2014 Mini COOPER: complaints, problems and recalls

GEAR SHIFT COMPLETELY BECAME DETACHED AT SPEED. TWO MAGAZINES HAVE HAD SAME ISSUE. THIS COULD EASILY CAUSE A FATAL ACCIDENT IF IT HAPPENED TO SOMEONE THAT ISN'T AS CALM AS MYSELF. CONSUMER REPORTS JUST HAD THIS SAME ISSUE HAPPEN. AFFECTS 2014 MINI COOPER HARDTOP MODELS, CHASSIS CODE F56. HTTP://WWW.CONSUMERREPORTS.ORG/CRO/NEWS/2014/06/2014-MINI-COOPER-S-SHIFTER-COMES-OFF-WHILE-DRIVING/INDEX.HTM. *TR

Owner-reported narrative. 2,466 miles reported. Look up ODI 10598798 at NHTSA ↗

ON TWO OCCASIONS WHEN DRIVING, THE AUTO START AND STOP FUNCTION SHUT THE ENGINE OFF, WHERE I HAD TO PUT THE CAR IN PARK & RESTART IT. HAPPENED ONCE ON A FLAT SURFACE AND ONCE ON A DOWNHILL SLOP AT A STOP. ALSO, I'VE ONLY HAD THE CAR ONE MONTH AND THE DRIVETRAIN LIGHT CAME AND THE MINI SERVICE REPAIR SAYS IT WAS FAULT #20A503 WITH THE WATER PUMP. PLEASE ADVISE! *TR

Owner-reported narrative. 1,500 miles reported. Look up ODI 10605086 at NHTSA ↗

ON TWO OCCASIONS (7/19/14 AND 7/29/14), THE ENGINE CUT-OFF, PUTTING THE CAR IN "ACCESSORY MODE." ON BOTH OCCASIONS, I WAS DRIVING ON A FLAT ROAD, AT LOW SPEED. THERE WAS NO ABILITY TO DRIVE THE VEHICLE WITHOUT COMPLETELY STOPPING, PUTTING THE CAR IN PARK, AND RESTARTING THE CAR. AS A RESULT OF BEING IN ACCESSORY MODE, I HAD NO POWER STEERING AND WAS ONLY ABLE TO GLIDE OVER TO THE SIDE OF THE ROAD. A MESSAGE APPEARED ON THE CAR'S SCREEN: "TRANSMISSION NOT IN PARK, VEHICLE MAY ROLL." I PURCHASED THIS VEHICLE 3 MONTHS AGO. I AM VERY CONCERNE…

Owner-reported narrative. 3,000 miles reported. Look up ODI 10617503 at NHTSA ↗

LEG BURN FROM HOT EXHAUST PIPE WHILE UNLOADING ITEMS FROM TRUNK. LEANED AGAINST REAR BUMPER WITH BARE LEG. *TR

Owner-reported narrative. 4,600 miles reported. Look up ODI 10618846 at NHTSA ↗

NEARLY RAN OUT OF GASOLINE BECAUSE THE GAS GAUGE IS NOT ACCURATE. AT AN INDICATED 1/2 FULL, THE CAR IS DOWN OVER 9 GALLONS AND THE TANK HOLD ABOUT 12.5 GALLONS. USING THE GAS GAUGE THERE IS NO WAY TO TELL HOW MUCH FUEL REMAINS IN THE TANK. *TR

Owner-reported narrative. 9,000 miles reported. Look up ODI 10629419 at NHTSA ↗

THERE WAS NO ONE SITTING IN THE FRONT PASSENGER SEAT, BUT MY IPOD WAS ON THE SEAT. A "FASTEN SEAT BELT" WARNING WENT OFF WHILE I WAS DRIVING AT HIGHWAY SPEEDS. I HAD BEEN DRIVING FOR OVER 30 MINUTES WHEN THIS HAPPENED. WHILE DRIVING, I REMOVED THE IPOD FROM THE SEAT, BUT THE WARNING DID NOT STOP. BECAUSE IT WAS NOT IMMEDIATELY POSSIBLE TO PULL OVER, I HAD TO IGNORE SAFETY LIGHTS AND CHIMES UNTIL I COULD PULL OVER. ALTHOUGH THIS FALSE WARNING HAS HAPPENED SEVERAL TIMES WITH LIGHT OBJECTS IN THE PASSENGER SEAT, IT DOES NOT HAPPEN CONSISTENTL…

Owner-reported narrative. 10,000 miles reported. Look up ODI 10632960 at NHTSA ↗

2014 MINI COOPER S HARDTOP MANUAL TRANSMISSION FAIL. THE VEHICLE ABRUPTLY DROPS OUT OF 1ST GEAR WHEN STARTING FROM A STOP, CAUSING THE CAR TO SHIFT INTO NEUTRAL. THIS FIRST OCCURRED ON NOV 17 AND HAS OCCURRED WITH INCREASING FREQUENCY TO NOW HAPPENING ABOUT 9/10 TIMES THE CAR IS STARTING FROM A STOP. THIS MAKES THE VEHICLE UNSAFE TO DRIVE IN TRAFFIC, MERGES, AND ON HILLS. NOTE, THIS CAR HAD A DEALER REQUIRED PROGRAMMING UPDATE ON OCTOBER 26 2014. *TR

Owner-reported narrative. 5,600 miles reported. Look up ODI 10660274 at NHTSA ↗

THIS WOULD BE THE SECOND TIME IN WHICH I HAVE HAD TO VISIT NICK ALEXANDER IMPORTS OF DOWNTOWN LOS ANGELES, DUE TO THE MALFUNCTIONING OF MY VEHICLE, SPECIFICALLY THE ENGINE. THE FIRST TIME, MY CAR HAD STALLED ON THE FREEWAY DURING RUSH HOUR TIME. THE SERVICE SPECIALIST AT THE DEALERSHIP ATTRIBUTED MY CAR STALLING AS A SYSTEM UPDATE ISSUE AND FOUND THAT THEIR WAS A RECALL ON A VEHICLE PART (A NUT THAT SECURES THE SPARE TIRE TO THE CAR THAT COULD BECOME LOOSE DURING DRIVING), WHICH HE REPLACED. THIS SECOND TIME, WHICH WAS ON JANUARY 5TH, 2015, …

Owner-reported narrative. Look up ODI 10672090 at NHTSA ↗

Reported: 2014-07-14 (July 14, 2014)

BMW of North America, LLC (BMW) is recalling a certain model year BMW i3 vehicle manufactured March 31, 2014, and certain 2014 MINI Cooper Hardtop vehicles manufactured February 2, 2014 to May 30, 2014. The affected vehicles may have been manufactured with an air bag inflator that was not assembled correctly. This could cause the air bag to not deploy properly in the event of an accident.

Consequence: If the air bag deploys improperly in the event of a crash necessitating deployment of the air bags, the seat occupant may be at an increased risk of injury.

Remedy: BMW will notify owners, and dealers will replace the front passenger side air bag, free of charge. The recall began in September 2014. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2014-10-03 (October 3, 2014)

BMW of North America, LLC (BMW) is recalling certain model year 2014 MINI Cooper Hardtop 2-door vehicles manufactured January 7, 2014, to July 21, 2014. The spare wheel may have been attached under the car with a nut that is not self-locking.

Consequence: Vibrations from driving may cause the nut to loosen, allowing the wheel to separate from the car. If the spare wheel separates from the vehicle, it could become a road hazard and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the spare wheel securing nut with a self-locking nut, free of charge. The recall began on November 20, 2014. Owners may contact MINI customer service at 1-866-275-6464.

Reported: 2014-12-15 (December 15, 2014)

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop 2 Door, and Cooper S Hardtop 2 Door vehicles manufactured January 6, 2014, to October 17, 2014. During service appointments, dealers may have inadvertently reprogrammed the transmission control unit with software that may allow drivers to exit the vehicle when the transmission is not in Park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 114, "Theft Protection and Rollaway Prevention."

Consequence: If the driver exits the vehicle without the transmission being in Park, the vehicle could roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: MINI will notify owners, and dealers will reprogram the transmission control module with the correct software, free of charge. The recall February 4, 2015. Owners can contact MINI customer service at 1-866-825-1525.

Reported: 2015-01-26 (January 26, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop two door vehicles manufactured December 1, 2013, to December 14, 2014. The affected vehicles may have been manufactured with an incorrect maximum capacity weight stated on the Tire Information Placard. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 110, "Tire Selection and Rims and Motor Home/Recreation Vehicle Trailer Load Carrying Capacity Information for Motor Vehicles with a GVWR of 4,536 kilograms (10,000 pounds) or less."

Consequence: The maximum weight listed on the label is incorrect (too low) and therefore does not comply with Federal Regulations.

Remedy: MINI will notify owners, and dealers will replace the incorrect labels with corrected labels, free of charge. Owners were mailed interim notification on March 18, 2015. The recall began on October 15, 2015. Owners may contact MINI customer service at 1-866-825-1525.

Reported: 2015-07-17 (July 17, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper and MINI Cooper S Hardtop 2 Door vehicles and 2015 MINI John Cooper Works Hardtop 2 Door vehicles. The affected vehicles do not meet the side impact performance requirements for the rear seat passengers. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."

Consequence: If the side impact performance requirements are not met, rear seat passengers may be at a higher risk of injury during a crash.

Remedy: MINI will notify owners, and dealers will install additional energy absorption material between the rear interior side panels and the exterior vehicle body, free of charge. The recall began on September 4, 2015. Owners may contact MINI customer service at 1-866-825-1525. Note: this recall supersedes 14V-815.

Reported: 2015-10-07 (October 7, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2014-2016 MINI Cooper S and MINI Cooper two-door vehicles, 2015-2016 MINI John Cooper Works and MINI Cooper S and MINI Cooper four-door vehicles and 2014-2015 BMW i3 vehicles. Due to a manufacturing error, the passenger frontal air bag may not deploy properly in a low speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence: In the event of a vehicle crash, an air bag that does not deploy properly increases the risk of injury to the front seat passenger.

Remedy: MINI and BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began on November 25, 2015. Owners may contact MINI customer service at 1-866-825-1525 and BMW customer service at 1-800-525-7417.

Reported: 2015-11-09 (November 9, 2015)

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop 2 door vehicles manufactured February 25, 2014, to May 16, 2015, 2014-2015 MINI Cooper S Hardtop 2 door vehicles manufactured March 28, 2014, to May 9, 2015, 2015 MINI Cooper Hardtop 4 door vehicles manufactured October 17, 2014, to June 2, 2015, and 2015 MINI Cooper S Hardtop 4 door vehicles manufactured November 24, 2014, to June 11, 2015. During a service appointment, the affected vehicles received replacement front passenger seat cushions (which contain integral Capacitive Interior Sensing (CIS) functions). The CIS functions may have been incorrectly calibrated, and if so, would cause impaired occupant classification and thus inappropriate air bag activation/deactivation.

Consequence: Inappropriate air bag activation/deactivation can increase the risk of occupant injury in the event of a vehicle crash.

Remedy: MINI will notify owners, and dealers will inspect and, if necessary, replace the front passenger seat cushion, free of charge. The recall began on December 28, 2015. Owners may contact MINI customer service at 1-866-825-1525 .