2001 National Rv SURFSIDE: complaints, problems and recalls

TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…

Owner-reported narrative. 40,500 miles reported. Look up ODI 10334558 at NHTSA ↗

AUTO PARK BRAKE SYSTEM HAS FAILED 3 TIMES. REAR WHEELS TRIED TO LOCK UP AND DID ONCE I SLOWED THE COACH . GREEN PRESSURE SWITCH FAILED WHILE GOING DOWN THE ROAD. LIGHT SWITCH FAILED LEAKED FLUID , DASH LIGHT "CAME ON" , REAR WHEELS DID NOT LOCK UP THIS TIME. GRAY LITE S/W FAILED AGAIN LEAKING FLUID "DASH LIGHT CAME ON AGAIN. THE SWITCHING SYSTEM SEEMS TO BE UNRELIABLE, CAUSES UNSAFE UNEXPECTED LOCK UP ON REAR WHEELS WITH NO NOTICE, IF IN TRAFFIC VERY DANGEROUS SITUATION.

Owner-reported narrative. 60,000 miles reported. Look up ODI 10971101 at NHTSA ↗

Reported: 2003-02-21 (February 21, 2003)

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPOSITION A LIGHT BULT FROM ONE SOCKET TO ANOTHER, AND REATTACH A WIRE FROM ONE CONNECTOR TO ANOTHER. OWNER NOTIFICATION BEGAN SEPTEMBER 2, 2003. OWNERS SHOULD CONTACT NATIONAL RV AT 1-800-439-3653. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE <A HREF=HTTP://WWW.CACB.USCOURTS.GOV>HTTP://WWW.CACB.USCOURTS.GOV</A> . ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT <A HREF=HTTP://WWW.OMNIMGT.COM/NATIONALRV>HTTP://WWW.OMNIMGT.COM/NATIONALRV</A> . NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.

Reported: 2007-06-04 (June 4, 2007)

CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: NATIONAL RV WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST OWNERS IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR NATIONAL RV AT 1-800-999-7260, EXT. 4335. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE WWW.CACB.USCOURTS.GOV. ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT WWW.OMNIMGT.COM/NATIONALRV. NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.