2001 Thomas Built Buses SAF-T-LINER ER: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
4 distinct recall campaigns
Not available median reported failure mileage
Scope: 2001 model year. Data snapshot: . 0 complaints include usable failure mileage.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
4 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
01V104000 · Structure:Body
Reported: 2001-03-27 (March 27, 2001)
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES BUILT WITH COMPOSITE FRONT ROOF CAPS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." THE ROOF CAP DOES NOT MEET THE REQUIREMENTS DUE TO THE OMISSION OF THE ADHESIVE THAT JOINS THE ROOF TO THE BUS BODY.
Consequence: IN THE EVENT OF A CRASH, THE ROOF OF THE VEHICLE MAY CRUSH, NOT PROPERLY PROTECTING THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL RE-BOND THE ROOF CAP TO THE ROOF SHEET METAL. OWNER NOTIFICATION BEGAN SEPTEMBER 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
NHTSA campaign record ↗02V320000 · Suspension:Rear:Springs:Air Suspension System
Reported: 2002-12-02 (December 2, 2002)
ON CERTAIN SCHOOL AND TRANSIT BUSES EQUIPPED WITH REYCO REAR AXLE AIR SUSPENSIONS, DEFLATED SUSPENSION AIR BAGS COULD CREATE EXCESSIVE DRIVELINE ANGLES CAUSING U-JOINT DAMAGE.
Consequence: THE DRIVE SHAFT COULD FALL OFF OF THE BUS. FOLLOWING VEHICLES COULD THEN RUN OVER THIS OBSTACLE, INCREASING THE RISK OF DAMAGE TO THE FOLLOWING VEHICLE.
Remedy: DEALERS WILL INSTALL AXLE STOPS TO LIMIT REAR SUSPENSION TRAVEL AND FASTENER TORQUE WILL BE CHECKED ON THE SUSPENSION HEIGHT CONTROL ROD. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
NHTSA campaign record ↗16V395000 · Structure:Body:Door
Reported: 2016-06-02 (June 2, 2016)
Daimler Trucks North America LLC (DTNA) is recalling certain model year 1998-2002 Thomas Built Buses Saf-T-Liner Conventional, 2000-2002 Saf-T-Liner ER, 2000-2017 Saf-T-Liner MVP-EF, 1998-1999 Vista, 2003 Saf-T-Liner FS65, 2013-2017 Saf-T-liner C2, 2000-2002 Saf-T-Liner MVP-ER, 2013-2017 Saf-T-Liner HDX. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Consequence: If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Remedy: DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was sent to owners on July 28, 2016. A second notice was mailed to owners on December 16, 2016. Parts are available. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-713.
NHTSA campaign record ↗16V407000 · Structure:Body:Door
Reported: 2016-06-07 (June 7, 2016)
Daimler Trucks North America LLC (DTNA) is recalling certain model year 1998-2002 Thomas Built Buses Saf-T-Liner Conventional, 2000-2002 Saf-T-Liner ER, 2000-2002 Saf-T-Liner MVP-EF, 2000-2001 CL-960, 1998-1999 Vista, 2000-2002 Saf-T-Liner MVP-ER, and 2000-2002 TL-960 transit buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Consequence: If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Remedy: DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was sent to owners on July 28, 2016. A second notice was mailed to owners on December 9, 2016 Parts are available. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-713.
NHTSA campaign record ↗