2008 Mercedes Benz C63: complaints, problems and recalls

2008 C63 AMG-EVERY TIME FILL UP TANK THERE VERY STRONG GAS SMELL EVEN OUT DOOR. I TRACKED DOWN SMELL FROM UNDER BACK SEAT WHERE GAS TANK IS. OPEN BACK SEAT YOU WILL SEE WET SPOT FROM GAS LEAK. THIS IS EXTREMELY DANGEROUS THAT CAR CAN GET CAUGHT ON FIRE. I RESEARCH ONLINE AND FOUND MANY MERCEDES HAS SAME ISSUE AND BEEN TOLD BY DEALER THAT IT TEAR AND WEAR, AND USER RESPONSIBLE FOR REPAIR. MY CAR IS 2008 C63 AMG, ONE OF TOP C CLASS MODEL, WITH 50,000 MILES. THE GAS TANK SHOULD LAST MUCH LONGER THAN 50,000 MILE. THIS IS UNACCEPTABLE FOR MERCEDE…

Owner-reported narrative. 50,000 miles reported. Look up ODI 10497765 at NHTSA ↗

REAR TAILLIGHTS STARTED SMOKING. IT WAS ALL BURNED OUT CAUSING REAR RIGHT TAILLIGHT TO MALFUNCTION. *TR

Owner-reported narrative. 31,500 miles reported. Look up ODI 10557594 at NHTSA ↗

THE PASSENGER TAIL LAMP BULB CARRIER, GROUND WIRE, AND CONNECTING PLASTIC HARNESS ALL MELTED CAUSING MY TAIL LAMPS TO APPEAR DIM AND EVENTUALLY MELTED TO THE POINT THE PASSENGER BRAKE LIGHTS, REAR RUNNING LAMPS, REAR PASSENGER TURN SIGNAL AND REAR FOG LAMP ALL COMPLETELY QUIT FUNCTIONING. I CONTACTED MY LOCAL MERCEDES BENZ DEALER AND THEY WOULD NOT FIX THE PROBLEM UNDER WARRANTY OR GOOD WILL EVEN KNOWING IT TO BE A COMMON PROBLEM. I PURCHASED THE PARTS THAT THEY CLAIMED HAVE BEEN UPDATED (ALTHOUGH THEY APPEAR TO BE EXACTLY THE SAME) AND HAD THE…

Owner-reported narrative. 67,200 miles reported. Look up ODI 10557662 at NHTSA ↗

MY 2008 MERCEDES AMG C63 HAD BEEN OPERATING WITHOUT FLAWS UNTIL RECENTLY, I PARKED, WENT IN THE GYM TO WORK OUT FOR 45 MINS. WHEN I CAME OUT AND TRIED TO START THE VEHICLE, THERE WAS NO RESPONSE. STEERING WHEEL LOCKED, WOULDN'T COME OUT OF PARK. LEFT ME STRANDED. I HAVE READ DOZENS OF COMPLAINTS ON THE MERCEDES-BENZ FORUMS ABOUT THIS SPECIFIC ISSUE HAPPENING TO OTHER OWNERS OF 2008-2009 MERCEDES C63 SEDANS. MERCEDES HAS A TECHNICAL SERVICE BULLETIN LISTING THIS AS A COMMON OCCURRENCE, AND THE ENTIRE STEERING COLUMN LOCK HAS TO BE REPLACED(USUAL…

Owner-reported narrative. 94,000 miles reported. Look up ODI 10874900 at NHTSA ↗

THE ELECTRONIC STEERING CONTROL LOCK MODULE WENT OUT ON MY CAR. THIS SEEMS TO BE A REOCCURRING ISSUE WITH ANY "W204" 2008/2009 MERCEDES BENZ MODEL CAR. I'VE DOCUMENTED OVER A FEW HUNDRED CASES ALONE ON THE FORUMS ONLINE. THIS IS A DEALERSHIP ONLY FIX AND SHOULD BE RECALLED. BASICALLY, SECURITY SYSTEM IN THE CAR THAT LETS THE KEY COMMUNICATE WITH THE IGNITION SYSTEM GOES OUT AND THE CAR WILL NOT START. IT'S A $1200 FIX MINIMUM..

Owner-reported narrative. 135,000 miles reported. Look up ODI 10884993 at NHTSA ↗

Reported: 2014-04-11 (April 11, 2014)

Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2008-2011 C300, C300 4Matic, C350, and C63 AMG vehicles manufactured January 26, 2007, through July 13, 2011. In the affected vehicles, a poor electrical ground connection may result in the dimming or failure of the tail lights.

Consequence: Dimming or failure of the tail lights reduces the ability to warn other motorists of the driver's intentions of stopping or turning, increasing the risk of a crash.

Remedy: Mercedes will notify owners, and dealers will replace the bulb holders if not previously updated and replace any corroded connectors, free of charge. The recall began on August, 18, 2014. Owners may contact Mercedes at 1-800-367-6372.

Reported: 2015-10-27 (October 27, 2015)

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2008-2009 C300 Sedan, C300 4Matic, C63 AMG, and C350 vehicles, and 2010 GLK350 and GLK350 4Matic vehicles. Due to a manufacturing error, the air bag control unit may corrode and cause the control unit to malfunction.

Consequence: The malfunctioning air bag control unit may cause the air bags to unexpectedly deploy increasing the risk of injury and the possibility of a vehicle crash. Alternatively, the air bag control unit malfunction may cause the air bags to not deploy in the event of a crash necessitating air bag deployment, increasing the risk of occupant injury.

Remedy: MBUSA will notify owners, and dealers will inspect the air bag control unit and replace it, as necessary, free of charge. Mercedes-Benz issued an interim notification to owners on December 23, 2015. The recall began on March 14, 2016. Owners may contact MBUSA customer service at 1-800-367-6372.

Reported: 2016-05-26 (May 26, 2016)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain model year 2008-2011 C300 Sedan, C300 4matic Sedan, C350 Sedan, C63 AMG Sedan vehicles, 2010-2011 GLK350, GLK350 4-Matic and E350 Coupe vehicles, 2011 SLS AMG, E350 Convertible, E550 Coupe and E550 Convertible vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, MBUSA is recalling certain model year 2008 C300 Sedan, C350 Sedan, C63 AMG Sedan and C300 4-Matic Sedan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: MBUSA will notify owners, and dealers will replace the passenger frontal air bag modules, free of charge. Owners were sent an interim notification October 2016. A second notice will be mailed when remedy parts are available. Owners may contact MBUSA customer service at 1-877-496-3691.