1997 Saturn SC: complaints, problems and recalls

WHILE DRIVING AT 25/30 MPH VEHICLE CAUGHT ON FIRE. THE FIRE STARTED FROM THE REAR TAIL LIGHT.*AK

Owner-reported narrative. 150,000 miles reported. Look up ODI 10022646 at NHTSA ↗

I GOT MY 97 SATURN SC1 A YEAR AGO WITH 56K MILES ON IT. THE COUPLE THAT HAD IT BEFORE ME TOOK VERY GOOD CARE OF IT CONSIDERING THE OBVIOUS LACK OF QUALITY FROM THE FACTORY. I'VE PUT JUST OVER 21K MILES ON IT IN THE LAST YEAR. EVERY 500-1000 MILES IT BURNS A QUART OF OIL. THIS MEANS THAT EVERY 3000 MILES I HAVE TO GIVE IT TWO OIL CHANGES, ONE THE NORMAL WAY, AND ONE EVERY TIME I FILL IT WITH GAS. THE JOKE HAS BECOME "FILL THE OIL AND CHECK THE GAS." *NM

Owner-reported narrative. 1 miles reported. Look up ODI 10064451 at NHTSA ↗

VEHICLE TO DATE IS ON IT'S 3RD BATTERY & ALTERNATOR WITH ONLY 36,000 MILES ON IT. DEALER SAID IT WAS A FLAW W/BATTERY/ALTERNATOR. BATTERY/ALTERNATOR 1ST REPLACED JULY - AUG 2002 APPROX 16,000 MILES, SECOND REPLACEMENT OCT 2004 BATTERY & ALTERNATOR 32,000 APPROX MILES. BATTERY PRORATED/REPLACED ALTERNATOR - OWNER MUST PAY FOR FULL REPAIRS. ALSO, IGNITION HAS BEEN REPLACED TWICE AND REPAIRED ONCE.*AK

Owner-reported narrative. 16,000 miles reported. Look up ODI 10095808 at NHTSA ↗

WHILE DRIVING 3 MPH, THE FRONTAL AIR BAGS DEPLOYED INADVERTENTLY. THIS CAUSED THE PASSENGER TO SUSTAINED MINOR INJURIES. PLEASE PROVIDE FURTHER DETAILS. *JB

Owner-reported narrative. Look up ODI 10099237 at NHTSA ↗

WHILE DRIVING ON THE FREEWAY AT APPROXIMATELY 55 MPH ALL OF A SUDDEN SMOKE CAME FROM UNDER THE HOOD. VEHICLE BECAME SQUARELY. THERE WAS A CRACK IN THE CYLINDER HEAD, SPILLING OIL ALL OVER THE EXHAUST SYSTEM, WHICH CAUSED SMOKE AND GOT OIL ALL OVER THE TIRES. IT BLEW OUT 4 QUARTS OF OIL VERY RAPIDLY, CAUSING THE FRONT OF THE VEHICLE TO SWIRL ALL OVER THE ROAD. THE ENTIRE VEHICLE WAS FILLED WITH OIL SMOKE, MAKING VISIBILITY VERY DANGEROUS. THERE WAS A VERTICAL CRACK ON THE RIGHT SIDE OF THE CYLINDER HEAD THAT WENT ALL THE WAY BACK TO THE MID…

Owner-reported narrative. 80,000 miles reported. Look up ODI 10101232 at NHTSA ↗

WHEN KEY IS IN IGNITION AND STARTED AND STILL IN PARK THE SHIFT LOCK MECHANISM WILL NOT DISENGAGE WHEN BRAKE IS DEPRESSED. ALSO WHEN I SHUT OFF THE CAR AND TURN KEY TO OFF POSITION THE KEY GETS STUCK IN THE IGNITION LEAVING THE CAR SUSCEPTIBLE TO THEFT.*AK

Owner-reported narrative. 100,105 miles reported. Look up ODI 10103068 at NHTSA ↗

WHEN THE CAR WAS COMING TO A STOP, THE ENGINE WOULD START TO STALL, THE INTERIOR LIGHTS WOULD DIM AND THE ELECTRONIC DASH WOULD GO OUT AND THE CAR WOULD COMPLETELY STALL. THE CAR WOULD NOT START ON ITS OWN AND WOULD HAVE TO BE JUMPED OFF. IF THIS HAPPENED WHEN PULLING INTO DRIVEWAY, YOU COULD WAIT AN HOUR AND THE CAR WOULD START AS IF NOTHING HAPPENED. WHEN YOU TOOK OFF AGAIN THE SAME THINGS WOULD START UP AGAIN WITH THE STALLING AND THE NO STARTS. *TR

Owner-reported narrative. 114,297 miles reported. Look up ODI 10224370 at NHTSA ↗

TL*THE CONTACT OWNS A 1997 SATURN SC1. THE CONTACT STATED THAT THE LOCK FEATURE OF THE SEAT BELT RETRACTOR WOULD NOT WORK PROPERLY. AS A CONSEQUENCE, HE IS NOT PROPERLY RESTRAINED IN THE VEHICLE. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 97V161000 (SEAT BELTS:FRONT:RETRACTOR), ALTHOUGH THE FAILURES WERE IDENTICAL. THE CONTACT PAID $400 TO HAVE THE RETRACTOR REPLACED; HOWEVER, THE FAILURE RECURRED SHORTLY AFTERWARDS. THE MANUFACTURER WAS UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE …

Owner-reported narrative. 80,000 miles reported. Look up ODI 10231696 at NHTSA ↗

Reported: 1996-08-23 (August 23, 1996)

THE FRONT PASSENGER SEATS HAVE LESS LOCK PAWL ENGAGEMENT ON THE INBOARD FORE/AFT ADJUSTER THAN SPECIFIED. THIS DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS."

Consequence: THIS CONDITION COULD RESULT IN SEAT MOVEMENT WITH A BELTED OCCUPANT DURING A MODERATE TO SEVERE FRONTAL IMPACT.

Remedy: DEALERS WILL INSPECT AND REPLACE THE PASSENGER SEAT INBOARD FORE/AFT ADJUSTER.

Reported: 1997-09-22 (September 22, 1997)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE DRIVER OR FRONT PASSENGER SAFETY BELT IS PULLED OUT MUCH FASTER THAN NORMAL, A NUMBER OF TIME, THE LOCK-UP FEATURE OF THE RETRACTOR WILL NOT WORK PROPERLY.

Consequence: IN A RAPID DECELERATION OR VEHICLE CRASH, THE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTOR.

Reported: 1997-09-22 (September 22, 1997)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECTION OF THE OWNER'S HANDBOOK TITLED "HORIZONTAL AIM" DOES NOT SPECIFICALLY INSTRUCT AN OWNER HOW TO ADJUST THE HEADLAMP HORIZONTAL AIM. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: A VEHICLE'S HEADLAMP WOULD NOT BE PROPERLY ADJUSTED CAUSING VISIBILITY PROBLEMS TO ONCOMING VEHICLES.

Remedy: OWNERS ARE BEING PROVIDED WITH A LABEL WITH THE CORRECT INFORMATION ON HEADLAMP HORIZONTAL AIM TO BE PLACED OVER THE EXISTING TEXT IN THE OWNER'S HANDBOOK. IF AN OWNER DESIRES, THEIR DEALER CAN PLACE THE STICKER IN THE OWNER'S HANDBOOK FOR THEM.