2014 Kia OPTIMA: complaints, problems and recalls

MY KIA OPTIMA 2014 STARTED A NOISE NEAR THE ENGINE THAT SOUNDS LIKE A CLAPPING NOISE. THE FIRST KIA DEALER I TOOK IT TO SAID THAT IT IS NOT TO WORRY AND IS PART OF THE KIA ENGINEERING DESIGN. THE SECOND KIA DEALER I TOOK IT TO SAID THAT THE NOISE IS BAD NEWS AND AFTER FURTHER DIAGNOSTICS, THEY DETERMINED THAT THE ENTIRE ENGINE NEEDED TO BE REPLACED. JUST 5,000 MILES INTO THE LIFE OF MY BRAND NEW KIA OPTIMA 2014. I WANT PEOPLE TO BE AWARE THAT IF YOU HEAR A CLAPPING NOISE NEAR THE TOP OF THE ENGINE THAN PLEASE TAKE IT INTO A KIA DEALER IMMEDIATE…

Owner-reported narrative. 5,000 miles reported. Look up ODI 10560127 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 KIA OPTIMA. THE CONTACT WAS DRIVING 50 MPH WHEN THE POWER STEERING ASSIST FAILED. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR DIAGNOSIS. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 100.

Owner-reported narrative. 100 miles reported. Look up ODI 10561751 at NHTSA ↗

I HAD MY CAR KID OPTIMA 2014 2 WEEKS (800 MILES ON MY NEW ).THE ENGINE WAS MAKING A KNOCKING NOISES TOOK IT BACK TO DEALERSHIP IT WAS THE PISTON NOT WORKING FULLY THEY SAID I WAS GOING TO HAVE TO HAVE ENGINE REPLACED .I DON'T WANT THE CAR ! I'M NOT HAPPY. *TR

Owner-reported narrative. 829 miles reported. Look up ODI 10562581 at NHTSA ↗

VEHICLE WANDERS FROM SIDE TO SIDE ON THE HIGHWAY, AT HIGHWAY SPEEDS (60+ MPH) AND REQUIRES CONSTANT CORRECTION FROM LEFT TO RIGHT TO MAINTAIN LANE POSITION. THIS HAS BEEN A PROBLEM FROM THE TIME WE PURCHASED IT NEW LESS THAN 3 WEEKS AGO. THE STEERING IS VERY HYPER-SENSITIVE AT SPEED AND A CORRECTION TO THE RIGHT REQUIRES A CORRECTION TO LEFT WITH NO APPARENT "GRAY" OR MIDDLE CENTER AREA WHICH WOULD KEEP THE VEHICLE IN A STRAIGHT LINE. MOST OF THIS IS ON VERY STRAIGHT SURFACES WITH LITTLE TO NO CROWN & CAMBER ON THE ROAD. STEERING MODE WAS CHANG…

Owner-reported narrative. 612 miles reported. Look up ODI 10564794 at NHTSA ↗

DRIVING SOUTHBOUND ON I-95 IN VIRGINIA, I HEARD A LOUD EXPLOSION LIKE A GUNSHOT. MOMENTS LATER, I HEARD THE SOUND OF AIR RUSHING PAST FROM ABOVE MY HEAD AND DEBRIS VIBRATING ON THE INTERIOR SUNROOF SCREEN. I LATER FOUND THAT IT WAS BROKEN GLASS CRACKLING AND FALLING AGAINST THE INTERIOR SUNROOF SCREEN. I PULLED OVER IMMEDIATELY TO CHECK THE ROOF FOR DAMAGE. WHAT I FOUND WAS A GAPING HOLE (8-12 INCHES IN DIAMETER) IN THE GLASS OF THE FRONT SUNROOF. I WAS NOT NEAR ANY OVERPASS OR WORK TRUCKS, NOR DID I EVER OBSERVE ANYTHING STRIKING THE CAR …

Owner-reported narrative. 1,000 miles reported. Look up ODI 10565194 at NHTSA ↗

VEHICLE WANDERS AT HIGHWAY SPEEDS. IT IS ALMOST IMPOSSIBLE TO GO STRAIGHT WITHOUT CONSTANT ADJUSTMENT. EVEN WITH CONSTANT ADJUSTMENT THE CAR WILL NOT TRACK STRAIGHT. *TR

Owner-reported narrative. 2,000 miles reported. Look up ODI 10568887 at NHTSA ↗

I COMPLAINED TO THE DEALER ABOUT THE ROUGH RIDE AND HARSH RIDE BUT WAS TOLD NOT TO WORRY. I THEN TOOK IT ON THE HIGHWAY AND THE STEERING PULLED TO THE LEFT AND I NEVER FELT CONFIDENT ABOUT THE STEERING ONLY TO SAY THAT IT DID NOT FEEL RIGHT AND IT WAS WORRISOME TO ME. IT SIMPLY DID NOT FEEL RIGHT TO ME. I'VE BEEN DRIVING 50 YEARS AND HAVE NEVER FELT THIS UNCOMFORTABLE DRIVING/STEERING A CAR AT HIGHWAY SPEEDS. *TR

Owner-reported narrative. 123 miles reported. Look up ODI 10569111 at NHTSA ↗

2014 KIA OPTIMA. CONSUMER WRITES IN REGARDS TO POWER STEERING ISSUES. *SMD THE CONSUMER STATED THE POWER STEERING WAS TOO SENSITIVE, TO THE POINT THAT IT WAS DIFFICULT KEEPING THE VEHICLE STRAIGHT ON THE ROAD. THE CONSUMER NOTICED THE ISSUE, TEN DAYS AFTER PURCHASING THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHERE THEY TRIED TO RESOLVE THE PROBLEM, BY ALIGNING THE FRONT END, AND EVEN REPLACING THE TIRES. BUT, TO NO AVAIL. THE SERVICE MANAGER STATED THE ONLY WAY TO CORRECT THE PROBLEM WAS TO RE-DESIGN THE POWER STEERING SYSTEM. …

Owner-reported narrative. Look up ODI 10574569 at NHTSA ↗

Reported: 2017-03-31 (March 31, 2017)

Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.

Consequence: Bearing wear may result in the engine seizing, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.

Reported: 2018-12-19 (December 19, 2018)

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Reported: 2020-02-21 (February 21, 2020)

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.

Consequence: If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.

Remedy: Kia will notify Owners, and Dealers will inspect the low pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, a heat-protective tape will be installed. Repairs will be performed free of charge. The recall began June 12, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC187.

Reported: 2020-08-27 (August 27, 2020)

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence: If the HECU short circuits, there is an increased risk of an engine compartment fire.

Remedy: Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.

Reported: 2021-05-10 (May 10, 2021)

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence: An electrical short in the HECU increases the risk of a fire while parked or driving.

Remedy: Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.

Reported: 2022-02-17 (February 17, 2022)

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.

Consequence: A fuel leak can increase the risk of a fire.

Remedy: Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed August 2, 2022. Owners may contact Kia customer service at 1-800-33-4542. Kia's number for this recall is SC228.

Reported: 2023-09-25 (September 25, 2023)

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.