2001 Subaru LEGACY: complaints, problems and recalls

MY 7 YR OLD SON, SEATED AND SHOULDER-STRAPPED INTO HIS BOOSTER SEAT IN THE BACK SEAT NEXT TO THE WINDOW, PULLED THE MIDDLE REAR SHOULDER STRAP OUT TO WHERE THE LOCKING MECHANISM BECAME ENGAGED, THEN WRAPPED THE STRAP AROUND HIS NECK. AS THE STRAP WENT BACK IN IT TIGHTENED AROUND HIS NECK TO THE POINT WHERE HE COULD NOT GET IT OFF OVER HIS HEAD OR PULL IT BACK OUT AGAIN, SINCE IT WAS IN LOCKING MODE. WE WERE DRIVING IN THE DARK, AND HE DID NOT TELL US HE WAS STUCK. WE WERE ON A LONG ROAD TRIP TO RELATIVES AND HAD BEEN DRIVING FOR ABOUT 16 HOU…

Owner-reported narrative. Look up ODI 10010321 at NHTSA ↗

WATER LEAKED INSIDE THE VEHICLE THROUGH THE SUNROOF, THE DEALER INSPECTED THE VEHICLE ON 5 OCCASIONS, HOWEVER THEY WERE UNABLE TO CORRECT THE PROBLEM. *JB

Owner-reported narrative. Look up ODI 10015458 at NHTSA ↗

THE VEHICLE WAS EQUIPPED WITH DUAL SUN ROOFS WHICH LEAKED THROUGH THE MAP LIGHT ONTO THE DRIVER. THE VEHICLE HAD BEEN TO THE DEALERSHIP AT LEAST 4 TIMES TO HAVE THE PROBLEM REPAIRED. THE MECHANIC WOULD CHECK FOR WATER TIGHTNESS OR LEAKAGE AFTER REPAIRING SUN ROOF. THE PROBLEM WOULD RECUR REGARDLESS OF THE TYPE OF REPAIR THAT WAS DONE. THE CONSUMER HAD CHECKED INTO THE LEMON LAW. *NLM PH *JB

Owner-reported narrative. Look up ODI 10015497 at NHTSA ↗

MY SUBARU LEGACY, 2001, 25,000 MILES, CAUGHT ON FIRE IN THE FRONT RIGHT PART UNDER THE HOOD SUDDENLY ON MY WAY HOME 2/5/03, I WAS LOCKED IN THE CAR AND UNABLE TO GET OUT TILL THE CAR FILLED WITH SMOKE, I WAS PANICKING, AS I WAS UNABLE TO BREATH. AT THAT POINT I THOUGHT I WOULD PASS OUT, OR DIE SOON, THE PEOPLE OUTSIDE COULD NOT GET ME OUT. MY CAR WAS TOTALED, AND STILL UNDER WARRANTY. SUBARU HAS NOT RESPONDED, I AM WITHOUT A CAR. THIS HAS BEEN VERY STRESSFUL FOR ME AND MY FAMILY. WE TRUSTED THE NAME OF SUBARU AND WHAT IT STANDS FOR TILL NOW. A…

Owner-reported narrative. 2,500 miles reported. Look up ODI 10019083 at NHTSA ↗

FUEL SYSTEM ISSUE. I HAVE OWNED MY VEHICLE FOR APPROXIMATELY 9 MONTHS. I BOUGHT IT AS A USED CAR FROM SLOANE IN PHILADELPHIA. IT HAS APPROXIMATELY 17000 MILES ON IT AND IS CONSIDERED STILL UNDER WARRANTY. I HAVE HAD TO TAKE IT IN FOR SERVICE 4 TIMES FOR THE VEHICLE HESITATING UPON ACCELERATION. THE SERVICE CENTER FIRST SAID THE HESITATION CAME FROM A BAD BATTERY, SECOND INCIDENT THEY STATED THEY COULD NOT FIND ANYTHING WRONG, THIRD INCIDENT, WHEN I ALMOST GOT IN AN ACCIDENT BECAUSE THE VEHICLE STARTED TO STALL UP ENTERING THE FREEWAY TRAFFI…

Owner-reported narrative. 17,400 miles reported. Look up ODI 10020970 at NHTSA ↗

WHILE DRIVING APPROXIMATELY 35MPH POWER STEERING FAILED WITHOUT WARNING.*AK

Owner-reported narrative. 46,466 miles reported. Look up ODI 10036723 at NHTSA ↗

THE PAINT IS CHIPPING OFF OF MY REAR BUMPER NEAR THE DRIVER'S SIDE UNDER THE TAIL LIGHTS. I TOOK THE CAR TO THE DEALER WHEN I WAS HAVING ANOTHER ISSUE LOOKED AT (MY ROUTERS KEEP WARPING). THE DEALER CALLED AND SAID THE PAINT GUY WOULD TAKE A LOOK AND LET ME KNOW. I PICKED UP THE CAR AFTER HOURS AND THERE WAS NO INFO ABOUT THE PAINT. WHEN I CALLED THEY TOLD ME IT WAS NEVER LOOKED AT. I HAD TO TAKE THE CAR BACK TO THE DEALER. THE PAINT GUY LOOKED AT AND SAID THAT HE CAN'T MAKE A DECISION ON PAINT, IT HAS TO BE MADE BY THE SUBARU REP. IT HA…

Owner-reported narrative. Look up ODI 10037469 at NHTSA ↗

CAR AT ISSUE IS A 2001 SUBARU LEGACY GT LIMITED. ON TWO OCCASIONS IN THE PAST MONTH, A STRONG RAW GAS SMELL FILLED THE ENGINE COMPARTMENT AND PASSENGER COMPARTMENT OF THE CAR. ON BOTH OCCASIONS, THE TEMPERATURE OUTSIDE WAS BELOW 10 DEGREES. AFTER THE FIRST OCCURRENCE, CAR WAS LEFT AT DEALER WHO FOUND NOTHING WRONG. THE CAR WAS FINE FOR NEXT 5 DAYS (WEATHER WAS 10 TO 30 DEGREES). ON DAY 6, WEATHER DROPPED TO ABOUT 8 DEGREES AND GAS SMELL RETURNED. CAR WAS LEFT IN GARAGE AFTER DRIVING AND GARAGE FILLED WITH VERY STRONG GAS SMELL. THERE IS …

Owner-reported narrative. 34,800 miles reported. Look up ODI 10054321 at NHTSA ↗

Reported: 2000-11-21 (November 21, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. A CASTING FLAW IN THE RIGHT FRONT BEARING HOUSING COULD RESULT IN LOSS OF STEERING IF THE CASTING FLAW SHOULD EXIST IN THE TIE-ROD ARM.

Consequence: THIS CASTING FLAW COULD CAUSE GREASE LEAKAGE, FRONT WHEEL BEARING FAILURE DUE TO LOSS OF GREASE, OR LOSS OF STEERING DUE TO TIE-ROD END SEPARATION.

Remedy: DEALERS WILL REPLACE ALL FRONT BEARING HOUSINGS WITH A LOT NUMBER OF OF15.

Reported: 2000-11-21 (November 21, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCORRECT BEIGE REAR CENTER SEAT BELT WEBBING WAS INSTALLED. THE BELT LENGTH IS TOO SHORT.

Consequence: THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE ALL BEIGE COLORED REAR CENTER LAP/SHOULDER BELTS WITH LOT NUMBER 0171.

Reported: 2000-11-21 (November 21, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. POSSIBLE FUEL LEAKAGE OF UNDER-HOOD FUEL HOSES AT LOW AMBIENT TEMPERATURES (-40 DEGREES C) ONCE THE FUEL HOSES AGE AND BECOME LESS FLEXIBLE.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT FOR UNDER-HOOD FUEL HOSES WITH LOT NUMBERS 0804 AND 0806 AND ALL FUEL HOSES WITH THOSE NUMBERS WILL BE REPLACED.

Reported: 2001-02-07 (February 7, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUALLY-ADJUSTABLE (NON-POWERED) SEATS. CERTAIN INNER FRONT SLIDE RAIL LATCH MECHANISMS MAY HAVE BEEN IMPROPERLY WELDED.

Consequence: IF AN INNER SLIDE RAIL LATCH MECHANISM BREAKS DUE TO IMPROPER WELDING, FORWARD AND REARWARD SEAT ADJUSTMENT WILL NO LONGER BE POSSIBLE. IN THE EVENT OF A CRASH, THE SLIDE RAILS COULD BREAK, EXPOSING THE OCCUPANT TO A RISK OF INJURY.

Remedy: DEALERS WILL REPLACE ONE OR BOTH FRONT SEAT INNER SLIDE RAILS. OWNER NOTIFICATION BEGAN MARCH 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Reported: 2002-10-30 (October 30, 2002)

CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.

Consequence: THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Reported: 2003-04-22 (April 22, 2003)

THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.

Consequence: IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Reported: 2004-03-16 (March 16, 2004)

ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.

Consequence: IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.