1995 Mitsubishi GALANT: complaints, problems and recalls

CONSUMER HAS HAD 2 DIFFERENT LOWER CONTROLL ARM BALL JOINT FAILURES. WHILE DRIVING IN 10/02, RIGHT FRONT WHEEL "CAVED IN" CAUSING LOSS OF VEHICLE CONTROL. 2ND FAILURE WHILE DRIVING ON 06/08/03 THE LEFT FRONT WHEEL "CAVED IN". *AK

Owner-reported narrative. Look up ODI 10022621 at NHTSA ↗

WHILE DRIVING, THE BOLT SECURING THE CRANKSHAFT PULLEY BECAME LOOSE AND BROKE THE ENGINE. *AK THE OUTER RING SEPARATED AND WAS REPLACED. *SC *JB

Owner-reported narrative. 100,000 miles reported. Look up ODI 10050387 at NHTSA ↗

ENGINE MOTOR MOUNTING WORE OUT PREMATURELY, CAUSING TRANSMISSION TO JUMP WHEN IT WAS ENGAGED FROM NEUTRAL TO DRIVE. DEALER NOTIFIED. *AK

Owner-reported narrative. Look up ODI 10073534 at NHTSA ↗

WHILE DRIVING BALL JOINTS SEPARATED AND THE FRONT END OF THE VEHICLE COLLAPSED.*MR THIS FAILURE OCCURRED PRIOR TO RECEIVING RECALL NOTICE SR-04-001. THE LETTER INDICATED THAT A PRIOR NOTICE WAS SENT IN APRIL 2001, UNFORTUNATELY THE CONSUMER NEVER RECEIVED THAT NOTICE BECAUSE THE VEHICLE WAS NOT PURCHASED UNTIL JULY 2002. THE CONSUMER REQUESTED REIMBURSEMENT BUT HAS NOT RECEIVED IT YET. *NM

Owner-reported narrative. Look up ODI 10082070 at NHTSA ↗

THE BALL JOINTS ON THE RIGHT SIDE OF THE VEHICLE CAME OFF WHILE DRIVING.*MR AS A RESULT THE VEHICLE COLLAPSED ONTO THE GROUND ON THE DRIVER'S SIDE, JAMMING THE DRIVER'S DOOR SHUT. THE VEHICLE WAS TOWED TO A SERVICE STATION WHERE IT WAS DETERMINED THAT THE LEFT SIDE BALL JOINT HAD SEPARATED AND BROKE THE AXLE OF THE CAR. ONE MONTH LATER THE CONSUMER RECEIVED A RECALL NOTICE WHICH REFERENCED A BALL JOINT PROBLEM. THE CONSUMER CALLED THE MANUFACTURER AND WAS TOLD TO TAKE THE VEHICLE TO THE DEALER TO HAVE THE DEALER INSPECT/INSTALL THE BALL JOI…

Owner-reported narrative. 61,889 miles reported. Look up ODI 10083870 at NHTSA ↗

WHILE MAKING A LEFT TURN OUT OF THE PARKING LOT VEHICLE FAILED TO MOVE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT BOTH FRONTAL LOWER BALL JOINTS NEEDED TO BE REPLACED. *AK

Owner-reported narrative. Look up ODI 10087236 at NHTSA ↗

WHILE DRIVING 65 MPH, THE VEHICLE STALLED. THE CONSUMER WAS NOT ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO A GARAGE. *AK THE CONSUMER WAS INFORMED THAT THE TRANSMISSION WAS SHOT. *SC

Owner-reported narrative. Look up ODI 10099699 at NHTSA ↗

DT: CONSUMER HAD A 1995 MITSUBISHI GULANT. CONSUMER TOOK VEHICLE TO A LOCAL GARAGE AND A MECHANIC LOOKED AT VEHICLE AND FOUND THAT THE CROSS MEMBER THAT HELD THE ENGINE BLOCK AND THE FRONT WHEELS TOGETHER RUSTED ON THE SIDES THAT CONNECTED TO THE PLATES. THEN TOOK VEHICLE TO DEALER, AND DEALER REPLACED THE CROSS MEMBER. CONSUMER WAS WORRIED THAT THIS MAY BE A COMMON PROBLEM FOR THIS MODEL. *AK

Owner-reported narrative. Look up ODI 10131389 at NHTSA ↗

Reported: 2000-08-25 (August 25, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. CRACKS CAN OCCUR IN THE TOP OF THE FUEL TANK DUE TO AN IMPROPER SPOT WELD ON THE BAFFLE PLATE TO THE TOP PORTION OF THE FUEL TANK.

Consequence: A CRACK IN THE FUEL TANK COULD ALLOW FUEL OR FUMES TO ESCAPE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE UPPER SURFACE OF THE FUEL TANK FOR ANY SIGNS OF CRACKING. IF NO CRACKING OR LEAKING IS FOUND, DEALERS WILL INSTALL A SEALING PROTECTOR PLATE. IF ANY CRACKING OR LEAKAGE IS FOUND, DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY.

Reported: 2000-12-18 (December 18, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Reported: 1998-09-08 (September 8, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. WHEN THE STOP LAMP SWITCH WAS ASSEMBLED, GREASE WAS INADVERTENTLY APPLIED TO THE CONTACT POINT. THIS CAN CAUSE THE CONTACT POINT TO HEAT UP CAUSING INTERNAL OPERATION ELEMENTS TO MELT ALLOWING THE SWTICH TO BECOME STUCK IN ON OR OFF POSITION.

Consequence: THIS CONDITION CAN CAUSE THE ANTI-LOCK BRAKING SYSTEM (ABS) WARNING LIGHT TO COME ON.

Remedy: DEALERS WILL INSTALL A RELAY AND REPLACE THE BRAKE LAMP SWITCH.

Reported: 1999-04-05 (April 5, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Reported: 1999-04-05 (April 5, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT IN JAPAN. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.