2019 Mini COOPER: complaints, problems and recalls

THIS IS A BRAND MODEL AND BRAND NEW CAR THAT I HAD JUST PURCHASED AND WAS DRIVING HOME FROM BUYING IT- I HAD NOT EVEN OWNED FOR A COUPLE OF HOURS. WHILE ON MY WAY HOME VEHICLE MALFUNCTIONED AND HAD NEAR FATAL COLLISION. WHILE DRIVING ON HIGHWAY - AT HIGHWAY SPEED I WAS UNABLE TO CONTROL CAR AND MAINTAIN SPEED. ENGINE SEEMINGLY LOCKED UP AND AS I WAS UNABLE TO CONTROL CAR ALMOST CAUSED A NEAR FATAL COLLISION AS CAR BEHIND ME DID NOT REALIZE I WAS LOSING SPEED. TAKEN TO DEALERSHIP AND THEY NOTED THE CRANKSHAFT SPEED PULSE GENERATOR SENSOR HAD MA…

Owner-reported narrative. 5 miles reported. Look up ODI 11115073 at NHTSA ↗

THIS IS SECOND INCIDENT THAT OCCURRED WITH BRAND NEW MINI COOPER 2019 WITH SAME EXACT ISSUE THAT AGAIN ALMOST CAUSED A NEAR FATAL ACCIDENT. WHILE DRIVING ON HIGHWAY, AT HIGHWAY SPEED THE CAR PRECIPITOUSLY MALFUNCTIONED AND CAR LOCKED UP AND WOULD ALLOW ME TO MAINTAIN SPEED- NOR ACCELERATE. I WAS UNABLE TO MAINTAIN SPEED OF THE CAR THEREFORE STARTED TO LOSE SPEED AND DECELERATE. THE VEHICLES BEHIND ME COULD NOT TELL THAT I WAS SUDDENLY LOSING SPEED AND I WAS ALMOST INVOLVING A NEAR FATAL COLLISION AGAIN. I HAD BEEN DRIVING ON THE HIGHWAY FOR ABO…

Owner-reported narrative. 70 miles reported. Look up ODI 11115082 at NHTSA ↗

WHILE DRIVING ON ROAD DRIVER'S SIDE ROLL OVER BAR JUST POPPED UP. I'M CONCERNED THAT IF CAR WOULD HAVE ROLLED OVER PASSENGER WOULD HAVE BEEN CRASHED. ALREADY NOTIFIED MIN ICOOPER WAITING FOR A RESPONSE. CAR WILL BE SERVICE THIS WEEK.

Owner-reported narrative. 18,200 miles reported. Look up ODI 11349959 at NHTSA ↗

Entire Driver Side Tail Lamp assembly stopped working (includes running light, brake light, reverse light, and blinker). Dash board did display warning (while driving) of lights malfunction, but nevertheless stopped working while driving. Upon further Inspection, found a “short” / melted pig tail (electrical connector) connecting to the rear of the lamp assembly. (Both the connector and pig tail showed signs of melted plastic/fire hazard). After further investigation, I realized this is not an isolated incident as I found multiple threads/posts…

Owner-reported narrative. Look up ODI 11452147 at NHTSA ↗

Center console phone charger Center console is and enclosed component and when a cell phone is placed in the console and used for Bluetooth navigation and or phone calls it shuts down the system. The phone heats to such a temp that all phone operations and interaction with the vehicle system freeze or shut down and the phone continues to heat. I have spoken to the dealership and have been told it's a problem. When I communicated to MINI USA they acted as if this had never been reported. As far as warnings all car play functions slow down then…

Owner-reported narrative. Look up ODI 11481612 at NHTSA ↗

Foul odor coming from vents when starting up AC, and after turning off for 10 - 15 minutes.

Owner-reported narrative. Look up ODI 11482310 at NHTSA ↗

I am writing regarding the failure of the steering column on my 2019 Mini Cooper Hardtop. The incident occurred on December 31, 2022. I drove my car to a residential location in Seattle, parked and locked the vehicle. When I returned to my car and started it up to move it, I realized I had no control of the car because the steering wheel was spinning uncontrollably. When the car was towed to Seattle Mini, the AAA tow truck driver and the dealership service department personnel receiving the car said they had seen nothing like this before. Seatt…

Owner-reported narrative. Look up ODI 11501907 at NHTSA ↗

*The condensate drain hose is not properly draining the condensate from the vehicle. *Breathing in mold and didn't know it *Yes the problem was confirmed by the dealer *The dealer inspected *no warnings, no recalls

Owner-reported narrative. Look up ODI 11552302 at NHTSA ↗

Reported: 2018-07-11 (July 11, 2018)

BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the crankshaft sensor, free of charge. The recall began September 6, 2018. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2019-08-14 (August 14, 2019)

BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X1 sDrive28i, X1 xDrive28i, 2019 X2 xDrive28i, MINI Cooper S Convertible, Countryman, and John Cooper Works Countryman vehicles. The steering gear tie rod may have been assembled incorrectly, which may result in excessive wear of the tie rod end, eventually causing it to break.

Consequence: A broken steering tie rod would lead to a loss of vehicle control, increasing the risk of a crash.

Remedy: BMW will notify owners, and dealers will inspect the vehicles and replace the tie rods and ball joints as necessary, free of charge. The recall began October 11, 2019. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.