2001 Thomas SAF-T-LINER HD: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
3 distinct recall campaigns
Not available median reported failure mileage
Scope: 2001 model year. Data snapshot: . 0 complaints include usable failure mileage.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
3 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
01V103000 · Vehicle Speed Control:Accelerator Pedal
Reported: 2001-03-27 (March 27, 2001)
VEHICLE DESCRIPTION: SCHOOL BUSES. THE ACCELERATOR PEDAL CAN POSSIBLY HANG UP ON THE FLOOR RUBBER.
Consequence: THE DRIVER WOULD BE EXPECTING THE VEHICLE'S SPEED TO DECREASE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A STAINLESS STEEL PLATE UNDER THE ACCELERATOR PEDAL. OWNER NOTIFICATION BEGAN JUNE 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
NHTSA campaign record ↗01V104000 · Structure:Body
Reported: 2001-03-27 (March 27, 2001)
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES BUILT WITH COMPOSITE FRONT ROOF CAPS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." THE ROOF CAP DOES NOT MEET THE REQUIREMENTS DUE TO THE OMISSION OF THE ADHESIVE THAT JOINS THE ROOF TO THE BUS BODY.
Consequence: IN THE EVENT OF A CRASH, THE ROOF OF THE VEHICLE MAY CRUSH, NOT PROPERLY PROTECTING THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL RE-BOND THE ROOF CAP TO THE ROOF SHEET METAL. OWNER NOTIFICATION BEGAN SEPTEMBER 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
NHTSA campaign record ↗02V320000 · Suspension:Rear:Springs:Air Suspension System
Reported: 2002-12-02 (December 2, 2002)
ON CERTAIN SCHOOL AND TRANSIT BUSES EQUIPPED WITH REYCO REAR AXLE AIR SUSPENSIONS, DEFLATED SUSPENSION AIR BAGS COULD CREATE EXCESSIVE DRIVELINE ANGLES CAUSING U-JOINT DAMAGE.
Consequence: THE DRIVE SHAFT COULD FALL OFF OF THE BUS. FOLLOWING VEHICLES COULD THEN RUN OVER THIS OBSTACLE, INCREASING THE RISK OF DAMAGE TO THE FOLLOWING VEHICLE.
Remedy: DEALERS WILL INSTALL AXLE STOPS TO LIMIT REAR SUSPENSION TRAVEL AND FASTENER TORQUE WILL BE CHECKED ON THE SUSPENSION HEIGHT CONTROL ROD. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
NHTSA campaign record ↗