2008 Tiffin ALLEGRO: complaints, problems and recalls

STARTED SMELLING STRONG BRAKE SMELL STOPPED FOUND LEFT REAR BRAKE VERY HOT. *TR

Owner-reported narrative. Look up ODI 10454022 at NHTSA ↗

TIFFIN RECALLED SOME 2008 ALLEGRO BAY MOTOR HOMES, BUT OURS WAS NOT ON THE LIST. WE HAD AN ISSUE WITH THE BRAKE CALIPERS FAILING IN JULY OF 2015. THIS WAS THE ISSUE OF THE RECALL. WE MADE A QUICK STOP TO AVOID A VEHICLE AND THEN THE BRAKES BEGAN TO DRAG. PULLED OVER, BRAKES WERE OVERHEATED SO WE BEGAN TO SEARCH FOR REPAIR FACILITY. WE WERE ABLE TO DRIVE SLOWLY TO THE GARAGE WHICH WAS ONLY ABOUT A HALF MILE. SPENT SOMEWHERE AROUND 6 HOURS IN REPAIR FACILITY. THEY REPLACED THE CALIPERS ON BOTH REAR BRAKES. THIS IS EXACTLY WHAT THE RECALL …

Owner-reported narrative. 31,630 miles reported. Look up ODI 10915226 at NHTSA ↗

Reported: 2008-08-26 (August 26, 2008)

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: TIFFIN IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.

Reported: 2009-04-03 (April 3, 2009)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

Reported: 2010-11-22 (November 22, 2010)

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.

Reported: 2011-06-15 (June 15, 2011)

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2006-2010, ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES, MANUFACTURED FROM JANUARY 2005, THROUGH APRIL 2010, AND BUILT ON A DAIMLER/FREIGHTLINER CHASSIS. THE BRAKE LIGHTS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

Consequence: THE BRAKE LIGHTS MAY NOT ILLUMINATE CONSISTENTLY UPON BRAKE APPLICATION AND FAIL TO PROPERLY INDICATE TO A FOLLOWING VEHICLE THAT THE MOTORHOME HAS SLOWED OR COME TO A STOP, INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER TRUCKS (DTNA), MANUFACTURER OF THE CHASSIS, WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS, FREE OF CHARGE. (SEE DTNA'S RECALL CAMPAIGN 10V-178.) THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2012-06-19 (June 19, 2012)

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES EQUIPPED WITH BOSCH HYDRAULIC BRAKES. HYDRAULIC BRAKE EQUIPPED MOTORHOME CHASSIS EXPOSED TO LONG PERIODS OF TIME OF NON-DRIVING MAY EXPERIENCE DIAMETRICAL BRAKE CALIPER PISTON GROWTH AND REDUCED PISTON TO BORE CLEARANCE POTENTIALLY LEADING TO BRAKE DRAG AND OVERHEATING RESULTING IN REDUCED BRAKE PERFORMANCE.

Consequence: REDUCED BRAKE PERFORMANCE MAY LEAD TO AN INCREASED RISK OF A CRASH.

Remedy: TIFFIN WILL NOTIFY THE OWNERS, AND AUTHORIZED DAIMLER TRUCKS NORTH AMERICA (DTNA) DEALERS WILL INSPECT AND, AS NECESSARY, REPLACE THE BRAKE CALIPERS FREE OF CHARGE. AN INTERIM NOTICE WAS MAILED TO OWNERS BY DTNA ON AUGUST 6, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2015-12-28 (December 28, 2015)

Tiffin Motorhomes (Tiffin) is recalling certain model year 2007-2015 motorhomes manufactured May 1, 2007, to December 31, 2014, equipped with certain Coachstep Double and Triple Electric Steps. The bolt that attaches the fan gear assembly to the steps may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may become unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Dealers will install a retainer bracket on the double step assemblies and the Coachstep Linkage Assembly will be replaced and a retainer bracket will be installed on the trip step assemblies. The recall began on Ferbuary 10, 2016. Owners may contact Tiffin customer service at 1-256-356-8661, or Lippert customer service at 1-574-537-8900.

Reported: 2016-07-13 (July 13, 2016)

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.

Consequence: If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.

Remedy: Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.