2002 Mazda B-SERIES TRUCK: complaints, problems and recalls

I HAVE BEEN TO THE DEALERSHIP TWICE. I HAD IT TOWED ONE OF THE TIMES. THE TRUCK HAS BEEN STALLING OUT ON ME WHEN I HAVE BEEN DRIVING DOWN THE ROAD. THE DEALERSHIP (SULLIVAN WATTS MAZDA) HAS SAID THERE IS NOTHING WRONG, AND TO HAVE IT TOWED BACK IN THE NEXT TIME I HAVE THE PROBLEM. MY TRUCK DID STALL ONE LAST TIME WHILE I WAS TRYING TO STOP AT A RED LIGHT. WHEN THE TRUCK STALLED I LOST BRAKE PRESSURE AND POWER STEERING AND REAR ENDED A CAR, TOTALING IT. CAUSING $4,800 DAMAGE TO MY TRUCK.*JB

Owner-reported narrative. Look up ODI 10010307 at NHTSA ↗

TRANSMISSION WILL NOT SHIFT INTO OVERDRIVE UNTIL SPEEDS OF 58-60 ARE REACHED - WHEN ACCELERATING. TOOK VEHICLE TO DEALER FOR THE COMPLAINT. DEALER TECH SAID VEHICLE WOULD NOT SHIFT DURING 'AGRESSIVE ACCELERATING' . DRIVER MUST EASE UP ON GAS PEDAL BEFORE TRANSMISSION WOULD SHIFT TO OVERDRIVE. SAID THIS WAS NORMAL. NEVER HEARD OF AN AUTOMATIC TRANSMISSION WITH SUCH REQUIREMENTS. NONE THAT I HAVE EVER OWNED REQUIRED AN EASING UP ON GAS IN ORDER TO SHIFT. WHEN I FOLLOWED DEALERS INSTRUCTIONS, VEHICLE WILL STILL NOT SHIFT UNTIL IT HAS BEEN DRIVEN…

Owner-reported narrative. 15 miles reported. Look up ODI 10025817 at NHTSA ↗

CONSUMER STARTED THE VEHICLE WHICH WAS ENGAGED IN LOWER GEAR, WITH OUT PUSHING THE CLUTCH, THE VEHICLE HIT A WALL ,AND BOTH AIR BAGS DEPLOYED. *AK THE CONSUMERS WIFE PUSHED IN THE CLUTCH AND STARTED THE VEHICLE, NOT REALIZING THAT THE TRUCK WAS LEFT IN FIRST GEAR INSTEAD OF SETTING THE EMERGENCY BRAKE, SHE RELEASED THE CLUTCH. THE VEHICLE IMMEDIATELY JERKED DIRECTLY INTO THE WALL IN FRONT OF IT. THIS CAUSED BOTH AIR BAGS TO DEPLOY. THE PROBLEM WAS WITH THE SIDE AIR BAG SWITCH BEING IN THE OFF POSITION, AND THE AIR BAGS DEPLOYED ANYWAY. …

Owner-reported narrative. 22,445 miles reported. Look up ODI 10027187 at NHTSA ↗

WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING VEHICLE WILL STALL WHILE ENGAGING THE CLUTCH PEDAL.*AK

Owner-reported narrative. Look up ODI 10030015 at NHTSA ↗

WHILE DRIVING 50 MPH CONSUMER'S CHILD WAS PLUGGING IN A CELL PHONE CORD, AND LOST CONTROL OF VEHICLE. VEHICLE VEERED DOWN INTO AN EMBANKMENT. THEN, CAME BACK ONTO THE HIGHWAY, SIDE SWIPED ANOTHER VEHICLE, AND SLAMMED INTO A GUARDRAIL. SEAT BELTS WERE WORN, BUT THE AIR BAGS DID NOT DEPLOY. CONSUMER'S CHILD SUFFERED SEVERE INJURIES.*AK

Owner-reported narrative. 22,500 miles reported. Look up ODI 10034430 at NHTSA ↗

VEHICLE WAS INVOLVED IN A CRASH. VEHICLE HIT A TREE HEAD ON WHILE DRIVING ABOUT 50MPH. UPON IMPACT, AIRBAGS DID NOT DEPLOY. *AK

Owner-reported narrative. 15,500 miles reported. Look up ODI 10063515 at NHTSA ↗

INTERMITTENT, RANDOM, ENGINE STALLING. THE 2002 MAZDA B3000 DUAL SPORT WILL STALL RANDOMLY AND WITHOUT WARNING. SO FAR THE VEHICLE HAS STALLED ON FOUR SEPARATE OCCASIONS AND UNDER DIFFERENT WEATHER CONDITIONS. SEVERAL OTHER DUAL SPORT OWNERS I HAVE TALKED TO REPORT THE SAME STALLING CONDITION. DEALERSHIP REPAIR FACILITY HAS SO FAR BEEN UNABLE TO VERIFY A FAULT CONDITION LEADING TO ENGINE STALLING.

Owner-reported narrative. 10,000 miles reported. Look up ODI 10066164 at NHTSA ↗

3 MONTHS AFTER I PURCHASED MY TRUCK, I STARTED HAVING PROBLEMS WITH THE TRANSMISSION. THE TRANSMISSION BANGS LIKE SOMEONE HIT ME FROM THE REAR WHEN SHIFTED FROM PARK TO REVERSE. IT ALSO SHUTTERS WHEN I PRESS THE ACCELERATOR.

Owner-reported narrative. 90 miles reported. Look up ODI 10071105 at NHTSA ↗

Reported: 2007-08-07 (August 7, 2007)

ON CERTAIN TRUCKS EQUIPPED WITH A SPEED CONTROL SYSTEM, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. AN INTERIM NOTICE WAS SENT TO OWNERS ON SEPTEMBER 7, 2007, DIRECTING THEM TO HAVE THE SPEED DEACTIVATION CONTROL SWITCH DISCONNECTED TEMPORARILY. A SECOND NOTIFICATION LETTER TO OWNERS WAS IN FEBRUARY 2008 ADVISING THEM TO RETURN TO DEALERS FOR INSTALLATION OF THE REPAIR PART. OWNERS OF AFFECTED VEHICLES WHO DID NOT RECEIVE A PHASE 2 NOTICE AND HAVE NOT HAD THE RECALL COMPLETED WILL BE NOTIFIED BEGINNING AUGUST 6, 2008. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.

Reported: 2009-10-23 (October 23, 2009)

MAZDA IS RECALLING MODEL YEAR 1995 THROUGH 1997 AND MODEL YEAR 2001 THROUGH 2003 TRUCKS EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS) AND/OR ANTI-LOCK BRAKE SYSTEM (ABS) AND MANUFACTURED ON OR BEFORE DECEMBER 5, 2002. A COMPONENT OF THE CRUISE CONTROL DEACTIVATION SWITCH MAY DETERIORATE OVER TIME AND DEVELOP A LEAK. THIS OCCURRENCE COULD CAUSE THE SWITCH TO OVERHEAT, SMOKE OR BURN WHICH COULD RESULT IN AN UNDER HOOD FIRE.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: MAZDA WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A UNIVERSAL FUSED JUMPER HARNESS ON THE CRUISE CONTROL DEACTIVATION SWITCH FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500 OPTION #6.