1997 Subaru LEGACY: complaints, problems and recalls

MY 1997 SUBARU LEGACY WAS TOTALLED IN A FRONT END COLLISION. THE COLLISION OCCURRED AT 30-35 MPH, MY 97 LEGACY'S ENGINE WAS DESTROYED IN THIS COLLISION, AND I WAS CRUNCHED INTO THE STEERING WHEEL BECAUSE THE AIRBAGS DID NOT DEPLOY. I SUFFERED INTERNAL INJURIES AND WAS TAKEN BY AMBULANCE TO THE HOSPITAL EMERGENCY ROOM. BOTH AIRBAGS IN MY 97 LEGACY FAILED. THE LEGACY WAS TOTALLED.

Owner-reported narrative. 49,882 miles reported. Look up ODI 10002691 at NHTSA ↗

WHILE DRIVING ON THE HIGHWAY AT A SPEED OF APPROXIMATELY 55 MPH, THE HOOD UNLATCHED, FLEW BACK, AND CONTACTED THE WINDSHIELD AND FORWARD ROOF. THE WINDSHIELD SHATTERED, BUT FORTUNATELY I WAS ABLE TO SEE THROUGH THE SPACE BETWEEN THE DASH AND BOTTOM OF THE HOOD AND MANAGED TO GET THE CAR TO THE MEDIAN. THE HOOD AND WINDSHIELD WERE RUINED, AND THE ROOF SUSTAINED CONSIDERABLE DAMAGE.*AK

Owner-reported narrative. Look up ODI 10021114 at NHTSA ↗

VEHICLE HAS BEEN LOOKED AT DURING A PERIOD OF TIME AND MECHANIC FOUND SEVERAL PROBLEMS. RADIATOR AND HEAD GASKETS WERE REPLACED. OIL WAS LEAKING FROM THE MOTOR, AND THE AXLE ON THE PASSENGER SIDE HAD GONE BAD. *AK

Owner-reported narrative. Look up ODI 10033998 at NHTSA ↗

THE VEHICLE WAS LEAKING OIL FROM THE REAR SEPARATOR PLATE AND OIL PUMP SEAL. *AK THIS CAUSED COPIOUS AMOUNTS OF SMOKE TO BILLOW OUT FROM UNDER THE HOOD AND OUT THE FRONT WHEEL WELLS WHEN STOPPED AFTER DRIVING SEVERAL MILES. TOOK SEVERAL MINUTES FOR THE SMOKE TO SUBSIDE. CONSUMER QUESTIONED WHETHER THERE WERE ANY FINES FOR THIS FAILURE. HE HEARD SUBARU MADE CHANGES TO THE NEWER MODEL LEGACY. CONSUMER LEARNED OF TWO OTHER SUBARU OWNER'S THAT EXPERIENCE THE SAME DEFECT. *PH *NLM

Owner-reported narrative. 70,000 miles reported. Look up ODI 10038415 at NHTSA ↗

VEHICLE ENGINE IS LEAKING OIL. *MR THE OIL LEAKED FROM THE OIL PUMP SEAL AND ALSO FROM THE REAR SEPARATOR PLATE THAT COULD START A FIRE. THE CONSUMER FOUND TWO OTHER OWNERS WITH THE EXACT SAME PROBLEM. SCC *JB

Owner-reported narrative. Look up ODI 10040582 at NHTSA ↗

WHILE TRAVELING AT 70 MPH ENGINE LIGHT ILLUMINATED AND SMOKE CAME FROM UNDER HOOD. DRIVER PULLED OVER, POPPED HOOD, AND NOTICED COOLANT AND OIL SPRAYED OVER ENGINE. ALSO A COUPLE OF FLAMES WERE PRESENT. DEALER SAID IT WAS A BLOWN HEAD GASKET.*AK

Owner-reported narrative. Look up ODI 10042496 at NHTSA ↗

WHILE THE VEHICLE WAS RUNNING IN THE PARK POSITION, THE CONSUMER WAS UNABLE TO SHIFT THE GEARS IN ANY DIRECTION. VEHICLE WAS NOT DRIVABLE. *AK THE CAUSE WAS DUE TO POOR GROUND TO THE SHIFTER SOLENOID. THIS WOULD NOT ACUATE TO ALLOW THE SHIFTER IN GEAR. THE CONSUMER WAS TOLD BY SEVERAL MECHANICS THAT THIS WAS A COMMON PROBLEM IN THIS MAKE/MODEL. *SCC *JB

Owner-reported narrative. 113,000 miles reported. Look up ODI 10042764 at NHTSA ↗

PROBLEMS WITH VEHICLE BLOWING HEAD GASKETS.*MR WHILE DRIVING, THE CHECK ENGINE LIGHT ILLUMINATED, SMOKE CAME FROM UNDER THE HOOD AND THE TAIL PIPE. VEHICLE WAS TOWED TO A SUBARU DEALERSHIP WHERE IT WAS DISCOVERED THE PROBLEM WAS A BLOWN HEAD GASKET. COOLANT AND OIL SPRAYED ALL OVER THE ENGINE AND IGNITED A SMALL FIRE ON THE EXHAUST MANIFOLD, BUT IT EXTINGUISHED ITSELF. CONSUMER HAD VEHICLE TOWED TO HER LOCAL DEALER. SHE OBTAINED TWO OPINIONS AND THEY BOTH SAID THE SAME THING. EXTREME COOLANT LOSS BUT NO EVIDENCE OF A LEAK. IT APPEARED W…

Owner-reported narrative. 63,000 miles reported. Look up ODI 10049945 at NHTSA ↗

Reported: 2001-06-25 (June 25, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.

Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Reported: 1997-11-13 (November 13, 1997)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT CLEARANCE WITHIN THE HAZARD WARNING LIGHT SWITCH HOUSING CAN CAUSE A BINDING BETWEEN THE ACTUATING BUTTON AND THE HOUSING.

Consequence: THE SWITCH COULD STICK IN AN INTERMEDIATE POSITION WHEN DEACTIVATING, RESULTING IN THE TURN SIGNALS BECOMING INOPERABLE.

Remedy: DEALERS WILL INSTALL A MODIFIED HAZARD WARNING SWITCH.

Reported: 1998-02-20 (February 20, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE THROTTLE SHAFT BALL BEARING ON THE SENSOR SIDE OF THE THROTTLE BODY ASSEMBLY WAS NOT INSTALLED IN CERTAIN THROTTLE BODIES.

Consequence: OPERATION OF A VEHICLE WITH A MISSING THROTTLE SHAFT BEARING CAN EVENTUALLLY LEAD TO AN INCOMPLETE RETURN OF THE THROTTLE VALVE RESULTING IN A HIGH IDLING CONDITION.

Remedy: DEALERS WILL INSPECT THE THROTTLE BODY AND REPLACE THE THROTTLE ASSEMBLY IF THE BEARING IS MISSING.

Reported: 1998-02-20 (February 20, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. DUE TO POOR WELDS, IGNITION KEYS CAN STICK, SHIFT LEVERS/LINKAGES CAN BREAK AND SHIFT LEVERS CAN MOVE.

Consequence: THIS CONDITION CAN CAUSE UNEXPECTED MOVEMENT OF THE VEHICLE INCREASING THE RISK OF A CRASH OR PROPERTY DAMAGE.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT LEVER ASSEMBLIES (EXCEPT THE HANDLE GRIP).

Reported: 1998-05-04 (May 4, 1998)

VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.

Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.