1998 Saab 900: complaints, problems and recalls

THE HEADLIGHT ASSEMBLY FOR THE RIGHT SIDE MARKER HAS FALLEN OUT TWICE IN 13 MONTHS.*AK

Owner-reported narrative. Look up ODI 10097933 at NHTSA ↗

I HAVE BEEN DRIVING A 1998 900 SAAB SINCE IT WAS NEW. IT HAD ABOUT 155,500 MILES AT THE TIME OF THE INCIDENT DESCRIBED BELOW. RECENTLY, I WAS GOING TO REMOVE THE FRONT SUSPENSION UPRIGHTS TO REPLACE THE SHOCK ABSORBER INSERTS. AFTER REMOVING THE WHEEL ON THE LEFT HAND SIDE, I DISCOVERED THAT THE "STEERING PIVOT ARM" (A HOLLOW CLAM-SHELL STAMPING WELDED TO THE UPRIGHT) WAS SO SEVERELY RUSTED OUT THAT I COULD ACTUALLY SLIP MY HAND INSIDE THE ARM. (APPROXIMATELY, 1/2 OF ITS TOTAL SURFACE AREA WAS GONE AND FATIGUE CRACKS WERE DEVELOPING IN THE R…

Owner-reported narrative. 155,285 miles reported. Look up ODI 10121692 at NHTSA ↗

1998 SAAB 900SE CONVERTIBLE - HAS HAD A CHRONIC PROBLEM 1YR+ OF VEHICLE ABRUPTLY STALLING WHEN DRIVING AT ANY SPEED. USUALLY COULD BE RESTARTED AFTER A MINUTE, BUT NOW IS DIFFICULT TO RE-START ONCE IT STALLS. THE VEHICLE STALLS OUT ON THE HIGHWAY AS WELL AND IS DIFFICULT AND DANGEROUS TO CONTROL WHEN STALLS. THE DEALERSHIP HAS TRIED TO REPAIR THE VEHICLE MULTIPLE TIMES 10+ RETURNS; VARIOUS PARTS HAVE BEEN ADJUSTED AND/OR REPLACED. SENSORS, MAIN COMPUTER CHIP, REWIRING, ETC.. THE PROBLEM STILL HAS NOT BEEN FIXED AND IS GETTING MUCH WORSE. THE V…

Owner-reported narrative. 50,000 miles reported. Look up ODI 10131011 at NHTSA ↗

DT*: THE CONTACT STATED WHILE STOPPED AT A TRAFFIC SIGNAL BOTH THE FRONT AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHO DETERMINED THE CONTROL MODULE SHORTED CAUSING THE DEPLOYMENT. THE DEALER DETERMINED THE CONTROL MODULE, AIR BAGS, AND SEATBELTS NEEDED TO BE REPLACED.

Owner-reported narrative. 31,000 miles reported. Look up ODI 10170335 at NHTSA ↗

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, THE PASSENGER SIDE AIR BAG DEPLOYED. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THERE WAS A NHTSA RECALL, # 01V222000, REGARDING AIR BAGS:FRONTAL. THE CONTACT DID NOT RECEIVE ANY NOTIFICATION ABOUT THIS RECALL.

Owner-reported narrative. 169,000 miles reported. Look up ODI 10174422 at NHTSA ↗

CHRONIC, ABRUPT STALLING PROBLEMS FOR 3+ YEARS. DEALERSHIP HAS TRIED TO REPAIR ON AT LEAST, 15+ OCCASIONS. DEALERSHIP HAD IT AT THEIR FACILITY FOR OVER 3 MONTHS ONE PERIOD, CONDUCTING DIAGNOSTIC TESTS. PARTS CHANGED: SENSORS; MULTIPLE TIMES, WIRING HARNESS, "MAIN COMPUTER CHIP" AND VARIOUS OTHER PARTS. THE CAR ABRUPTLY STALLS. IT WILL STALL AT ANYTIME - WHETHER DRIVING, COASTING, AT A STOP, OR ON THE EXPRESSWAY. IT WILL STALL WITHOUT WARNING AND IS VERY DIFFICULT TO CONTROL THE VEHICLE SAFELY TO THE ROADSIDE MULTIPLE TIMES OVER AND OVER WITH…

Owner-reported narrative. 50,000 miles reported. Look up ODI 10184358 at NHTSA ↗

MY 1998 SAAB 900 SE TURBO CONVERTIBLE HAS 62,000 MILES ON IT, AND YET I'VE JUST HAD TO REPLACE THE DIRECT IGNITION CASSETTE WHICH COMPLETELY FAILED -- THANKFULLY I WAS STILL IN THE DRIVEWAY WHEN IT CONKED OUT, THIS IS RIDICULOUSLY EARLY IN THE LIFE OF THE CAR ACCORDING TO MY SAAB SPECIALIST MECHANIC. I SAW THAT THE 2000 AND 2002 MODEL DI CASSETTES WERE RECALLED BUT NOT THE EARLIER MODELS. WONDERING IF THERE'S A WAY FOR REDRESS. *JB

Owner-reported narrative. 62,000 miles reported. Look up ODI 10199775 at NHTSA ↗

TL*THE CONTACT OWNS A 1998 SAAB 900 SE TURBO. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN STALLING, SPITTING, AND STUTTERING AS IF IT NEEDED GAS. THE VEHICLE THEN SHUT OFF AND RESTART. THE VEHICLE WAS DIAGNOSED WITH DIRECT IGNITION CASSETTE FAILURE AND HAS REMAINED PARKED EVER SINCE. THE CURRENT AND FAILURE MILEAGES WERE 96,000.

Owner-reported narrative. 96,000 miles reported. Look up ODI 10228167 at NHTSA ↗

Reported: 2001-07-02 (July 2, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. STATIC ELECTRICITY CAN BUILD UP WITHIN THE PASSENGER-SIDE AIR BAG MODULE AND CREATE ENOUGH OF A CHARGE TO CAUSE AN INADVERTENT AIR BAG DEPLOYMENT. MOST OF THESE INADVERTENT DEPLOYMENTS HAVE OCCURRED IN COOLER, DRY WEATHER, AND HAVE GENERALLY INCLUDED DUSTING OR WIPING OF THE DASHBOARD, STARTING THE CAR, OR CLOSING THE DOOR.

Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.

Remedy: DEALERS WILL INSTALL A FRONT PASSENGER-SIDE AIR BAG MODULE GROUNDING STRAP. OWNER NOTIFICATION BEGAN SEPTEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAAB AT 1-800-955-9007.

Reported: 1998-02-24 (February 24, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE INSTRUCTIONS FOR PROPERLY AIMING THE HEADLIGHTING SYSTEM WERE OMITTED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.

Remedy: OWNERS WILL BE SENT AIMING INSTRUCTIONS, AND DIRECTIONS FOR AFFIXING THESE INSERTS TO THE OWNER GUIDES. IF AN OWNER SO DESIRES, A DEALER CAN AFFIX THE INSERTS IN THEIR OWNER GUIDE FOR THEM.

Reported: 1998-06-23 (June 23, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG ALERT LABEL ON THE DRIVER SIDE VISOR WAS OMITTED. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."

Consequence: THE VEHICLE OCCUPANT MAY NOT PROPERLY UNDERSTAND THE OPERATION OF THE AIR BAG SYSTEM AND THE NEED TO USE SEAT BELTS.

Remedy: OWNERS WILL BE PROVIDED WITH AN ALERT LABEL TO BE INSTALLED ON THE VISIBLE SIDE OF THE DRIVER'S SUN VISOR. IF AN OWNER SO DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.