2010 Mercedes-Benz GL350: complaints, problems and recalls

TL* THE CONTACT OWNS A OWNS A 2010 MERCEDES BENZ GL350. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ABS WARNING LAMP ILLUMINATED. IMMEDIATELY AFTER THE FAILURE, THE BRAKES SEIZED AND PREVENTED THE VEHICLE FROM MOVING. THE VEHICLE WAS TOWED TO THE DEALER, WHO DIAGNOSED THAT THE FRONT SPEED SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 24,226. UPDATED 08/28/12*LJ UPDATED 08/29/12

Owner-reported narrative. 24,226 miles reported. Look up ODI 10462284 at NHTSA ↗

2010 MERCEDES BENZ GL 350. CONSUMER WRITES IN REGARDS TO A FRACTURED STEERING COLUMN, WATER PUMP LEAK AND ENGINE OIL LEAK. *SMD THE CONSUMER STATED AT 11,763 THE STEERING COLUMN JACKET TUBE COVERING MOUNT FRACTURED, WHICH CAUSED BINDING AND WEAR ON THE SURROUNDING TRIM. THE COVERING AND TRIM WERE REPLACED. AT 26,163 THE WATER PUMP AND GASKET WERE REPLACED. THEN AT 50,548 MILES, AN ENGINE OIL LEAKED DEVELOPED FROM THE OIL COOLER, R&R TURBO CHARGER, R&R LEFT AND RIGHT CHARGE AIR MANIFOLDS. ALL OF THE SEALS WERE REPLACED.

Owner-reported narrative. 11,763 miles reported. Look up ODI 10515243 at NHTSA ↗

I HAVE BEEN NOTICING AN INCREASING SMALL LEAK IN ENGINE OIL ON MY GARAGE FLOOR. RECENTLY I SAW A VERY LARGE PUDDLE WHILE PARKED AT A LOT AND HAD THE CAR TAKEN TO NEAREST DEALER. DEALERSHIP ADVISED REPLACING OIL COOLER AND ASSOCIATED SYSTEM PARTS. I BELIEVE IF I HAD NOT NOTICED LEAK/PUDDLE, ENGINE MAY HAVE SEIZED WHILE DRIVING. ALSO, ON MANY MB FORUMS, THE OIL COOLER IS IMPLICATED AS THE CULPRIT FOR A LARGE OIL LEAK. *TR

Owner-reported narrative. 46,213 miles reported. Look up ODI 10546126 at NHTSA ↗

ABOUT A WEEK AGO I BOUGHT DIESEL FUEL FROM A TRUCK STOP IN LONG BEACH, NOT MY USUAL PURCHASE FROM MY LOCAL GAS STATION. ONE WEEK LATER I GET A MESSAGE TO CHANGE MY FUEL FILTER AND GOT A TROUBLE CODE INDICATING A LOW FUEL RAIL PRESSURE. I HAD THE FILTER CHANGED AND EXPERIENCED HARD STARTING LATER ON. THE OLD FILTER HAD WATER AND SOME ALGAE CONTAMINATION WHICH IS VERY COMMON IN DIESEL ENGINES. I SUSPECTED WATER FROM THE TRUCK STOP WHERE I GOT FUEL FROM AND TRIED TO REMOVE IT USING A DIESEL ADDITIVE, SEA FOAM. STARTING MY CAR GOT WORSE TO THE PO…

Owner-reported narrative. 49,000 miles reported. Look up ODI 10564368 at NHTSA ↗

AFTER EXTENSIVE REVIEWS OF TDI FORUMS, COMMON RAIL FORUMS, DIESEL FORUMS I HAVE FOUND A COMMONALITY IN THE FAILURES IN THE HIGH PRESSURE FUEL PUMP (HPFP). MAINLY THOSE FAILURES WERE ATTRIBUTED TO METAL SHAVINGS/PARTICLES/RUST FOUND IN DIESEL FUEL SYSTEMS. THE FUEL LEVEL SENDING UNITS ARE USUALLY RUSTED IN EACH CASE AND MOST LIKELY IS THE SOURCE OF METAL/RUST CONTAMINATION AND ULTIMATELY CAUSE OF THE HPFP FAILURE. FAILURE OF THE HPFP CAUSES THE CR TO LOSE PRESSURE THEREFORE THE INJECTORS ARE STARVED OF FUEL OR WORSE CLOGGED WITH RUSTED METAL PA…

Owner-reported narrative. 49,000 miles reported. Look up ODI 10565780 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 MERCEDES BENZ GL350. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED TWELVE TIMES PRIOR TO THIS INCIDENT. AFTER EACH FAILURE, THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ABS SENSOR MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,848. UPDATED 8/21/15*CN UPDATED 10/26/2017*CN

Owner-reported narrative. 37,848 miles reported. Look up ODI 10726898 at NHTSA ↗

AFTER A LONG TRIP WITH THE 2010 MERCEDES GL350 BLUETEC, I NOTICED FRESH OIL ON THE GARAGE FLOOR. I TOOK THE GL350 TO A LOCAL MECHANIC FOR AN OIL CHANGE THE DAY AFTER, AND THE MECHANIC NOTED THAT THERE IS SIGNIFICANT OIL UNDER THE ENGINE. FEW DAYS AFTER, CHECK ENGINE LIGHT CAME ON, AND I TOOK THE GL350 IN FOR A CHECK, AND ANOTHER MECHANIC CONFIRMED THAT THE ENGINE OIL COOLER SEAL IS BROKEN CAUSING THE OIL LEAK. IT SEEMS THAT THIS IS A VERY COMMON FAULT WITH MERCEDES OM642 ENGINE IN MY GL350.

Owner-reported narrative. 65,000 miles reported. Look up ODI 10747970 at NHTSA ↗

THE "CHECK ENGINE LIGHT" IS ON, WHEN I TOOK THE CAR TO THE DEALER, THEY TOLD, " THE AD BLUE TANK IS CORRODED." I HAVE ALWAY FUELED WITH DISEL RECOMMENDED BY MERCEDES. HOW CAN TANK GET CORRODED SO EARLY. I SUSPECT FAULTY IN THE MANUFACTURING. I REQUEST YOU TO DO NECESSARY INVESTIGATION INTO IT. I HAVE HEARD SIMILAR INCIDENT ABOUT FAULTY AD BLUE TANK FROM MANY OTHERS ON FORUM: HTTP://MBWORLD.ORG/FORUMS/GL-CLASS-X164/396987-2010-GL350-BLUETEC-FUEL-SYSTEM-CORROSION-BIG-PROBLEM.HTML

Owner-reported narrative. Look up ODI 10781223 at NHTSA ↗

Reported: 2022-05-09 (May 9, 2022)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2012 ML-Class, GL-Class, and R-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. Moisture may accumulate and cause corrosion in the brake booster housing unit, which can result in reduced brake performance or brake failure.

Consequence: Reduced brake performance or brake failure can increase the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will remove the rubber sleeve, inspect the brake booster, and as necessary, replace the brake booster. All repairs will be performed free of charge. Owner notification letters were mailed June 30, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2022050014, 2022050015 2022090006, & 2022090007.

Reported: 2024-04-26 (April 26, 2024)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2012 ML, GL, and R-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. Moisture may accumulate and cause corrosion in the brake booster housing unit, which can result in reduced brake performance or brake failure.

Consequence: Reduced brake performance or brake failure can increase the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will remove the rubber sleeve, inspect the brake booster, and as necessary, replace the brake booster. All repairs will be performed free of charge. Owner notification letters were mailed on May 24, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MMUSA's number for this recall is 2024050001/2. This recall is an expansion of previous recall number 22V-315.