2014 Ram 4500: complaints, problems and recalls

I PURCHASED THE TRUCK NEW AND THE DEALER WELDED THE BED TO THE FRAME IT IS KNOW COMPRISED SO IF IT CRACKS IT'S THERE FAULT. THE OTHER PROBLEM IS THE TRUCK DRIFTS TO THE RIGHT WE FOUND THE REAR AXEL IS ABOUT .30 THRUST ANGEL ,OUT OF SQUARE TO THE FRAME CAUSING PULL THEY SAY THERE IS NO FIX AFTER 7 TIMES IN THE SHOP AND DODGE WON'T HELP ME OR FIX IT.

Owner-reported narrative. 1,000 miles reported. Look up ODI 10783192 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 RAM 4500. WHILE DRIVING APPROXIMATELY 5 MPH UP HILL WITH HEAVY SNOW ON THE GROUND, THE VEHICLE WAS PULLING A 24 FOOT TRAILER WITH A PIECE OF MACHINERY APPROXIMATELY 1,800 POUNDS OF WEIGHT. THE VEHICLE LOST POWER AND SLID BACKWARDS INTO AN EMBANKMENT. THE FRONT DRIVER SIDE FENDER, SIDE MIRROR, AND DRIVER SIDE DOOR WERE DAMAGED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE SAME FAILURE OCCURRED ON TWO SEPARATE OCCASIONS WHILE DRIVING UP HILL WITH THE SAME LOAD AND ROAD CONDITIONS. THE CHECK ENGINE WARNING IND…

Owner-reported narrative. 18,000 miles reported. Look up ODI 10860907 at NHTSA ↗

MY 2014 RAM 4500 STARTED TO MAKE NOISE COMING FROM THE WATER PUMP OF THE 6.7L CUMMINS MOTOR. HAPPENS TO BE THAT THE FCA RELEASED A RECALL OF 500,000 RAMS WITH POSSIBLE ENGINE FIRE DUE TO A FAILED WATER PUMP BEARING. WHEN I NOTIFIED THE DODGE DEALER THEY STATED NO KNOWLEDGE ON THIS AND SCHEDULED A SERVICE APPOINTMENT OVER A WEEK OUT. BEFORE THE APPOINTMENT DATE THE WATER PUMP SEIZED AND SNAPPED THE BELT AMONGST OTHER THINGS LIKE A BELT TENSIONER UNDER THE HOOD AND THE TRUCK HAD TO BE TOWED IN. THEY WILL NOT COVER THE BELT BECAUSE THERE IS A PTO …

Owner-reported narrative. 64,000 miles reported. Look up ODI 11032948 at NHTSA ↗

2014 RAM 4500 G56 TRANSMISSION DON'T DO ANY HARD SHIFTING OR ANYTHING ELSE SHIFT LEVER BROKE CLEAN OFF TODAY SHIFTING INTO SIX DOING 45 MPH, NOT A HARD SHIFT NO GRINDING GEARS JUST DROPPED INTO GEAR AND THEN SNAPPED OFF. THE TECHS TELL ME THAT IS IS AN "ISOLATOR" WHICH KEEPS THE VIBRATION DOWN, BUT THE SHIFTER IS ONLY HELD TOGETHER BY RUBBER. THIS IS ON A HEAVY DUTY WORK TRUCK AND THE PIECE IS HELD TOGETHER BY RUBBER. THIS IS DANGEROUS BECAUSE AT THE TIME OF FAILURE I WAS TOWING A TRAILER WHEN IT BROKE LEAVING ME STUCK IN 6TH GEAR UNABLE TO M…

Owner-reported narrative. 105,000 miles reported. Look up ODI 11181586 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 RAM 4500. WHILE THE CONTACT'S EMPLOYEE WAS DRIVING 30 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE DID NOT SHUT OFF. THE DRIVER TOOK THE VEHICLE TO MCPEEK'S CHRYSLER DODGE JEEP RAM OF ANAHEIM (LOCATED AT 1221 S AUTO CENTER DR, ANAHEIM, CA 92806, [phone removed]) WHERE IT WAS DIAGNOSED THAT THE TURBO CHARGER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 93,881.

Owner-reported narrative. 93,881 miles reported. Look up ODI 11256913 at NHTSA ↗

MY OIL PAN IT RUSTING OUT FAST. NOTHING ON THE WHOLE TRUCK IS RUSTED AT ALL, ONLY MINOR SURFACE RUST. THE OIL PAN IS RUSTING VERY FAST AND THE TRUCK IS NOW LEAKING OIL. I BROUGHT THE TRUCK TO GOODBROTHERS DODGE AND THEY QUOTED ME THE REPAIRS TO BE AROUND 1200.00. I DROPPED THE TRUCK OFF AND THE NEXT DAY THEY SAID THE OIL PAN THEY ORDERED IS DENTED AND THEY NEED TO ORDER ANOTHER. THEN 4 DAYS LATER THEY SAID THEY COULDN'T DO THE JOB AND REPLACE THE OIL PAN. THEY SAID I NEED TO FIND SOMEONE ELSE TO FIX IT. I BOUGHT THE TRUCK FROM THEM AND NOW THEY…

Owner-reported narrative. 50,000 miles reported. Look up ODI 11268100 at NHTSA ↗

HEATER WILL WORK WHEN IT WANTS TO I HAVE CHANGED BLOWER AND RESISTOR STILL KICKS OFF FOR NO REASON

Owner-reported narrative. 342,000 miles reported. Look up ODI 11281958 at NHTSA ↗

TL* THE CONTACT OWNED A 2011 RAM 4500. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, IT CAUGHT ON FIRE WHILE SITTING IN HIS WORK PARKING LOT. DUE TO THE PROXIMITY TO THE FIRE, THE VEHICLE PARKED IN FRONT OF HIS VEHICLE ALSO CAUGHT FIRE. A BYSTANDER HAD CALLED THE FIRE DEPARTMENT WHO THEN ARRIVED TO THE SCENE TO EXTINGUISH THE FIRE. UPON EXITING HIS BUILDING, THE CONTACT DISCOVERED IT WAS HIS VEHICLE THAT CAUGHT FIRE. NO INJURIES WERE REPORTED AS A RESULT OF THE FIRE AND THE CONTACT WAS UNCERTAIN IF A FIRE REPORT WAS FILED. THE VEHICLE H…

Owner-reported narrative. 125,000 miles reported. Look up ODI 11415786 at NHTSA ↗

Reported: 2014-10-08 (October 8, 2014)

Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.

Consequence: If the connectors overheat, the fuel heater may leak fuel, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will replace the harness side connector with a silver plated beryllium copper terminal service kit, and inspect the fuel heater for leaks, replacing it as necessary, free of charge. Chrysler issued interim notification to owners on December 8, 2014. The recall began on April 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P65.

Reported: 2015-05-18 (May 18, 2015)

Chryser (FCA US LLC) is recalling certain model year 2014-2015 Ram 4500 and 5500 cab chassis trucks manufactured August 20, 2013, to January 27, 2015 and equipped with 6.4L Hemi engines. The affected vehicles have a maximum governed speed of 106 mph but are fitted with tires that are only rated for a maximum speed of 87 mph.

Consequence: If the vehicle exceeds the tires' maximum speed rating, the tires may suddenly fail, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will correct the electronic control unit software to limit the vehicle's speed to 87 mph, free of charge. The recall began on June 10, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R17.

Reported: 2015-07-22 (July 22, 2015)

Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Ram 1500, 2500, 3500, 4500, and 5500 trucks manufactured January 18, 2011, to October 7, 2014, and equipped with the Electronic Vehicle Information Center option. The affected vehicles have a steering wheel wiring harness that may rub against the driver air bag module retainer spring.

Consequence: This abrasion may result in an electrical short that could cause driver's frontal air bag to unexpectedly deploy. Inadvertent deployment of the air bag may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will inspect, repair as necessary, and secure the steering wheel wiring harness. Additionally, protective caps will be added to the air bag retainer spring ends. These repairs will be done free of charge. The recall began on September 18, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R36.

Reported: 2015-07-23 (July 23, 2015)

Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.

Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.

Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.

Reported: 2017-09-12 (September 12, 2017)

Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.

Consequence: The leaking water pump can increase the risk of an engine compartment fire.

Remedy: Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.

Reported: 2017-12-20 (December 20, 2017)

Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.

Consequence: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.

Remedy: Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.

Reported: 2017-12-21 (December 21, 2017)

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

Reported: 2018-05-17 (May 17, 2018)

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Reported: 2021-05-27 (May 27, 2021)

Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.

Consequence: Wheel separation can cause a vehicle crash.

Remedy: Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.