2022 Ram 5500: complaints, problems and recalls

Owners manual and marketing documents for 2022 RAM 5500 contain incomplete and obsolete information about diesel fueling requirements causing increased safety risk for drivers. These documents imply that without B20 option / package, vehicle cannot be safely fueled with diesel that contains ANY percentage of bio mass. Fuel must be straight petro diesel (B0) which is impossible to obtain in most of the United States as many states mandate at least 5% bio mass (B5). In addition, for the past few years, B20 optioned vehicles have not been ava…

Owner-reported narrative. Look up ODI 11456614 at NHTSA ↗

The contact owns a 2022 Ram 5500. The contact stated while driving approximately 65 MPH, the vehicle failed to shift properly into the correct gear. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the air filter to be replaced. The vehicle was repaired. The contact stated while driving approximately 65 MPH, the vehicle stalled. The contact stated no warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to Efird Chrysle…

Owner-reported narrative. 50,000 miles reported. Look up ODI 11487689 at NHTSA ↗

On the evening of 1/06/2022 I was traveling in heavy traffic going east on I-70 approaching mile marker 234 coming down a large mountain grade when i realized my transmission disengage. I was able to exit interstate and come to a stop I checked and found had no forward gears in transmission only had reverse gear. When I had secured a towing company ( which ram could not secure ) towing guy informed me that he has towed 2 to 3 of these vehicles every week for past six months with same issues. I very much feel this is a big safety issue especiall…

Owner-reported narrative. Look up ODI 11500780 at NHTSA ↗

My transmission went out completely without warning while driving on the expressway was able to glide it to right shoulder thank goodness my truck only has 161 miles that’s one hundred and sixty one miles and was recently bought as I’m doing research I’m starting to find out I’m not the only one these trucks are dangerous specially, when you’re on the expressway these transmissions go out without warning I could’ve got hit by other vehicles in the middle of the expressway. I got lucky. Thank God there wasn’t a lot of traffic due to a snowstorm …

Owner-reported narrative. Look up ODI 11506897 at NHTSA ↗

The contact owns a 2022 Ram 5500. The contact stated while driving approximately 65 MPH, the vehicle lost motive power and the contact was unable to shift gear. The check engine warning light was illuminated. The vehicle failed to restart. The vehicle was towed to a local dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that while driving at an undisclosed speed on the highway, the vehicle lost motive power and stalled. The vehicle failed to…

Owner-reported narrative. 1,500 miles reported. Look up ODI 11507457 at NHTSA ↗

My truck has 850 miles on it and the transmission failed. It has been at the ram dealer for a month with no fix in sight. Ram customer service has been no help.

Owner-reported narrative. Look up ODI 11507762 at NHTSA ↗

Driving down freeway lost all momentum had to coast to the shoulder almost causing several accidents and getting hit by a semi in the process. The truck had no gears whatsoever and gave me on warning something was as it risk for failing. Was told the entire transmission had failed. This was the second transmission ram had put in. The problem is becoming wide spread across the internet as multiple owners are now reporting with no known fix currently. Please note that the file below is the first repair which did nothing but almost cause another a…

Owner-reported narrative. Look up ODI 11507787 at NHTSA ↗

The contact owns a 2022 Ram 5500. The contact stated that while driving approximately 30 MPH, the transmission became inoperable. There was no warning light illuminated. The vehicle was towed to the local dealer where it was diagnosed and determined that the transmission needed to be replaced; however, the parts were on backorder. The vehicle was not repaired. The manufacturer was notified about the failure, but no additional assistance was provided. The failure mileage was approximately 862.

Owner-reported narrative. 862 miles reported. Look up ODI 11509679 at NHTSA ↗

Reported: 2021-10-14 (October 14, 2021)

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.

Reported: 2022-08-26 (August 26, 2022)

Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.

Consequence: An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z87.

Reported: 2023-02-09 (February 9, 2023)

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.

Consequence: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.

Reported: 2025-11-06 (November 6, 2025)

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.