2007 Newmar KOUNTRY STAR: complaints, problems and recalls

2007 NEWMAR KOUNTRY STAR WINDSHIELD WIPERS INOPERATIVE. *TS THE COACH HAS A ONE PIECE WINDSHIELD. THE WINDSHIELD WIPERS ON THE DRIVER'S SIDE WILL NOT REMAIN IN CONTACT WITH THE WINDSHIELD WHEN THERE IS THE SLIGHTEST WIND. THIS CAUSED POOR VISIBILITY.

Owner-reported narrative. Look up ODI 10174311 at NHTSA ↗

2007 NEWMAR KOUNTRY STAR. SPARTAN MOTORS INC SAFETY RECALL ON ENGINES. CUSTOMER WANT THEM TO REDO THE RECALL**NAR**CC *JB

Owner-reported narrative. Look up ODI 10199267 at NHTSA ↗

The contact owns a 2007 Newmar Kountry Star. The contact stated that three of the four mounting bolts on the satellite dish were fractured. The contact decided to remove the satellite dish to prevent a potential failure. The contact initially notified the vehicle manufacturer of the failure and referred him to the maker of the satellite dish. The satellite dish manufacturer stated that the installation of the satellite was the responsibility of the vehicle manufacturer. Neither of the manufacturers had taken responsibility for the failure. The …

Owner-reported narrative. 75,000 miles reported. Look up ODI 11429459 at NHTSA ↗

Reported: 2006-07-26 (July 26, 2006)

CERTAIN CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148). THEY WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR NEWMAR AT 574-773-7791.

Reported: 2007-08-08 (August 8, 2007)

ON CERTAIN MOTOR HOMES BUILT ON SPARTAN MM CHASSIS WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence: IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: NEWMAR IS WORKING WITH SPARTAN AND CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 , SPARTAN AT 517-543-6400, OR NEWMAR AT 1-574-773-7791.

Reported: 2008-07-17 (July 17, 2008)

NEWMAR IS RECALLING 772 MY 2004-2005 AMERICAN STAR, KOUNTRY AIRE, MOUNTAIN AIRE, MY 2003-2006 KOUNTRY STAR, MY 2007 X-AIRE FIFTH WHEEL TRAILERS; MY 2007 BAY STAR, MY 2004-2007 KOUNTRY STAR, MY 2004-2006 MOUNTAIN AIRE, MY 2003-2005 SCOTTSDALE CLASS A MOTOR HOMES; AND MY 2004-2006 DUTCH STAR, MY 2003-2006 KOUNTRY STAR, MY 2004-2006 MOUNTAIN AIRE DIESEL PUSHER MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy: NEWMAR IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR NEWMAR AT 1-574-773-7791.

Reported: 2017-12-15 (December 15, 2017)

Newmar Corporation (Newmar) is recalling various 1995-2018 motorhomes. A list of the affected vehicles available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V809-2309.pdf. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Newmar will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 7, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information or owners may contact Newmar customer service at 1-574-773-7791. Newmar's number for this recall is 17E-062.