2006 Mercury MARINER: complaints, problems and recalls

DT*: THE CONTACT STATED WHILE DRIVING 25 MPH THE STEERING PULLED HARD TO THE LEFT AND GOT WORSE AT HIGHER SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY ALIGNED THE FRONT WHEELS AND ELONGATED THE BOTTOM BOLT OF THE STRUT TO THE KNUCKLE, HOWEVER THE PROBLEM STILL EXISTS. THE MANUFACTURER WAS ALERTED. AFTER FOUR ATTEMPTS TO CORRECT THE PROBLEM, THE DEALER FINALLY STATED THAT WAS THE WAY THE VEHICLE WAS DESIGNED. UPDATED 03/20/06. *JB

Owner-reported narrative. 800 miles reported. Look up ODI 10151470 at NHTSA ↗

2006 MERCURY MARINER TRANSMISSION SLIPPED AT 4,000 MILES. *TS THE VEHICLE WAS TOWED TO THE DEALER FOR SERVICE. THE MANUFACTURER APPROVED A BRAND NEW TRANSMISSION TO BE INSTALLED. *NM

Owner-reported narrative. 4,000 miles reported. Look up ODI 10158379 at NHTSA ↗

FORD MERCURY MARINER: AT 65 MPH I TAPPED THE BRAKE PEDAL TO DISCONNECT THE CRUISE CONTROL. PROCEEDED TO PRESS THE GAS PEDAL AND FOUND THE GAS PEDAL CABLE TO THE THROTTLE LINKAGE FELL OFF. COASTING THROUGH 65 MPH TRAFFIC WITH NO GAS CONTROL WAS CHALLENGING. WHY DID THE GAS PEDAL CABLE FALL OFF AND HAS OTHER VEHICLES OWNERS EXPERIENCE THE SAME PROBLEM? *JB

Owner-reported narrative. Look up ODI 10159085 at NHTSA ↗

I ONLY HAD MY CAR 4 DAYS WHEN DRIVING ON THE GARDEN STATE PARKWAY AT APPROXIMATELY 60 MPH ON A SUNDAY WITH MY GRANDCHILDREN IN THE CAR. LUCKILY, I WAS IN THE SLOW LANE WHEN THE SUV JUST SHUT OFF. I WAS ABLE TO PULL ONTO THE SHOULDER AND RESTART THE CAR. I WAS NEAR AN EXIT AND PROCEEDED DOWN THE RAMP. THE CAR AGAIN SHUT OFF AT THE BOTTOM ON THE RAMP. THE CHECK ENGINE LIGHT STAYED ON. I CALLED THE DEALER THE NEXT DAY (MONDAY) AND BROUGHT THE CAR IN ON TUESDAY. IT IS NOW FRIDAY AND I STILL DO NOT HAVE MY CAR. *JB

Owner-reported narrative. 110 miles reported. Look up ODI 10162415 at NHTSA ↗

THIS COMPLAINT REGARDS THE 2006 MERCURY MARINER THAT I AM LEASING. THE VEHICLE WAS LEASED BEGINNING IN APRIL, 2006 FROM HOLMAN LINCOLN-MERCURY IN MT. LAUREL, NEW JERSEY. MY WIFE, THE PRINCIPAL DRIVER OF THIS VEHICLE COMPLAINED ABOUT THE HEAD RESTRAINTS PREVENTING HER FROM KEEPING HER HEAD STRAIGHT UP WHILE DRIVING. THE MARINER'S HEAD RESTRAINTS PROJECT FORWARD PREVENTING THE DRIVER FROM KEEPING HIS/HER HEAD STRAIGHT UP WHILE DRIVING. THIS IS VERY UNCOMFORTABLE AS ONE'S HEAD IS BENT FORWARD. SOMETIME IN AUGUST, I RETURNED TO HOLMAN AND MET…

Owner-reported narrative. Look up ODI 10167339 at NHTSA ↗

I PURCHASE A 2006 MERCURY MARINER ON FEBRUARY 18, 2006, AT PRICE LINCOLN MERCURY IN CENTENNIAL, CO. WHEN I PURCHASE THIS VEHICLE IT HAD 15 MILES ON THE ODOMETER. I WAS INSTRUCTED BY THE SALES REP THAT I SHOULD AVOID DRIVING THIS VEHICLE OVER 55 MPH TO ALLOW THE ENGINE TO BREAK IN PROPERLY. I STARTING HAVING A SHIMMING AND VIBRATION WHEN THE VEHICLE GET TO 60 AND ABOVE. THIS SHIMMING IS COMING FROM THE FRONT SUSPENSION. I HAVE TAKING THIS VEHICLE TO TWO DIFFERENT MERCURY DEALERSHIP TRYING TO GET THIS PROBLEM RESOLVED. THE LAST RESULT BY ON…

Owner-reported narrative. 500 miles reported. Look up ODI 10176792 at NHTSA ↗

I HAVE A 2006 MERCURY MARINER HYBRID, AND THE BRAKES ON THE CAR GO OUT ON IT. THE BRAKES GO OUT FOR 5 TO 7 SEC. AND THE SERVICE BRAKES LIGHT COME ON AND IT STOPS. THE LAST TIME, IT DID NOT STOP RIGHT A WAY. I HAVE BEEN HAVING IN-DASH NAVIGATION SYSEM PROBLEM AND THE DEALER HAD WORK ON IT. IT IS NOT FIXED RIGHT. AND THE BRAKES STOPPED WORK AGAIN. I HAD CALLED THE DEALER BACK AND SAID THE NAVIGATION IS NOT WORKING RIGHT. I GOT IN MY CAR AND BRAKES STOPPED WORKING AT THE END OF MY DRIVEWAY. I A DATE FOR THE BRAKES AND THE NAVIGTION. THE CAR…

Owner-reported narrative. Look up ODI 10197159 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 MERCURY MARINER. WHILE DRIVING 30 MPH, THE CONTACT HEARD A METAL GRINDING NOISE. THE BRAKES WERE APPLIED; HOWEVER, THE NOISE GREW LOUDER AND THE VEHICLE BEGAN TO VEER TO THE RIGHT. WHEN THE BRAKES WERE RELEASED AND REAPPLIED. THERE WERE ALSO NO WARNING INDICATORS PRESENT. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND THEY STATED THAT THE FRONT PASSENGER SIDE BRAKES WERE WORN DOWN TO THE ROTORS. THE ROTORS AND PADS WERE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 27,500. UPDATED 03-05-08 *BF THE CONSUMER ST…

Owner-reported narrative. 27,500 miles reported. Look up ODI 10208424 at NHTSA ↗

Reported: 2005-11-09 (November 9, 2005)

ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

Reported: 2014-09-03 (September 3, 2014)

Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.

Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.

Reported: 2015-09-29 (September 29, 2015)

Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.

Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.