1998 Orion V: complaints, problems and recalls

Reported: 2001-01-29 (January 29, 2001)

VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.

Consequence: WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.

Remedy: ORION WILL NOTIFY OWNERS TO INSPECT THEIR BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VANNER AT 1-800-227-6937.

Reported: 2003-03-27 (March 27, 2003)

CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.

Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT MAY HAVE DIFFICULTY OPENING THE EMERGENCY EXIT WINDOW, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.

Remedy: DEALERS WILL REPAIR THESE WINDOWS. OWNER NOTIFICATION BEGAN JUNE 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-800-492-2116.

Reported: 2004-03-23 (March 23, 2004)

ON CERTAIN BUSES EQUIPPED WITH CUMMINS ELECTRONIC CONTROL MODULES ON THE L10G ENGINES, THE ECM DOES NOT HAVE THE ABILITY TO DETECT A THROTTLE FAIL-SAFE ENGINE SHUTDOWN COMMAND. THIS COULD RESULT IN AN UNANTICIPATED, UNCOMMANDED OPEN THROTTLE CONDITION WITHOUT WARNING.

Consequence: IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: CUMMINS WILL NOTIFY THE CUSTOMERS AND REPLACE THE ECM. OWNERS SHOULD CONTACT CUMMINS AT 1-800-343-7357 OR ORION AT 1-800-658-2871.

Reported: 2004-11-15 (November 15, 2004)

CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." DURING SUBSEQUENT CLOSING OF AN EMERGENCY EXIT THE MOVING WINDOW FRAME INTERFERES WITH THE JAM FRAME STOP LOCATED IN MID SPAN ALONG THE LOWER EDGE OF THE WINDOW FRAME.

Consequence: DURING THE USE OF AN EMERGENCY EXIT WINDOW, A WINDOW MAY NOT OPEN AFTER APPLYING THE REQUIRED FORCES ALLOWING A PERSON TO ESCAPE IN THE EVENT OF AN EMERGENCY.

Remedy: DEALERS WILL INSTALL TWO ALUMINUM BLOCKS EACH ATTACHED BY TWO SCREWS. THE MOVING WINDOW FRAME WILL NOT INTERFERE WITH THE JAM FRAME STOP. THE RECALL BEGAN MAY 1, 2005. OWNERS SHOULD CONTACT ORION AT 905-403-7832, EXT. 3335.

Reported: 2005-02-01 (February 1, 2005)

ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO ENTER THE EXHAUST SYSTEM.

Consequence: IN THE EVENT THE TURBOCHARGER FAILS, A FIRE MAY OCCUR IN THE ENGINE COMPARTMENT RESULTING IN PROPERTY DAMAGE OR INJURIES.

Remedy: DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPAIR THE ENGINE AND INSTALL AN EXHAUST TEMPERATURE SENSOR TO PREVENT THE POSSIBILITY OF AN EXHAUST OR ENGINE COMPARTMENT FIRE. OWNERS MAY CONTACT DETROIT DIESEL CORPORATION AT 313-592-5791 OR ORION AT 905-403-7832.

Reported: 2007-02-01 (February 1, 2007)

ON CERTAIN TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS, IT IS POSSIBLE FOR A PERSON TO WEDGE THEIR FEET UNDER THE SOLID BAR BARRIER LINKAGE.

Consequence: WHILE SITTING IN A WHEELCHAIR, A PERSON WITH NO SHOES AND WHO DOES NOT HAVE CONTROL OF THEIR FEET COULD TWIST THEIR FEET AND GET THEM FORCED UNDER THE LINKAGE WHICH COULD RESULT IN AN INJURY.

Remedy: DAIMLERCHRYSLER COMMERCIAL IS WORKING WITH LIFT-U TO REPAIR THESE BUSES (PLEASE SEE 06E-093). OWNERS WILL RECEIVE A FREE REPAIR KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNERS MAY CONTACT LIFT-U AT 209-838-2400 OR ORION BUS AT 905-403-7807.

Reported: 2010-01-21 (January 21, 2010)

DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.

Consequence: THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.

Reported: 1998-07-31 (July 31, 1998)

VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH SUNSOURCE/FAUVER TANDEM HYDRAULIC PUMPS. THE HYDRAULIC PISTON PUMP IS DRIVEN BY THE ENGINE AND A SHAFT OUT OF THE BACK OF THE PUMP PROVIDING POWER TO THE POWER STEERING PUMP. THE SHAFTS ARE CONNECTED TOGETHER WITH A COUPLING. THIS COUPLING IS FITTED WITH TWO RETAINER CLIPS WHICH KEEPS IT CENTERED BETWEEN THE TWO PUMPS. THESE BUSES WERE SHIPPED MISSING THE COUPLING RETAINER CLIPS.

Consequence: EXCESSIVE MOVEMENT OF THE COUPLING CAN DISENGAGE THE TWO PUMP SHAFTS, CAUSING LOSS OF POWER STEERING.

Remedy: DEALERS ARE INSPECTING AND RETROFITTING THE COUPLINGS ON THESE PUMPS.

Reported: 1998-09-21 (September 21, 1998)

VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH WHEEL CHAIR BARRIERS. THE WHEEL CHAIR BARRIERS ARE ATTACHED TO THE FLOOR STRUCTURE WITH A BOLT THREADED INTO THE FLOOR STRUCTURE. IN THE CASE OF A FRONTAL CRASH, WITH THE WHEEL CHAIR POSITION OCCUPIED, THE BOLT THREADS COULD STRIP ALLOWING MOVEMENT OF THE WHEEL CHAIR BARRIER.

Consequence: THIS CONDITION COULD ALLOW MOVEMENT OF THE WHEEL CHAIR WHICH COULD CAUSE PERSONAL INJURY, OR DEATH, TO THE WHEEL CHAIR OCCUPANT.

Remedy: DEALERS WILL REPLACE THE EXISTING WHEEL CHAIR BARRIER LEG MOUNTING BOLTS WITH NEW BOLTS, NUTS AND WASHERS.

Reported: 1998-09-17 (September 17, 1998)

VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH ELECTRIC ENGINE STARTERS. THE POWER CABLES ARE ROUTED ACROSS THE BACK OF THE ENGINE AND FASTENED TO THE ENGINE BULKHEAD. THE CABLE MAY NOT BE ADEQUATELY FASTENED, CHAFFING THE CABLE, AND CAUSING AN ELECTRICAL SHORT.

Consequence: THIS CONDITION COULD POSSIBLY START A FIRE IN THE ENGINE COMPARTMENT.

Remedy: DEALERS REROUTED THE WIRING IN THE ENGINE COMPARTMENT.

Reported: 1999-09-08 (September 8, 1999)

VEHICLE DESCRIPTION: TRANSIT BUSES. FAILURE OF A SOFT SEAT CHECK VALVE IN WHEELCHAIR LIFTS PROVIDED BY LIFT-U, MAY ALLOW THE FRONT AND REAR PLATFORM BARRIERS TO RETURN TO A HORIZONTAL POSITION FROM THE VERTICAL POSITION THEY ARE SUPPOSED TO BE LOCKED IN.

Consequence: THIS COULD ALLOW A MOBILITY AID TO ROLL OFF OF THE LIFT PLATFORM INJURING ITS OCCUPANT. LIFT-U WILL REPLACE THE SOFT SEAT CHECK VALVES.

Remedy: LIFT-U WILL REPLACE THE SOFT SEAT CHECK VALVES.