1998 Mitsubishi MONTERO: complaints, problems and recalls

CRUISE WIL NOT DISENGAGE DUE TO STOP LAMP SWITCH FAILURE

Owner-reported narrative. 49,761 miles reported. Look up ODI 10004911 at NHTSA ↗

WHILE PASSING ANOTHER VEHICLE AT 60 MPH GAS PEDAL BECAME STUCK AND VEHICLE ACCELERATED TO ABOVE 80 MPH. PUMPING THE BRAKE PEDAL WAS OF NO USE, BUT USING THE EMERGENCY BRAKES EVENTUALLY STOPPED THE VEHICLE.*AK

Owner-reported narrative. 4,800 miles reported. Look up ODI 10037879 at NHTSA ↗

WHEN VEHICLE EXCEEDS SPEEDS OF 60 MPH STEERING WHEEL VIBRATES. CAUSE OF VIBRATION IS UNDETERMINED. *AK

Owner-reported narrative. 68,000 miles reported. Look up ODI 10039728 at NHTSA ↗

CRANKSHAFT BOLT BROKE, CAUSING TIMING BELT PULLEY/SPROCKET TO FALL OFF. THIS IS AN INTERFERENCE ENGINE AND COULD HAD CAUSED SERIOUS DAMAGE. THERE HAS BEEN A RECALL FOR THE MONTERO 3.0 ENGINE FOR SAME PROBLEM..WHY NOT THE 3.5? INTEND TO CONTACT THE CORPORATION COMMISSION. VERY POOR DESIGN.*AK

Owner-reported narrative. Look up ODI 10068313 at NHTSA ↗

WHILE DRIVING 35 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A THREE VEHICLE PILE UP. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED MAJOR HEAD INJURIES, AND PASSENGER BROKE HIS SHOULDER. *AK

Owner-reported narrative. 85,000 miles reported. Look up ODI 10099789 at NHTSA ↗

MINOR PROBLEM WITH SWELLING IN DRIVER SIDE AIRBAG, 1998 MITS MONTERO, VIN[XXX]. PURCHASED NEW IN SANTA MARIA CA. THE SWELLING AIRBAG HAS CAUSED CONTINUOUS HORN ACTIVATION. THE HORN HAS BEEN DISCONNECTED. QUESTIONS: DO YOU HAVE ANY OTHER INCIDENTS THAT INDICATE A TREND WHERE THE DRIVER SIDE AIR BAG HAS AFFECTED THE HORN? IS THIS A SAFETY ISSUE? THE DEALER IN SAN ANTONIO SAYS THE AIRBAG STILL WORKS BUT CAN'T BE REPLACED UNDER WARRANTY SINCE THE VEHICLE HAS OVER 100,000 MILES ON IT. REPLACEMENT PART QUOTED IS MR390111, MODULE AIR BAG, D…

Owner-reported narrative. 106,000 miles reported. Look up ODI 10136122 at NHTSA ↗

CRANKSHAFT PULLEY BROKE OFF. LOST BELTS, LOST POWER STEERING AND ALTERNATOR POWER . REPAIR SHOP SAYS ENGINE MUST BE REPLACED. *NM

Owner-reported narrative. Look up ODI 10165676 at NHTSA ↗

TL*THE CONTACT OWNS A 1996 MITSUBISHI MONTERO. WHILE DRIVING 40 MPH,THE POWER STEERING FAILED. THE MECHANIC STATED THAT THE FRONT CRANK SHAFT PULLEY BOLT DETACHED AND CAUSED THE PULLEY TO WOBBLE. THIS FAILURE WAS ENCOMPASSED IN RECALL # 00V311000. THE DEALER STATED THAT THIS VEHICLE WAS EXCLUDED FROM THE RECALL. HOWEVER, THE CONTACT STRONGLY BELIEVED OTHERWISE. THE CURRENT AND FAILURE MILEAGE WERE 94,000.*AK

Owner-reported narrative. 94,000 miles reported. Look up ODI 10187107 at NHTSA ↗

Reported: 2004-09-01 (September 1, 2004)

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.

Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.

Reported: 2020-01-23 (January 23, 2020)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 1998-2000 Montero vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.

Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.

Remedy: MMNA will notify owners, and dealers will replace the air bag inflator, free of charge. The recall began February 25, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-001.

Reported: 1998-09-02 (September 2, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.

Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE.

Remedy: DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING.

Reported: 1998-09-09 (September 9, 1998)

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER.

Consequence: BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP.

Remedy: DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRECT. IF THERE IS EVIDENCE OF BRAKE LINE WEAR, THE BRAKE LINE WILL BE REPLACED.