1996 Mercury SABLE: complaints, problems and recalls

THE WATER PUMP FAILED ON A 1996 MERCURY SABLE BECAUSE SAND FROM THE ENGINE CASTING GOT INTO THE WATER PUMP

Owner-reported narrative. 96,500 miles reported. Look up ODI 10005561 at NHTSA ↗

WHEN THE BRAKE WAS APPLIED, THE VEHICLE LUNGED FORWARD AND ACCELERATED INTO SOME NEARBY TRASH CANS AND A WOODEN FENCE. *JG *JB

Owner-reported narrative. Look up ODI 10006304 at NHTSA ↗

CAR IS A 1996 MERCURY SABLE, VIN [XXX], WITH A DEFECTIVE TRANSMISSION. CAR WOULD LUNGE AND JERK AS CAR WOULD SLOW AND THEN RE-ACCELERATE (SUCH AS GOING INTO AND OUT OF A CURVE IN TOWN, OR APPROACHING A RED LIGHT THAT CHANGED TO GREEN BEFORE THE CAR COMPLETELY STOPPED.) CAR WAS FIRST WORKED ON 9/9/1999, AT WHICH TIME THE CAR HAD 28,156 MILES ON IT. THE DEALER REPLACED A SENSOR UNDER WARRANTY. THE SYMPTOMS AGAIN STARTED OCCURRING ABOUT A YEAR LATER. WHEN SERVICED ON 5/15/2001, THE DEALER COULD NOT FIND THE SOURCE OF THE PROBLEM. FINALLY, T…

Owner-reported narrative. 46,650 miles reported. Look up ODI 10007614 at NHTSA ↗

VEHICLE STALLED REPEATEDLY. THE IGNITION MODULE WAS REPLACED, HOWEVER THE PROBLEM RECURRED.*JB

Owner-reported narrative. 39,000 miles reported. Look up ODI 10009682 at NHTSA ↗

THE DRIVER'S DOOR LOCK DID NOT FUNCTION PROPERLY. IT CONSTANTLY JAMMED NOT ALLOWING CONSUMER TO OPEN THE DOOR. *NLM

Owner-reported narrative. Look up ODI 10015568 at NHTSA ↗

I HAVE A MERCURY SABLE 1996, MANUFACTURED IN 9/95. VIN NUMBER [XXX]. MY CAR HAS 58,000 MILES AND THE TRANSMISSION IS ALMOST GONE. I WAS INFORMED THAT THERE IS A RECALL ON THE TRANSMISSIONS FOR THIS CAR AND I AM LOOKING FOR THE NECESSARY INFORMATION TO TAKE WITH ME TO DEALER FOR REPLACEMENT. I HAVE ALSO NOTICED THAT MY CAR JERKS FORWARD WHEN AM TAKING OFF FROM A STOPPED POSITION. I HAVE DONE ALL THAT I CAN TO TAKE CARE OF THIS CAR BUT NOTHING I DO HAS WORKED. THERE ARE SO MANY COMPLAINTS AND RECALLS ON THIS CAR AND I REALLY NEED HELP WITH MY RE…

Owner-reported narrative. 58,890 miles reported. Look up ODI 10020530 at NHTSA ↗

CONSUMER STATES THAT WHEN VEHICLE WAS HIT IN THE FRONT CENTER AIR BAGS DID NOT DEPLOY, CAUSING MINOR INJURIES TO THE CONSUMER. DEALER NOTIFIED. *AK

Owner-reported narrative. Look up ODI 10026856 at NHTSA ↗

PROBLEM STARTED WHEN SHIFTING FROM PARK TO DRIVE, CAR WOULD LURCH FORWARD UNLESS YOU HAD BRAKE PEDAL PUSHED DOWN AS HARD AS YOU COULD. THEN WHILE LEAVING A STOP LIGHT CAR WOULD HESITATE THEN PICK UP SPEED VERY SLOWLY, FINALLY THE CAR WILL NOT GO INTO REVERSE. TRANSMISSION SHOP SAID THAT TRANSMISSION HAD TO BE REPLACED. $1800.00 !! *JB

Owner-reported narrative. 96,512 miles reported. Look up ODI 10028593 at NHTSA ↗

Reported: 1996-01-25 (January 25, 1996)

THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SWITCH MALFUNTIONS, THE BRAKE SYSTEM WARNING LAMP WILL EITHER REMAIN ILLUMINATED CONTINUOUSLY OR FAIL TO LIGHT AS INTENDED WHEN THE FLUID LEVEL FALLS TO A CERTAIN LEVEL. IN EITHER CASE, THE VEHICLE OPERATOR WOULD NOT BE WARNED OF A LOW BRAKE FLUID LEVEL CONDITION.

Remedy: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.

Reported: 1996-05-14 (May 14, 1996)

THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.

Consequence: THIS COULD RESULT IN THE PARK PAWL OCCASIONALLY NOT ENGAGING WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE PARK POSITION. THIS COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE.

Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.

Reported: 1996-09-05 (September 5, 1996)

THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.

Consequence: UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT CAN RESULT IN PERSONAL INJURY AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.

Reported: 1996-09-18 (September 18, 1996)

THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.

Consequence: THIS CONDITION COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL WITH THE SHIFT LEVER IN THE PARK POSITION.

Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.

Reported: 1998-03-25 (March 25, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.

Consequence: IF THIS SHIPPING PLUG IS DISPLACED, FUEL LEAKAGE CAN RESULT. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL THE CORRECT FUEL TANK.