2022 Ram 4500: complaints, problems and recalls

We purchased a brand new 2022 RAM 4500 truck 07/25/2022 , at the beginning of November the truck broke down and needed a brand new transmission . It took the dealer two months to install the new transmission , we picked up the truck from the dealer December 28th , 2022. Today 02-15-2023 truck broke again in the the middle of the highway and is not drivable again with transmission not working . The problem persists and puts safety of our employees and other at risk .

Owner-reported narrative. Look up ODI 11507515 at NHTSA ↗

The Aisin transmission lost 1-4 forward gears while towing a trailer. The vehicle would not go forward only would move in reverse. We were going through a weigh station at time of failure in Florida, while our home base is in Michigan. There are many failures with this part. It is the K-1 clutch pack fails then forward gears do not work. Dealerships and Stellantis are both fully aware of the problem and forced us to have the transmission rebuilt rather than replaced. Check engine light came on at time of failure.

Owner-reported narrative. Look up ODI 11515258 at NHTSA ↗

I was driving my truck and when i came to a stop and tried to put it in reverse, I did not have reverse. After several attempts of moving the gear lever there was a loud clunk, then I had reverse. Then when I then put it into drive it would not move. The vehicle has 35,500 miles. Dealer believes its the K1 snap ring in the aisin transmission. It is still at the dealer and they believe it will takes months to get the parts. Dealer has the same issue when it was dropped off. No warning lamps or symptoms prior to attempting to put it in re…

Owner-reported narrative. Look up ODI 11617612 at NHTSA ↗

Reported: 2021-10-14 (October 14, 2021)

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.

Reported: 2022-08-26 (August 26, 2022)

Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.

Consequence: An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z87.

Reported: 2023-02-09 (February 9, 2023)

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.

Consequence: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.

Reported: 2025-11-06 (November 6, 2025)

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.