1994 Saab 9000: complaints, problems and recalls

CONSUMER RECEIVED NHTSA RECALL 99V109000 CONCERNING AIR BAG MODULE. AFTER HAVING THE ECM REPLACED AND INSTALLED A COVER OVER THE ECM SRS LIGHT APPEARED ON THE DASHBOARD. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE CAUSE HAD NOT BEEN DETERMINED. *AK

Owner-reported narrative. Look up ODI 10101108 at NHTSA ↗

TL*THE CONTACT OWNS A 1994 SAAB 9000. THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT IT FAILED TO ENGAGE. HE PUSHED THE VEHICLE TO THE MECHANIC WHO DIAGNOSED THE CAUSE OF FAILURE AS THE IGNITION MODULE. THE CONTACT BELIEVES HIS VEHICLE SHOULD BE A PART OF RECALL # 05V399000 (ELECTRICAL SYSTEM:IGNITION:MODULE). THE VIN, ENGINE SIZE, AND # OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 210,000.

Owner-reported narrative. 210,000 miles reported. Look up ODI 10194130 at NHTSA ↗

SRS LIGHT CAME ON WITHIN 1 DAY SPONTANEOUS DRIVER SIDE AIR BAG DEPLOYED AT HWY. SPEED, ABLE TO GET CAR TO SHOULDER SLIGHT BURNS INSIDE RIGHT FOREARM, CLEAR AND DRY DAY. *TR

Owner-reported narrative. 239,000 miles reported. Look up ODI 10207583 at NHTSA ↗

TL*THE CONTACT OWNS A 1994 SAAB 9000. THE CONTACT NOTICED THAT THE DASHBOARD WAS CRACKED AND HAD OTHER UNSIGHTLY DAMAGE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THEY STATED THAT THE TOP SURFACE OF THE DASHBOARD NEEDED TO BE REPLACED. THE REPAIR COST WAS ESTIMATED AT $750. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 150,000 AND CURRENT MILEAGE WAS 178,000.

Owner-reported narrative. 150,000 miles reported. Look up ODI 10280239 at NHTSA ↗

TL* THE CONTACT OWNS A 1994 SAAB 9000 CSE. THE CONTACT STATED THAT WHILE TRAVELING 15-20 MPH, THE DRIVER SIDE AIR BAG DEPLOYED ERRONEOUSLY. THE FAILURE CAUSED INJURIES TO THE CONTACT'S HEAD, LEG AND SHOULDERS. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 173,899.

Owner-reported narrative. 173,899 miles reported. Look up ODI 10472903 at NHTSA ↗

ABS WARNING LIGHT COMES ON/OFF.

Owner-reported narrative. Look up ODI 485372 at NHTSA ↗

CONSUMER NOTICED A GASOLINE ODOR IN BACK OF VEHICLE ALONG WITH A SUDDEN LOSS OF FUEL, DEALER REPLACED THE FUEL PUMP SENDER ASSEMBLY, DEALER STATED THIS FAILURE COULD HAVE CAUSED AN EXPLOSION. *SLC

Owner-reported narrative. Look up ODI 559083 at NHTSA ↗

CONSUMER APPLIED BRAKES AT 55-60 MPH, THERE WAS A LOUD NOISE AND PEDAL WENT TO THE FLOOR. DEALER DETERMINED THAT BRAKE LINE WAS CRUSHED DUE TO ENGINE MOVEMENT.*AK

Owner-reported narrative. Look up ODI 8017193 at NHTSA ↗

Reported: 1994-05-02 (May 2, 1994)

ONE OF THE BULBS IN EACH OF THE BRAKE LIGHT LOWER OUTBOARD LAMP ASSEMBLIES MAY NOT HAVE BEEN PROPERLY WIRED, RESULTING IN IMPROPER TAIL LIGHT ILLUMINATION ON BRAKE APPLICATION. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IMPROPER ILLUMINATION OF BRAKE LIGHTS DURING BRAKE APPLICATION MAY NOT SIGNAL FOLLOWING DRIVERS OF THE OPERATOR'S INTENT TO SLOW OR STOP AND COULD RESULT IN A VEHICLE COLLISION.

Remedy: DEALERS WILL MODIFY THE BRAKE LIGHT OUTBOARD LAMP ASSEMBLIES TO MEET FMVSS REQUIREMENTS.

Reported: 1994-07-08 (July 8, 1994)

DURING LOW ENERGY FRONTAL IMPACT COLLISIONS, THE FRONT CROSSMEMBER CAN CONTACT THE METAL TUBING PORTION OF THE COOLER HOSE ASSEMBLY; AND/OR THE HOSE ASSEMBLY CAN BREAK AND LEAK OIL ONTO THE HOT EXHAUST MANIFOLD OR THE TURBOCHARGER.

Consequence: OIL LEAKING ON THESE HOT ENGINE SURFACES CAN IGNITE AND CAUSE A VEHICULAR FIRE.

Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER WHICH WILL PROTECT THE COOLER AND HOSES FROM OTHER STRUCTURAL COMPONENTS IN LOW ENERGY FRONT IMPACTS.

Reported: 1995-03-29 (March 29, 1995)

MOISTURE CAN FOLLOW THE ELECTRICAL HARNESS AND ENTER THE PRESSURE SWITCH CONNECTOR CAUSING CORROSION AND MALFUNCTION OF THE SWITCH.

Consequence: THE CORROSION CAUSES A DETERIORATION OF THE ELECTRICALSWITCH CONNECTION AND CAN RESULT IN FALSE ILLUMINATION OF ABS AND/OR THE BRAKE WARNING LIGHTS AND/OR THE LOSS OF POWER ASSISTANCE BECAUSE OF NO HYDRAULIC PUMPOPERATION. LOSS OF POWER ASSIST INCREASES THE DRIVER'S BRAKE PEDAL EFFORT REQUIRED FOR STOPPING WHICH CAN RESULT IN EXTENDED BRAKING DISTANCES.

Remedy: DEALERS WILL INSPECT THE ELECTRICAL CONNECTIONS TO THE ABS PRESSURE SWITCH TERMINALS FOR CORROSION AND INSTALL A SHRINK HOSE TO THE WIRING HARNESS TO AVOID MOISTURE ENTERING THE CONNECTION. PRESSURE SWITCHES WITH CORRODED CONNECTORS WILL BE REPLACED.

Reported: 1999-05-06 (May 6, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. MOISTURE CAN ENTER THE AIR BAG INFLATABLE RESTRAINT ELECTRONIC CONTROL MODULE (ECM) AND CAUSE CORROSION ON PORTIONS OF THE ECM PRINTER CIRCUIT BOARDS.

Consequence: THIS CORROSION CAN POSSIBLY CREATE OPEN CONNECTIONS IN CIRCUITS WHICH CONTROL THE RESTRAINT DEPLOYMENT, POSSIBLY CAUSING INADVERTENT AIR BAG DEPLOYMENT.

Remedy: DEALERS WILL INSPECT THE EXTERIOR OF THE ECM. IF THERE IS NO INDICATION OF MOISTURE, A COVER WILL BE INSTALLED OVER THE ECM. IF THERE IS INDICATION OF MOISTURE, THE DEALER WILL REPLACE THE ECM AND INSTALL A COVER OVER THE NEW ECM.