1999 Mercury COUGAR: complaints, problems and recalls

I HAVE HAD NUMEROUS PROBLEMS WITH MY '99 COUGAR SUCH AS, FAILURE OF MY PAT SYSTEM AND COMPUTER SYSTEM. I HAVE HAD PROBLEMS WITH MY BRAKES WHICH THEY CAN'T SEEM TO FIGURE OUT THE PROBLEM. I HAVE HAD MY STARTER REPLACED TWICE. I HAVE HAD DEFECTS IN SEVERAL SENSORS, WHICH IS NOT UNDER WARRANTY THAT I HAD TO PAY A GOOD AMOUNT OF MONEY FOR THEM TO REPAIR. MY FAN HAS EVEN BLOWN OUT. THERE IS A BURNING SMELL WHENEVER I TURN ON MY HEATER THAT NONE OF THE DEALERS CAN'T SEEM TO SMELL. I ALSO HAD TO PURCHASE A NEW RADIATOR. WHEN MY COMPUTER WENT O…

Owner-reported narrative. Look up ODI 10000023 at NHTSA ↗

I HAVE A 1999 MERCURY COUGAR. I TOOK MY CAR TO MY MECHANIC TO FIND OUT WHAT WAS WRONG WITH MY HEATER THEY TOLD ME BEFORE THEY DID ANYTHING TO CONTACT FORD BECAUSE THERE WAS A RECALL ON MY CAR FOR THE SAME EXACT PROBLEM. I CONTACTED FORD AND THEY FIRST TOLD MY THAT THERE WAS NO RECALL. AFTER I PRESENTED THEM WITH THE RECALL NUMBERS THEY THEN INFORMED ME THAT THERE WAS A SUCH RECALL, BUT THAT MY CAR WOULD NOT BE COVERED UNDER THE RECALL. ON YOUR WEB-SITE THERE IS A SECTION ON THE RECALL ON THE SAME YEAR MAKE AND MODEL AS MY CAR. IT NOTES THA…

Owner-reported narrative. Look up ODI 10000264 at NHTSA ↗

THE KNOB THAT ADJUST THE HEAT FOR HIGH OR LOW IS STUCK ON LOW. CONSUMER STATES" IT IS AN ELECTRICAL PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10002189 at NHTSA ↗

THE KNOB THAT ADJUSTS THE HEAT FOR HIGH OR LOW HAD STUCK ON LOW. THE PROBLEM MAY BE AN ELECTRICAL PROBLEM. TS THE SUNROOF HAD BROKEN. SCC

Owner-reported narrative. Look up ODI 10002190 at NHTSA ↗

THE KNOB THAT ADJUST THE HEAT FOR HIGH OR LOW IS STUCK ON LOW. CONSUMER STATES" IT IS AN ELECTRICAL PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10002191 at NHTSA ↗

THE KNOB THAT ADJUST THE HEAT FOR HIGH OR LOW IS STUCK ON LOW. CONSUMER STATES" IT IS AN ELECTRICAL PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10002192 at NHTSA ↗

THE KNOB THAT ADJUST THE HEAT FOR HIGH OR LOW IS STUCK ON LOW. CONSUMER STATES" IT IS AN ELECTRICAL PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10002193 at NHTSA ↗

THE CONSUMER BEGUN TO DRIVE, WHEN SHE ATTEMPTED TO PLACE THE VEHICLE IN 3RD GEAR, IT DID NOT. SHE HAD TAKEN THE VEHICLE TO THE DEALER, AND WAS TOLD THAT SHE NEEDED A NEW TRANSMISSION. THE CONSUMER FELT THAT THIS SHOULD NOT HAVE HAPPENED WITH LESS THAN 60K MILES. TS THE LOWELL DEALER STATED THAT THE VEHICLE HAD A MAZDA TRANSMISSION, AND THAT THE TRANSMISSION HAD TO BE COMPLETELY REBUILT WITH A NEW TORQUE CONVERTER. SCC

Owner-reported narrative. 59,000 miles reported. Look up ODI 10002405 at NHTSA ↗

Reported: 2000-03-09 (March 9, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

Reported: 2001-02-06 (February 6, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES. THE BATTERY CABLE WAS MISROUTED AND ITS ATTACHMENT TO THE ALTERNATOR CABLE WAS UNDER-TORQUED. IF MISROUTED, THE CABLE COULD CONTACT THE POWER STEERING LINE AND THE INSULATION COULD WEAR, RESULTING IN AN ELECTRICAL SHORT.

Consequence: THE SHORT COULD POTENTIALLY RESULT IN A FIRE, STALLING, OR A NO-START CONDITION.

Remedy: DEALERS WILL INSPECT THE BATTERY CABLE TO THE ALTERNATOR FOR DAMAGE AND, IF IT IS DAMAGED, WILL REPLACE THE CABLE. ADDITIONALLY, THE ROUTING OF THE CABLE WILL BE CORRECTED, AS NECESSARY, AND A ROUTING CLIP WILL BE ADDED. ALSO THE TORQUE ON THE ALTERNATOR ATTACHMENT OF THE CABLE WILL BE CHECKED AND, AS REQUIRED, WILL BE TIGHTENED TO SPECIFICATION. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2001-02-06 (February 6, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE LAMP SWITCH TERMINALS COULD OVERHEAT.

Consequence: THIS COULD CAUSE EITHER A LOSS OF BRAKE LAMP FUNCTION OR CONTINUOUSLY ILLUMINATED BRAKE LAMPS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A NEW STOP LAMP EXTENSION HARNESS WITH BRONZE TERMINALS AT THE BRAKE LAMP SWITCH CONNECTOR, AND ALSO INSPECT THE BRAKE LAMP SWITCH FOR SIGNS OF OVERHEATING AND REPLACE, AS REQUIRED. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2001-07-09 (July 9, 2001)

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2004-08-30 (August 30, 2004)

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.

Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 1999-07-20 (July 20, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.

Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.

Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.

Reported: 1999-08-18 (August 18, 1999)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DOOR LATCH MAY HAVE BEEN MANUFACTURED WITH A LATCH PAWL THAT HAS A COATING WHICH WILL SWELL IN HIGH HUMIDITY CONDITIONS. THE LATCH PAWL MAY THEN STICK IN THE OPEN OR UNLATCHED POSITION.

Consequence: THE DOOR WOULD NOT LATCH WHEN CLOSED. IF THE VEHICLE IS DRIVEN IN THIS CONDITION, IT COULD POTENTIALLY RESULT IN THE DOOR OPENING WHILE THE VEHICLE IS IN MOTION.

Remedy: DEALERS WILL INSTALL A REVISED SIDE DOOR LATCH.