEPLOYMENT CAUSED NON-LIFE THREATENING INJURIES.*AK

Owner-reported narrative. 23,000 miles reported. Look up ODI 10185835 at NHTSA ↗

TL* - THE CONTACT OWNS A 2003 TOYOTA 4 RUNNER. THE CONTACT HEARD A NOISE COMING FROM THE FRONT BRAKES. THE CONTACT HAD TO APPLY THE BRAKES WITH GREAT FORCE FOR THE VEHICLE TO STOP. THE VEHICLE SLID TO A STOP. THE DEALER'S DIAGNOSES WAS THAT DEBRIS IN THE ROTORS CAUSED THE NOISE. HOWEVER, THEY WERE UNABLE TO DIAGNOSE WHY THE VEHICLE COULD NOT STOP WITHOUT SLIDING. THE FRONT BRAKE PADS WERE REPLACED, AND THE ROTORS RESURFACED. THE FAILURE MILEAGE WAS APPROXIMATELY 900 MILES. THE CONTACT HAS THE REPAIR ORDER. THE CURRENT MILEAGE WAS 40,0…

Owner-reported narrative. 900 miles reported. Look up ODI 10187176 at NHTSA ↗

Reported: 2002-12-17 (December 17, 2002)

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.

Consequence: IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.

Remedy: OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.

Reported: 2003-04-14 (April 14, 2003)

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH V6 ENGINES, THE FUEL PULSATION DAMPER, LOCATED ON THE FUEL RAIL, MAY HAVE BEEN IMPROPERLY ASSEMBLED, CAUSING A DIAPHRAGM IN THE PULSATION DAMPER TO BE DAMAGED. IF THE DIAPHRAGM FAILS, FUEL MAY LEAK.

Consequence: THIS COULD RESULT IN AN ENGINE COMPARTMENT FIRE IF A HEAT SOURCE OR AN IGNITION SOURCE IS PRESENT.

Remedy: DEALERS WILL REPLACE THE PULSATION DAMPER. OWNER NOTIFICATION BEGAN MAY 5, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2011-02-24 (February 24, 2011)

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.