2012 Nissan XTERRA: complaints, problems and recalls

VEHICLE WOULD NOT START, BECAUSE OF A BROKEN CLUTCH PEDAL STOPPER. THIS BROKEN PART PREVENTED THE DEPRESSED CLUTCH PEDAL FROM ACTIVATING THE CLUTCH SAFETY SWITCH. THIS IS A SAFETY DEFECT, BECAUSE THIS A 4WD VEHICLE INTENDED FOR OFF-ROAD USE; HAD THIS PART BROKEN "IN THE MIDDLE OF NOWHERE," A SERIOUS SAFETY-RELATED INCIDENT COULD HAVE OCCURRED. ALSO, THIS PART BROKE A JUST 1540 MILES ON A VEHICLE THAT HAS NOT BE ABUSED. VEHICLE HAD TO BE TOWED TO DEALERSHIP. PART WAS REPLACED UNDER WARRANTY. *TR

Owner-reported narrative. 1,540 miles reported. Look up ODI 10507354 at NHTSA ↗

PASSENGER SIDE AIR BAG WARNING LIGHT INTERMITTENTLY GOES ON W/ SEAT OCCUPIED (120LB ADULT), SEAT BELT FASTENED, SEAT IN NORMAL UPRIGHT POSITION - INDICATING THE AIR BAG IS DEACTIVATED. I ASKED THE DEALER I PURCHASED THE VEHICLE (NEW) FROM ABOUT THIS ANOMALY AT THE FIRST SERVICE (2220 MILES/3MOS) ON 2-20-2013 AND WAS TOLD THERE WAS NOTHING THEY COULD DO - "READ THE OWNERS MANUAL". WE DID MANY DIFFERENT EXPERIMENTS WITH SEATING POSITION, SEAT BACK ANGLE ON SUBSEQUENT TRIPS, WITH NO POSITIVE RESULTS. THE ONLY EXPERIMENT THAT PROVIDED POSITIVE R…

Owner-reported narrative. Look up ODI 10513350 at NHTSA ↗

I FIRST NOTICED MY CLUTCH START TO SLIP UPON LEAVING A STOP SIGN. 15 MILES LATER I WAS STRANDED ON THE SIDE OF THE ROAD WITH NO GEARS. MY CLUTCH HAD GONE OUT ON A BRAND NEW XTERRA WITH 1800 MILES ON IT. IT WAS TOWED TO THE CONCORD, CA NISSAN DEALER WHERE I PURCHASED IT. I WAS BADGERED ON ABUSING THE CAR SINCE IT HAD SOME MUD ON THE TIRES AND THEY INSISTED I DID NOT NO HOW TO DRIVE MANUAL. I HAD TO REPLACE THE CLUTCH AND "BLUED" FLYWHEEL SINCE THEY DID NOT COVER IT WITH THE WARRANTY. THEY SAID THIS WAS THE WORST FLYWHEEL THE SHOP HAS SEEN. HERE…

Owner-reported narrative. 1,782 miles reported. Look up ODI 10520055 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 NISSAN XTERRA. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE CLUTCH AND FLYWHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 23,633. THE VIN WAS UNAVAILABLE.

Owner-reported narrative. 23,633 miles reported. Look up ODI 10563080 at NHTSA ↗

VEHICLE'S ENGINE SEIZED WHILE BEING OPERATED AT A LOW RATE OF SPEED. REASON GIVEN BY DEALERSHIP WHEN TOWED IN WAS NO OIL IN THE ENGINE HOWEVER THERE WAS NO WARNING LIGHT FOR EITHER OIL OR ENGINE ISSUE DISPLAYED AT ANY TIME LEADING UP TO ENGINE FAILURE. THERE HAD BEEN A PREVIOUS OIL LEAK APPROXIMATELY 10 MONTHS EARLIER WHICH HAD BEEN REPAIRED. THERE HAD BEEN NO INCIDENTS IN THE INTERIM AND NO INDICATION OF ISSUES. THERE WAS A RECALL RELATED TO THE OIL FILTER AND ENGINE BUT ACCORDING TO NISSAN, MY VEHICLE WAS NOT SUBJECT TO THE RECALL. I WAS FORC…

Owner-reported narrative. 6,800 miles reported. Look up ODI 10693208 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 NISSAN XTERRA. AFTER MOVING THE VEHICLE FROM A PARKING SPOT, THE CONTACT NOTICED OIL LEAKING UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING ON TWO SEPARATE OCCASIONS, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,500.

Owner-reported narrative. 1,500 miles reported. Look up ODI 10906374 at NHTSA ↗

I'M FILING A COMPLAINT BEFORE I HAVE AN INCIDENT. I OWN A NISSAN XTERRA. MANY OTHER NISSAN XTERRA OWNERS HAVE HAD SPONTANEOUS SIDE CURTAIN AIR BAG DEPLOYMENT WHEN TRAVELING VERY SLOWLY, GENERALLY ON DIRT ROADS. SOME OF THESE DEPLOYMENTS HAVE CAUSED INJURIES. THE PROBLEM APPEARS TO BE COMMON ON ALL 2ND GENERATION NISSAN XTERRAS (2006-2016). THE FOLLOWING LINKS ARE TO XTERRA FORUM THREADS AND PROFESSIONAL PUBLICATIONS ABOUT RANDOM AIRBAG DEPLOYMENT IN XTERRAS. THERE ARE MANY MORE DOCUMENTED CASES OF THIS ONLINE, THE LINKS BELOW ARE A TASTE. THIS…

Owner-reported narrative. Look up ODI 10909867 at NHTSA ↗

PREMATURE CLUTCH FAILURE ON MY MANUAL TRANSMISSION. LESS THAN 48000 MILES ON THE ODOMETER AND THE CLUTCH IS GONE. THIS IS FAR TOO LITTLE TRAVEL FOR THE CLUTCH TO BE FAILING AT. DEGRADATION HAS ADVANCED RAPIDLY OVER A MATTER OF WEEKS AND DAYS AND NOW I FEAR HAVING MY FAMILY RIDE IN THE VEHICLE IN CASE THEY BECOMING STRANDED OR NEED TO AVOID A CRASH AND CANNOT DUE TO LOSS OF POWER. GENERAL CONSENSUS IS THAT THE CLUTCH IS TOO SMALL FOR THIS TRUCK. NISSAN CLAIMS THIS IS A WEAR ITEM AND WILL NOT COVER REPLACEMENT UNDER WARRANTY, OR ADMIT THERE IS…

Owner-reported narrative. 47,291 miles reported. Look up ODI 11011458 at NHTSA ↗

Reported: 2011-12-19 (December 19, 2011)

NISSAN IS RECALLING CERTAIN MODEL YEAR 2011 INFINITI FX, MODEL YEAR 2012 INFINITI M, MODEL YEAR 2011-2012 NISSAN FRONTIER, MODEL YEAR 2011-2012 NISSAN XTERRA, MODEL YEAR 2011-2012 NISSAN PATHFINDER, AND MODEL YEAR 2012 NISSAN NV VEHICLES. SOME OF THE BOLTS THAT CONNECT THE ENGINE OIL COOLER AND THE ENGINE OIL FILTER TO THE ENGINE IN THESE VEHICLES MAY HAVE BEEN MANUFACTURED TO BELOW SPECIFICATION STRENGTH. AS A RESULT, THE BOLT MAY BREAK AT THE OIL FILTER ATTACHMENT POINT AND CAN CAUSE AN ENGINE OIL LEAK.

Consequence: IF THERE IS AN ENGINE OIL LEAK, THE ENGINE OIL PRESSURE WOULD DROP AND THE ENGINE COULD SEIZE, INCREASING THE RISK OF A CRASH.

Remedy: NISSAN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE CONNECTOR BOLTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 30, 2012. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Reported: 2012-09-20 (September 20, 2012)

Nissan is recalling certain model year 2012 Frontier, Pathfinder, and Xterra two-wheel drive vehicles manufactured from June 19, 2012, through July 12, 2012. These vehicles may have been equipped with front wheel hubs that may not meet the design hardness specifications. A wheel hub that was manufactured below hardness specification may wear prematurely and eventually crack.

Consequence: If the vehicle is driven in this condition, the wheel hub may break, possibly resulting in a vehicle crash.

Remedy: Nissan will notify owners, and dealers will replaced the left and right side front wheel hub assemblies free of charge. The safety recall began on October 22, 2012. Owners may contact Nissan Customer Service at 1-800-647-7261.