1999 Suzuki GRAND VITARA: complaints, problems and recalls

WHILE DRIVING AXLE ASSEMBLY SLID OUT CAUSING LOSS OF POWER. DEALER CONTACTED. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

Owner-reported narrative. Look up ODI 10001804 at NHTSA ↗

THE WIRES AT THE BACK OF THE CIGARETTE LIGHTER MELTED. WHEN THE CONSUMERS BRAKE ASSIST WAS PLUGGED INTO THE CIGARETTE LIGHTER IT BURNED UP, BECAUSE THE WIRE WAS TOO THIN AND WAS UNABLE TO CARRY THAT TYPE OF LOAD. LUCKILY THE FUSE DID NOT BLOW OUT. *NLM *CB *JB

Owner-reported narrative. 40,000 miles reported. Look up ODI 10017458 at NHTSA ↗

THE VEHICLE WAS TAKEN TO THE DEALER AT 30,000 MILES BECAUSE OF A "CLICKING NOISE" COMING FROM THE ENGINE. THE DEALER STATED THERE WAS NO PROBLEM WITH THE ENGINE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHO FOUND A PROBLEM WITH THE TENSION ON THE TIMING CHAIN. THE PART WAS ON BACK ORDER. *NLM *TT *JB

Owner-reported narrative. 30,000 miles reported. Look up ODI 10017956 at NHTSA ↗

THE ENGINE WOULD NOT TURN OVER, COULD NOT BE JUMP STARTED, AND WAS TOWED TO THE DEALERSHIP. THE DIAGNOSIS WAS A DEAD CELL BATTERY AT ~48,000 MILES. TWO WEEKS LATER THE ENGINE WOULD NOT TURN OVER, BUT EVENTUALLY DID AFTER A JUMP START. THE FOLLOWING TWO WEEKS, WHEN THE KEY WAS TURNED TO TRY AND START THE ENGINE, ALL THAT HAPPENED WAS A CLICKING NOISE. JUMP STARTING WAS INEFFECTIVE. IT WAS TOWED AGAIN TO THE DEALERSHIP. THE DIAGNOSIS IS ENGINE SIEZURE. THE VEHICLE IS FOUR YEARS OLD, WITH ~48,000 MILES, AND PERFECT SERVICE RECORDS. THE DEA…

Owner-reported narrative. 48,476 miles reported. Look up ODI 10020630 at NHTSA ↗

THE ACCELERATOR PEDAL HAD GONE TO THE FLOOR WITHOUT BEING APPLIED. THE MANUFACTURER WAS CONTACTED AND STATED THEY HAD NO RECALLS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE HE SUGGESTED CHANGING THE ACCELERATOR PEDAL. *AK *SCC *JB

Owner-reported narrative. 43,000 miles reported. Look up ODI 10022369 at NHTSA ↗

CONSUMER STATES ENGINE MAKE RATTLING NOISE. DEALER HAS INSPECTED VEHICLE SEVERAL TIMES, AND PROBLEM STILL RECURRING. *AK

Owner-reported narrative. Look up ODI 10029769 at NHTSA ↗

I HAVE 1999 SUZUKI GRAND VITARA. I HAD A PROBLEM WITH THE ACCELERATOR STICKING TO THE FLOOR ABOUT A YEAR AND A HALF AGO. IT WAS STILL UNDER WARRANTY WHEN IT WAS REPAIRED. THE DEALER SAID IT WAS A BROKEN LINKAGE. NOW THE PROBLEM IS WHEN I ACCELERATE AT LOW SPEED IT MAKES A WEIRD GRUNTING GURGLING SOUND. I PLANNING ON HAVING IT CHECKED OUT WHEN I HAVE MY 3000 MILE OIL CHANGE IN SEPTEMBER.*AK

Owner-reported narrative. 69,178 miles reported. Look up ODI 10033289 at NHTSA ↗

VEHICLE TIE ROD BROKE.*MR THE FAILURE CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE AND CONSEQUENTLY STRUCK A CONCRETE DIVIDER WALL AND THE AIR BAGS FAIL TO DEPLOY. *PH (PER ALBERTO JIMENEZ THIS DOCUMENT IS CONSIDERED A MAILED IN VOQ) *JB

Owner-reported narrative. Look up ODI 10042068 at NHTSA ↗

Reported: 2001-04-27 (April 27, 2001)

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER TEMPERATURES BELOW -25 DEGREES, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. FUEL SYSTEM PRESSURE COULD INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.

Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A REDESIGNED INTAKE MANIFOLD VACUUM UNION AND A NEW FUEL PRESSURE REGULATOR. OWNER NOTIFICATION BEGAN JUNE 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Reported: 2003-12-05 (December 5, 2003)

ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.

Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Reported: 2004-08-30 (August 30, 2004)

ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.

Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR, THE FUEL DELIVER HOSE AND REPLACE THE HOSE CLAMP WITH AN IMPROVED CLAMP. THE RECALL BEGAN ON SEPTEMBER 29, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Reported: 2005-10-05 (October 5, 2005)

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.

Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.