2001 Nissan XTERRA: complaints, problems and recalls

WHEN APPLYING THE BRAKES AFTER A SHORT PERIOD OF TIME THE PEDAL WILL SINK APPROXIMATELY 1 - 2 INCHES. I HAVE TAKEN THE VEHICLE SEVERAL TIMES TO THE DEALER SINCE I PURCHASED IT. THE FIRST TIME I WAS TOLD THAT THEY REPLACE THE BAKE BOOSTER. THE SYMPTOMS CONTINUED. WHEN I RETURN TO THE DEALER I WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE BRAKES. THE PROBLEM CONTINUES EVERY TIME THAT I HAVE TO APPLY THE BRAKES FOR MORE THAT A FEW SECONDS. TS

Owner-reported narrative. 150 miles reported. Look up ODI 10000163 at NHTSA ↗

WHILE DRIVING THE VEHICLE ON RAINING DAYS THE HORN WONT WORK. DEALER HAS INSPECTED THE VEHICLE AND REPLACED THE MODULE SENSOR. TS THE PROBLEM HAS DEVELOPED AGAIN. *JG

Owner-reported narrative. 15,000 miles reported. Look up ODI 10001533 at NHTSA ↗

WHILE DRIVING THE VEHICLE CAUGHT ON FIRE UNDER THE HOOD. *TS

Owner-reported narrative. 76,000 miles reported. Look up ODI 10005884 at NHTSA ↗

VEHICLE STOPPED RUNNING ON I-287N NEAR MAHWAH, NJ., POST PRESIDENT'S DAY BLIZZARD. CONDITIONS WERE VERY DANGEROUS DUE TO SEMI TRUCK TRAFFIC AND SNOW/ICE PACK IN EMERGENCY LANE WHICH PREVENTED PULLING VEHICLE ALL THE WAY OFF THE HIGHWAY. STRANDED ON SIDE OF THE HIGHWAY FOR SEVERAL HOURS IN BELOW FREEZING COLD UNTIL NJ STATE POLICE SENT TOW TRUCK. TOWED TO NISSAN DEALER, DIAGNOSED FUEL SENDING UNIT FAILURE PART #250604S415. TEN DAYS LATER, PART IS STILL ON BACK ORDER WITH NO IDEA WHEN IT WILL BE AVAILABLE. *JB

Owner-reported narrative. 62,000 miles reported. Look up ODI 10008225 at NHTSA ↗

I WAS ON MY WAY HOME FROM WORK AND ON RT17 WHICH IS VERY BUSY AROUND RUSH HOUR WITH TRACTOR TRAILERS AND PLENTY OF CARS, ALL OF A SUDDEN MY 2001 XTERRA STALLED OUT AT THE STOP LIGHT, THEN WOULD NEVER START AGAIN, IT TOOK 30 MINUTES TO GET THE TRUCK OF THE ROAD BECAUSE THERE WAS SO MUCH TRAFFIC, I HAD IT TOWED TO RADLEY CHEVROLET BECAUSE I CALLED NISSAN, AND THEY ADVISED ME MY WARRANTY RAN OUT AND IT WOULD BE AT LEAST 200.00 BEFORE THEY COULD EVEN LOOK AT IT? ONCE TO THE DEALER WHICH MY WARRANTY JUST RAN OUT, AND THEY SAID THERE WAS NOTHING WRO…

Owner-reported narrative. 36,850 miles reported. Look up ODI 10013659 at NHTSA ↗

SUV HAS BEEN TO DEALER THREE TIMES DUE TO LEAKING SUNROOF AND PASSENGER SIDE SEAT BELT THAT LOCKS AND COULD DECAPITATE THE PASSENGER. *JB

Owner-reported narrative. Look up ODI 10016429 at NHTSA ↗

WHILE DRIVING THE PASSENGER SEAT BELT LOCKED UP. *NLM

Owner-reported narrative. Look up ODI 10017473 at NHTSA ↗

XTERRA WAS MAKING A POPPING SOUND WHEN TURNING. AFTER TAKING DRIVERS SIDE WHEEL OFF,I DISCOVERED BROKEN SWAY BAR BRACKET (LEFT HAND SIDE). TOP BOLT MISSING THREADS NOT DAMAGED WHICH RESULTED IN BROKEN FRAME OF VEHICLE. NO OTHER DAMAGE TO UNDERSIDE OF XTERRA. SUSPECT TOP BOLT NEVER INSTALLED CORRECTLY. NISSAN REFUSED TO WARRANTY THE FRAME DESPITE MY HAVING AN EXTENDED WARRANTY. HAD XTERRA REPAIRED BY REPUTABLE BODY SHOP. EXPERT BODY SHOP OPINION CONCURS WITH BOLT BACKING OUT AND CAUSING DAMAGE. BODY SHOP RECOMMEND REPAIR BEFORE USING XTE…

Owner-reported narrative. 42,833 miles reported. Look up ODI 10018515 at NHTSA ↗

Reported: 2002-11-12 (November 12, 2002)

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.

Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Reported: 2002-11-12 (November 12, 2002)

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE FUEL TANK INLET SHUTTER VALVE DOES NOT MEET THE SEALING PERFORMANCE SPECIFICATION.

Consequence: UNDER CERTAIN CONDITIONS SUCH AS HIGH AMBIENT TEMPERATURE AND WHEN WINTER GRADE GASOLINE IS BEING SOLD, FUEL COULD SPILL FROM THE FILLER INLET AS THE TANK IS BEING FILLED. IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK INLET SHUTTER VALVE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DECEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Reported: 2004-05-24 (May 24, 2004)

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.

Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.