2000 New Flyer D60HF: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
4 distinct recall campaigns
Not available median reported failure mileage
Scope: 2000 model year. Data snapshot: . 0 complaints include usable failure mileage.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
4 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
03V248000 · Service Brakes, Air:Supply:Quick Release Valve
Reported: 2003-07-14 (July 14, 2003)
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE SERVICE BRAKE RELEASE TIMING AND PARK BRAKE APPLY TIMING ARE OUT OF COMPLIANCE WITH THE STANDARD.
Consequence: THESE VEHICLES DO NOT COMPLY WITH FEDERAL STANDARDS.
Remedy: TO RESOLVE THE ISSUE OF NONCOMPLIANCE WITH THE SERVICE BRAKE RELEASE TIMING, DEALERS WILL RE-ROUTE THE REDUNDANT SIGNAL LINE TO THE CENTER AXLE RELAY VALVE AND THE CENTER AND REAR RELAY VALVES WILL BE SWAPPED. OWNER NOTIFICATION BEGAN JULY 17, 2003. OWNERS SHOULD CONTACT NEW FLYER AT 1-204-982-8400.
NHTSA campaign record ↗04V042000 · Wheels
Reported: 2004-02-02 (February 2, 2004)
ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.
Consequence: THE DRIVER COULD LOSE CONTROL OF THE VEHICLE WHEN DRIVING AWAY FROM A PARKED POSITION, WHICH COULD RESULT IN A CRASH.
Remedy: NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED RINGS AND HARNESSES) IF NOT ALREADY EQUIPPED WITH ABS; AND WILL REVISE PLC PROGRAMMING. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.
NHTSA campaign record ↗07V268000 · Steering
Reported: 2007-06-11 (June 11, 2007)
ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
Consequence: EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.
Remedy: THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
NHTSA campaign record ↗08V053000 · Equipment:Appliance:Air Conditioner
Reported: 2008-02-05 (February 5, 2008)
NEW FLYER IS RECALLING 431 MY 1996-2001 D60HF DIESEL TRANSIT BUSES EQUIPPED WITH A ROOFTOP AIR CONDITIONING EVAPORATOR. THE EVAPORATOR DRAIN LINES MAKE CONTACT WITH COMPONENTS (BALLAST ASSEMBLIES) WITHIN THE INTERIOR LIGHTING PANEL BELOW THE DRAIN LINE PORT. THIS CAN RESULT IN EITHER DAMAGE TO THE DRAIN LINE, WHICH INTRODUCES MOISTURE INTO THE LIGHTING PANEL, OR RESTRICTION OF THE LINE WHICH RESULTS IN A BACK-UP AND OVERFLOW OF MOISTURE THROUGH THE FRESH AIR RETURN VENT AND BACK INTO THE LIGHTING PANEL.
Consequence: MOISTURE IN SUFFICIENT QUANTITIES WITHIN THE LIGHTING PANEL MAY RESULT IN A SHORTING OF THE ELECTRICAL COMPONENTS AND A VEHICLE FIRE.
Remedy: NEW FLYER WILL INCORPORATE AN ELBOW FITTING INTO THE DRAIN LINE WHERE IT ENTERS THE LIGHTING PANEL FROM THE ROOF, WHICH WILL PROMOTE CLEARANCE BETWEEN THE LINE AND THE BALLAST ASSEMBLY. THE RECALL BEGAN ON FEBRUARY 6, 2008. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4803.
NHTSA campaign record ↗