2019 Tesla MODEL S: complaints, problems and recalls

ON MORE THAN ONE OCCASION, WHEN DRIVING IN ENHANCED AUTO-PILOT AND ENGAGED AUTO LANE CHANGE, THE CAR STARTED CHANGING LANES, THEN ABRUPTLY SWERVED BACK INTO MY ORIGINAL LANE. I LOOKED BEHIND ME AND COAST WAS CLEAR. IT'S NOT AT ALL APPARENT WHY THE CAR ABORTS THE LANE CHANGE. I WAS DRIVING THE SPEED LIMIT, 65 MPH ON A 3 LANE HIGHWAY AND I WAS IN A MIDDLE LANE, CHANGING INTO THE RIGHT LANE. FIRST OCCURANCE WAS IN TRAFFIC WITH PLENTY OF SPACE BETWEEN VEHICLES TO EXECUTE A SAFE LANE CHANGE. ONCE THE VEHICLE RETURNS TO THE ORIGINAL LANE IT WILL A…

Owner-reported narrative. 325 miles reported. Look up ODI 11187433 at NHTSA ↗

ELECTRICAL PROBLEM ASSOCIATED WITH SOFTWARE UPDATE 2019.28.2 320FBAO. DOWNLOADED UPDATE AND FOLLOWING UPDATE ONE COULD HEAR SOLENOIDS OPENING & CLOSING FOLLOWED BY LEFT DAY TIME RUNNING LIGHT ILLUMINATING FOLLOWED BY RIGHT. DID A SOFT AND HARD RESET AND FACTORY RESET TO NO AVAIL. TOOK CAR INTO SERVICE CENTER AND UPDATE REMOVED AND TOLD TO RE ENTER UPDATE WHEN HOME. RE INSTALLED UPDATE AND SAME THING OCCURS. SPENT OVER AN HOUR TRYING TO FIND A NUMBER TO CALL TO TALK TO SOMEONE ABOUT THE PROBLEM. ON CHAT LINE TOLD TO DO ANOTHER HARD RESET A…

Owner-reported narrative. 2,730 miles reported. Look up ODI 11242154 at NHTSA ↗

TL* THE CONSUMER OWNS A 2019 TESLA MODEL S. THE CONSUMER STATED THAT WHILETHEY WERE PULLING INTO THE DRIVEWAY UNKNOWN, THE VEHICLE ACCELERATED AND CRASHED INTO THE GARAGE DOOR AND WALL. THE AIR BAGS DID NOT DEPLOY, AND THE STEERING WHEEL AND BRAKES SEIZED. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76.2. *BF ORI NUMBER (XXX) ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSON…

Owner-reported narrative. 76 miles reported. Look up ODI 11269912 at NHTSA ↗

THE PASSENGER SIDE FRONT WHEEL GOT DISLODGED FROM THE STRUT AND THE CAR WAS UNCONTROLLABLE. IT WAS IN MOTION ON CITY STREET AFTER JUST GETTING OFF THE HIGHWAY

Owner-reported narrative. 30 miles reported. Look up ODI 11298299 at NHTSA ↗

ON HARD ACCELERATION (IN MOTION), THE CAR VIBRATES AND RATTLES FROM THE FRONT END. TESLA SAID THEY DO NOT HAVE A FIX. LOTS OF PEOPLE ARE COMPLAINING ABOUT IT. I FRERL SOMETHING MAJOR IS WRONG WITH THE CAR AND TESLA IS DOING NOTHING TO FIX THE PROBLEM.

Owner-reported narrative. 5,000 miles reported. Look up ODI 11307709 at NHTSA ↗

THIS ABOUT THE 400TH TIME THAT I HAVE HAD TO FILE A COMPLAINT ABOUT DEFECTIVE TESLA SUSPENSIONS. I DON'T GIVE UP EASILY. HERE IS A TESLA IN THE JUNKYARD. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/35537692/22 IT HAS NOT BEEN IN A CRASH. NO AIR-BAGS DEPLOYED. NO DAMAGE TO THE BODYWORK. THE ENTIRE FRONT SUSPENSION HAS FALLEN TO BITS. THE WHEEL AND TIRE APPEAR UNDAMAGED SO IT CAN NOT HAVE RUN OVER A BOULDER. EVERY SINGLE COMPONENT OF THE SUSPENSION HAS SNAPPED INTO PIECES. THE CAST MONKEY METAL STEERING KNUCKLE HAS CRACKED INTO SEVERAL PIECES. …

Owner-reported narrative. 5,000 miles reported. Look up ODI 11312283 at NHTSA ↗

I WAS DRIVING MY 2019 MODEL S TESLA ON AUTOPILOT DOWN THE FREEWAY AT FREEWAY SPEED WHEN SUDDENLY IT STARTED BRAKING AND THE ALARMS WENT OFF AS IF REACTING TO AN IMPENDING COLLISION. ONLY, THERE WAS NOTHING IN FRONT OF ME TO REACT TO. THE GUY BEHIND ME REAR ENDED ME AND SPUN ACROSS TRAFFIC LANES. THANKFULLY, EVERYONE WALKED AWAY FROM THIS WITH WHAT WE THINK IS JUST WHIPLASH AT THIS TIME - IT COULD HAVE BEEN SO MUCH WORSE!

Owner-reported narrative. 9,000 miles reported. Look up ODI 11339261 at NHTSA ↗

AT LOW SPEEDS (10-30 MPH) THERE IS A RATTLE THAT SOUNDS LIKE IT IS COMING FROM UNDER THE FRONT LEFT SIDE OF THE CAR. IT IS TRIGGERED BY EVEN THE SLIGHTEST OF BUMPS IN THE ROAD. IN 2018, TESLA ADMITTED TO THE PROBLEM AND WAS REPLACING STRUTS (OR EVEN BUYING BACK CARS), BUT EVER SINCE 2019, THEY SAY IT'S A "NORMAL" NOISE. I'M SORRY, BUT ANY NOISE THAT MAKES ME WONDER IF MY WHEELS OR SUSPENSION ARE GOING TO FALL OFF SHOULD NOT BE CONSIDERED A NORMAL NOISE. TESLA EVEN RELEASED A SERVICE BULLETIN ON 10/9/18 THAT SAID ONE WAY TO POSSIBLY GET RID…

Owner-reported narrative. 500 miles reported. Look up ODI 11340472 at NHTSA ↗

Reported: 2021-12-21 (December 21, 2021)

Tesla, Inc. (Tesla) is recalling certain 2014-2021 Model S vehicles. The front trunk latch assembly may be misaligned, preventing the secondary hood latch from engaging. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 113, "Hood Latch System."

Consequence: If the primary latch is inadvertently released and the secondary latch is not engaged, the hood could open unexpectedly, obstructing the driver's view and increasing the risk of a crash.

Remedy: Tesla Service will inspect and reposition the latch assembly as necessary, free of charge. Owner notification letters were mailed February 18, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-11-003.

Reported: 2021-10-29 (October 29, 2021)

Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.

Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.

Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.

Reported: 2022-01-27 (January 27, 2022)

Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

Consequence: Failing to stop at a stop sign can increase the risk of a crash.

Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

Reported: 2022-03-18 (March 18, 2022)

Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence: A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.

Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.

Reported: 2022-11-01 (November 1, 2022)

Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S and Model X vehicles. The electronic power assist steering (EPAS) system may experience a loss of power steering assist when driving on rough roads or after hitting a pothole.

Consequence: A loss of power steering assist can require greater steering effort, especially at low speeds, increasing the risk of a crash.

Remedy: Tesla has released an over-the-air (OTA) software update to recalibrate the EPAS system, free of charge. Owner notification letters were mailed December 31, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-014.

Reported: 2023-02-15 (February 15, 2023)

Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Consequence: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

Remedy: Tesla will release an over-the-air (OTA) software update, free of charge.  Owner notification letters were mailed April 15, 2023.  Owners may contact Tesla customer service at 1-877-798-3752.  Tesla's number for this recall is SB-23-00-001.

Reported: 2023-12-12 (December 12, 2023)

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Consequence: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

Reported: 2024-01-30 (January 30, 2024)

Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

Reported: 2024-02-27 (February 27, 2024)

Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.

Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.

Reported: 2024-05-28 (May 28, 2024)

Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.