2000 Saturn SW: complaints, problems and recalls

THE BOLTS BROKE, WHICH CAUSED THE DRIVER SEAT BACK TO COLLAPSE.*JB

Owner-reported narrative. Look up ODI 10007113 at NHTSA ↗

THE REAR STABILIZER LINKS FROZE UP, DUE TO ROAD DIRT, SALT ETC. *AK *JB

Owner-reported narrative. 75,833 miles reported. Look up ODI 10038076 at NHTSA ↗

WHILE DRIVING AT A LOW SPEED AND WITHOUT ANY WARNING VEHICLE WOULD STALL, CAUSING THE DRIVER TO PULL OFF THE ROAD.*AK

Owner-reported narrative. Look up ODI 10043961 at NHTSA ↗

TWO MAJOR GASKET PROBLEMS WITH A SATURN 2000 SW2 WAGON. TOTAL REPAIR COST $1,500.*AK

Owner-reported narrative. Look up ODI 10104537 at NHTSA ↗

LETTER ON BEHALF OF CONSTITUENT (NC) THE DEFECTIVE FUEL TANK VENT VALVE ON HER 2000 SATURN SW1, DEALER CLAIMS THERE WAS NO RECALL. THE CONSUMER STATED THE VEHICLE WOULD NOT TAKE GAS. SHE WENT TO AN AUTO REPAIR SHOP AND THEY PRINTED OUT A RECALL AND ADVISED HER TO TAKE THE VEHICLE TO THE DEALER. *JB

Owner-reported narrative. Look up ODI 10247048 at NHTSA ↗

TL* THE CONTACT OWNS A 2000 SATURN SW2. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH AND ATTEMPTING A TURN WHEN THE REAR DRIVER SIDE DOOR RELEASED INDEPENDENTLY AND SWUNG OPEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS TOLD THAT THE FAILURE WAS COMMON AMONGST THE YEAR, MAKE AND MODEL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED NOR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 230,000. UPDATED 04/25/11 *BF

Owner-reported narrative. 230,000 miles reported. Look up ODI 10393686 at NHTSA ↗

TL* THE CONTACT OWNED A 2000 SATURN SW. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT NOTICED FLAMES UNDER THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND DETERMINED THAT IT WAS DUE TO AN ELECTRICAL FAILURE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

Owner-reported narrative. 200,000 miles reported. Look up ODI 10630098 at NHTSA ↗

ON MAY 29TH, 2015 AT APPROX. 5:30 PM EST THE DRIVER'S 2000 SATURN SW2 HAD UNCONTROLLABLE SUDDEN FULL THROTTLE ACCELERATION WHEN PUT INTO DRIVE FROM REVERSE WITHOUT A FOOT ON THE ACCELERATOR & COULD NOT BE STOPPED BY BRAKES WHILE ATTEMPTING TO LEAVE A PRIVATE BUSINESS PARKING LOT ONTO A PUBLIC ROADWAY. DRIVER TRAVELLED APPROX.100 FT. WITH FULL ON BRAKES APPLIED & AVOIDED POTENTIALLY STRIKING ONCOMING ROAD TRAFFIC BY DRIVING PARALLEL TO THE ROADWAY & DRIVING HEAD ON INTO A ROADWAY BRIDGE GUARDRAIL TERMINAL END TO STOP THE FORWARD PROGRESS OF THE …

Owner-reported narrative. 170,000 miles reported. Look up ODI 10722803 at NHTSA ↗

Reported: 2000-10-12 (October 12, 2000)

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES WERE BUILT WITH AN INADEQUATE VENT VALVE WELD ON THE TOP PORTION OF THE FUEL TANK.

Consequence: FUEL SPILLAGE COULD OCCUR DURING REFUELING OR IF THE VEHICLE WERE INVOLVED IN A ROLLOVER. IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE VEHICLE TO ENSURE THE FUEL TANK VENT VALVE IS PROPERLY WELDED. IF NECESSARY, DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY.

Reported: 2000-10-12 (October 12, 2000)

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH AUTOMATIC TRANSAXLES, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." THESE VEHICLES WERE BUILT WITH AN IMPROPERLY ADJUSTED AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY. IF IMPROPERLY ADJUSTED, IT IS POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED.

Consequence: THIS CONDITION INCREASES THE RISK OF A CRASH RESULTING FROM THE UNINTENDED MOVEMENT OF PARKED VEHICLES.

Remedy: SATURN IS ASKING OWNERS AND RETAILERS TO PERFORM A FUNCTIONAL CHECK OF THE AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY OPERATION, AND IF NECESSARY, TO HAVE THE CABLE ADJUSTED. IF OWNERS ARE NOT COMFORTABLE PERFORMING THE FUNCTIONAL CHECK THEMSELVES, THEY CAN HAVE THEIR DEALER PERFORM THIS INSPECTION FOR THEM.

Reported: 1999-08-23 (August 23, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE MANUFACTURED WITH WELDS IN THE INSTRUMENT PANEL CARRIER ASSEMBLY THAT DO NOT MEET SATURN QUALITY STANDARDS.

Consequence: A FRONT SEAT OCCUPANT, PARTICULARLY AN UNBELTED OCCUPANT, MAY HAVE AN INCREASED RISK OF INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL REPAIR THE VEHICLE'S INSTRUMENT PANEL CARRIER ASSEMBLY.

Reported: 1999-08-24 (August 24, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THESE VEHICLES WERE PRODUCED WITH BRAKE PIPE ATTACHMENT NUTS THAT MAY NOT BE TIGHTENED TO SPECIFICATIONS.

Consequence: IF THE BRAKE PIPE NUTS ARE NOT PROPERLY TIGHTENED, BRAKE FLUID LEAKAGE COULD OCCUR, INCREASING THE BRAKE'S STOPPING DISTANCE.

Remedy: DEALERS WILL INSPECT THE BRAKE PIPE NUTS FOR LEAKAGE, VERIFY THEY ARE TIGHTENED TO SPECIFICATIONS, AND REPLACE THE BRAKE PIPES IF NEEDED.

Reported: 1999-08-23 (August 23, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 581, "BUMPER STANDARD." THESE VEHICLES WERE PRODUCED WITH REAR BUMPER FASTENERS THAT MAY BE LOOSE OR MISSING.

Consequence: IF THE FASTENERS ARE LOOSE OR MISSING, THE REAR BUMPER MAY NOT ABSORB ENERGY AS IT WAS DESIGNED TO DO IN THE EVENT OF A REAR END COLLISION.

Remedy: DEALERS WILL VERIFY THAT THE REAR BUMPER BEAM FASTENERS ARE PRESENT AND PROPERLY TIGHTENED AND, IF MISSING, INSTALL NEW FASTENERS.

Reported: 1999-10-20 (October 20, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME OF THE VEHICLES WERE PRODUCED WITH SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE NOT ADEQUATELY TIGHTENED AT THE CENTER PILLAR AND COULD FALL OUT, MAKING THE SEAT BELT INOPERATIVE.

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR PROPER INSTALLATION AND TORQUE OF THE SEAT BELT SHOULDER GUIDE ANCHOR BOLTS.

Reported: 1999-10-27 (October 27, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A CONSOLE ARMREST FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THE ARMRESTS WERE PRODUCED WITH A LATCH THAT WILL NOT WITHSTAND THE VERTICAL FORCE REQUIREMENTS OF THE STANDARD.

Consequence: IN THE EVENT OF A CRASH, THE LATCH MAY OPEN AND THE ARMREST OR THE CONTENTS OF THE CONSOLE COULD INJURE AN OCCUPANT.

Remedy: DEALERS WILL REPLACE THE CONSOLE ARMREST LATCH.