2002 Tiffin ALLEGRO: complaints, problems and recalls

ON OCTOBER 10, 2003 CONSUMER NOTICED A BULGE ON THE SIDEWALL OF THE RIGHT FRONT TIRE. ON FEBRUARY 23, 2004 THE RIGHT REAR INNER DUAL TIRE BLEW OUT, AND SEPARATED WHILE DRIVING 65 MPH. THERE WAS SOME EXTENSIVE DAMAGE TO THE REAR FENDER. *AK

Owner-reported narrative. Look up ODI 10063170 at NHTSA ↗

TIFFIN MOTORHOME PROBLEMS EXPERIENCE WITH RV DRIVERS SEAT BELT , BOTH WINDSHIELD WIPERS AND ELECTRICAL SYSTEM. VEHICLE WARPED AND MISALIGNED BODY CHASSIS. *BF THE VEHICLE OVERHEAD A/C FAILED. THE 20 AMP FUSE BLEW INTERMITTENTLY WHEN THE CONSUMER TRIED TO USE THE A/C. WHEN THE CONSUMER ATTEMPTED TO BUCKLE THE BELT IT TIGHTENED AND WOULDN'T RELEASE. THE ENTRANCE DOOR WAS OUT OF ALIGNMENT THEREFORE IT COULDN'T BE LOCKED FORM THE OUTSIDE. THE DINING SEAT TOP RAISED UP ABOUT AND INCH BECAUSE IT HAD NOTHING UNDER IT FOR SECURITY. THE EXHAUST …

Owner-reported narrative. Look up ODI 10111352 at NHTSA ↗

2002 ALLEGRO RV, NEW, HAS DEMONSTRATED REPEATED SAFETY VIOLATIONS, WINDSHIELD WIPERS (2) INOPERATIVE/FAILURE TWICE, ONCE AFTER REPAIRED. SEAT BELT INOPERATIVE/FAILURE TWICE, ONCE AFTER REPAIRED. WINDSHIELDS (2) REPLACE TWICE DUE TO STRESS BREAKAGE. OVERHEAD A/C BLOWS FUSES, BECAUSE OF SHORTAGE, FUSE PANEL LOCATED UNDER CLOSET OVER THE PROPPANE TANK. IF PANEL FAILS THEN FIRE COULD CAUSE DEATH OR INJURY. HAVE ALL RELATED CORRESPONDENCE, CAN FURNISH YOUR OFFICE. RV PLACE "IN-OP STATUS" WITH CA DMV BECAUSE OWNER AFRAID TO OPERATE UNDER CURENT CO…

Owner-reported narrative. 4,500 miles reported. Look up ODI 10116749 at NHTSA ↗

2002 TIFFIN ALLEGRO HAS PROBLEMS WITH WINDSHIELD WIPERS, SEAT BELT MALFUNCTIONED, AND DOOR LOCKS.*MR THE CONSUMER WAS UNABLE TO LATCH THE SEAT BELT, THE MOTOR UNIT OF THE WINDSHIELD WIPERS WAS COMPLETELY DETACHED FROM THE BODY, BOTH WINDSHIELDS BROKE DUE TO STRESS. THE VEHICLE HAD AN ELECTRICAL DEFECT THAT CONTINUOUSLY CAUSED POWER FAILURES AND CIRCUIT BREAKERS TO BLOW. THE COMMODE WAS INOPERABLE. THE RV HAD A DEFECT IN THE DESIGN WHICH ALLOWED STRUCTURAL MOVEMENT.*JB

Owner-reported narrative. 3,134 miles reported. Look up ODI 10117504 at NHTSA ↗

DT: THE CONTACT OWNS A 2002 ALLEGRO BUS MOTOR HOME AND HE IS HAVING PROBLEMS WITH THE ORIGINAL TIRES ON THE VEHICLE THAT WAS MANUFACTURED BY MICHELIN. IN 2000 2 TIRES BLEW OUT. IN APRIL 2005 TWO MORE TIRES BLEW OUT. ALL TOGETHER 4 TIRES BLEW OUT OF THE ORIGINAL 6 TIRES. HE HAD MOTOR HOME AND TIRES REGULARLY MAINTAINED. HE WAS DRIVING AT THE TIME OF BOTH INCIDENTS. THE FIRST TIME ONE TIRE BLEW OUT, AND HE PROBABLY HADN'T DRIVEN 50 MILES WHEN THE OTHER TIRE BLEW OUT. THE TIRES HAD LESS THAN 20000 MILES ON THEM. TIRE SIZE 235/80R2…

Owner-reported narrative. 20,000 miles reported. Look up ODI 10121944 at NHTSA ↗

WORKHORSE CHASSIS AUTOMATIC PARKING BRAKE LOCKED WITHOUT WARNING AND WITHOUT PULLING THE AUXILIARY BUTTON. WOULD NOT RELEASE AND I HAD TO GO UNDER THE VEHICLE AND DISCONNECT IT. (THERE IS NO TRANSMISSION LOCK SO THE VEHICLE CAN ROLL AND HAS TO BE BLOCKED.) FORTUNATELY I WAS NOT AT SPEED BUT THE REPAIR SHOP ADVISED THIS HAS HAPPENED TO A CUSTOMER AT HIGHWAY SPEED; CAUSING MANY THOUSANDS DAMAGE. *NM *AK

Owner-reported narrative. 13,500 miles reported. Look up ODI 10158638 at NHTSA ↗

AN ON GOING PROBLEM WITH THE TURN SIGNAL CONTINUITY FAILING TO OPERATE. VEHICLE BEEN TO THE DEALER ON FIVE OCCASIONS, AND THE PROBLEM STILL REOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

Owner-reported narrative. Look up ODI 8016069 at NHTSA ↗

FRONT SLIDEOUT DRAG THE CARPET WHEN USED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

Owner-reported narrative. Look up ODI 8016072 at NHTSA ↗

Reported: 2003-04-14 (April 14, 2003)

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TIFFIN AT 1-256-356-8661.

Reported: 2007-11-05 (November 5, 2007)

ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: TIFFIN MOTORHOMES WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 1-256-356-8661.

Reported: 2009-04-03 (April 3, 2009)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

Reported: 2010-11-22 (November 22, 2010)

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.

Reported: 2011-02-08 (February 8, 2011)

TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.