2015 Kenworth T680: complaints, problems and recalls

WHEN THE ENGINE RUNS HOT, FROM HARD PULLS OVER A MOUNTAIN, THE POWER STEERING FLUID GETS SO HOT IT BOILS. I LOSE SOME POWER STEERING WHEN THAT HAPPENS.

Owner-reported narrative. 508,600 miles reported. Look up ODI 11080420 at NHTSA ↗

DRIVER DRIVING DOWN FLAT HYWAY NEAR EASTON PA RIGHT FRONT DRIVE AXLE BRAKES STARTED ON FIRE CAUSE THOUGHT TO BE HALDEX BRAKE CHAMBER SINCE HAVING SO MANY FAIL FAILURES OF THIS GOLD SEAL CHAMBER AND CAUSING FIRES, TOTAL LOSS OF BOTH TRUCK AND TRAILER, DRIVER CONFIRMED RIGHT FRONT HEEL END ON FIRE AND COULD NOT GET IT PUT OUT DUE TO ALL THE HEAT

Owner-reported narrative. 348,455 miles reported. Look up ODI 11110397 at NHTSA ↗

I HAVE ALWAYS ANY LIGHTS ON MY TRUCK / NOW CHEEK ENGINE LIGHT ON FOR CCV SPEEDO ROTOR / SENSOR NOX ALL MOST $3500 DOLLER NEED FIX / I DON'T HAVE / BEFORE I LOT MONEY PUT ON REPAIR/

Owner-reported narrative. 395,600 miles reported. Look up ODI 11154820 at NHTSA ↗

TAKATA RECALL MHC KENWORTH HAS REPLACED OR CORRECTED THE DRIVERS LOW BEAM LIGHT 5 TIMES, 3 FOR FEE AND 2 AS A COST TO MY BUSINESS. THE THIS HEADLIGHT CONTINUES TO MALFUNCTION AND THE LIGHT BULB IS NOT EVEN BLOWN. THE DASHBOARD LIGHTS GOES PITCH BLACK DARK. THE ORANGE ENGINE OUTLINE COMES ON EVERY SINGLE TIME THE MALFUNCTION OCCURS. THIS IS NOT SAFE AND WE CANNOT CONTINUE DRIVING THIS TRUCK LIKE THIS. THE TRUCK CONTINUES TO MISFIRE AFTER THE WARRANTY COVERED THE INJECTORS REPLACEMENT. SOME TIMES THE ENTIRE ELECTRICAL SHUT DOWN IN THE TRUCK. I N…

Owner-reported narrative. 669,842 miles reported. Look up ODI 11165381 at NHTSA ↗

MY 2015 KENWORTH T680 FROM WHAT I WAS TOLD BY THE DEALER SHOP HAS A DEFECTIVE FUEL PUMP THAT CAUSING THE ENGINE OF MY TO STALL IN THE MIDDLE OF THE HIGHWAY ALMOST CAUSED ME A TERRIBLE ACCIDENT, BUT THE MANUFACTURER REFUSED TO TAKE RESPONSIBILITY SO I AM PLACING THIS COMPLAINT TO SEE IF I CAN GET ANY ASSISTANCE, THANKS.

Owner-reported narrative. 20 miles reported. Look up ODI 11219663 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 KENWORTH T680. THE CONTACT STATED THAT THE HEAVY TRUCK EXHIBITED NUMEROUS FAILURES WITH THE DIESEL FUEL SYSTEM WHICH CAUSED THE FAILURES OF THE NOX SENSOR, DIESEL FUEL DOSING VALVE, THE EGR COOLER, THE HC VALVE, THE AMMONIA SENSOR, THE COMMON RAIL, FUEL PUMP, EXHAUST FLEX PIPE, AND THE COMPUTER ALSO FAILED WHICH CAUSED THE HEAVY TRUCK TO NOT EXCEED 5 MPH. THE CONTACT STATED THAT THE MANUFACTURER PROVIDED AN EXTENDED WARRANTY REPAIR COVERAGE HOWEVER, THE MILEAGE OF 435,000 MILES WAS EXCEEDED. THE VEHICLE WAS NOT REP…

Owner-reported narrative. 530,000 miles reported. Look up ODI 11322873 at NHTSA ↗

3

Owner-reported narrative. Look up ODI 11444045 at NHTSA ↗

The contact owns a 2015 Kenworth T680. The contact stated while driving at 55 MPH, he noticed smoke coming through the AC vents and from underneath the hood of the vehicle. There was no warning light illuminated. The contact veered to the side of the road and opened the hood of the vehicle. The contact noticed that the water pump was leaking and one of the hose pipe was cracked. The contact was able to drive the vehicle to a nearby independent mechanic. The independent mechanic diagnosed that the water pump and the hose pipe needed to be repla…

Owner-reported narrative. 924,278 miles reported. Look up ODI 11485741 at NHTSA ↗

Reported: 2014-12-29 (December 29, 2014)

PACCAR Incorporated (PACCAR) is recalling certain model year 2015 Peterbilt 367, 389, 567, 579, and 587 trucks manufactured from May 23, 2014, to February 13, 2015, and 2015 Kenworth T270, T370, T440, T470, T660, T680, T800, T880, and W900 trucks manufactured from May 23, 2014, to February 13, 2015, equipped with certain air brake actuators. The affected vehicles may experience brake drag due to an improperly seated diaphragm in the brake chamber.

Consequence: Brake drag may result in a wheel end fire.

Remedy: Kenworth and Peterbilt will notify owners, and dealers will inspect and replace the brake chamber, as necessary, free of charge. An interim notice was mailed to owners March 3, 2015. The recall began on May 14, 2015. Owners may contact PACCAR customer service at 1-425-828-5000 (Kenworth), or 1-940-591-4000 (Peterbilt). PACCAR's number for this recall is 14KWP (Kenworth), and 1214L (Peterbilt).

Reported: 2015-04-03 (April 3, 2015)

PACCAR Incorporated (PACCAR) is recalling certain model year 2015-2016 Kenworth T680 and T880 trucks manufactured November 17, 2014, to January 5, 2015. The affected vehicles are equipped with Meritor MT-40-14X rear drive axles that may circulate an inadequate amount of lubricant to the wheel end hub assembly.

Consequence: Without adequate lubrication to the wheel end hub assembly, the bearings may fail prematurely, increasing the risk of a wheel-end fire or crash.

Remedy: Kenworth will notify owners, and dealers will replace the defective rear drive axle and inspect the wheel ends for damage, replacing them, as needed, free of charge. The recall began May 29, 2015. Owners may contact Kenworth customer service at 1-425-828-5000. PACCAR's number for this recall is 15KWB.

Reported: 2015-05-08 (May 8, 2015)

PACCAR Incorporated (PACCAR) is recalling certain model year 2014-2016 Kenworth T660, T680, T880 trucks manufactured February 18, 2013, to April 10, 2015, and 2011-2016 Peterbilt 386, 389, 567, 579, and 587 trucks manufactured December 13, 2010, to April 20, 2015. The affected trucks, equipped with PACCAR MX-13 engines and Delco-Remy 40SI alternators, have alternator charge cables that may chafe against a formed metal freon discharge line.

Consequence: If the alternator cable rubs through its insulation, an electrical short may occur, increasing the risk of a fire.

Remedy: PACCAR will notify owners, and dealers will reroute the alternator charge cable away from the metal freon line, free of charge. PACCAR issued an interim notification to owners on July 10, 2015. The recall began on September 16, 2015. Owners may contact Kenworth customer service at 1-425-828-5000 or Peterbilt customer service at 1-940-591-4000. PACCAR's numbers for this recall are 15KWE and 515-F.

Reported: 2015-05-26 (May 26, 2015)

PACCAR Incorporated (PACCAR) is recalling certain model year 2014 and 2015 Kenworth T660, T680, and T800 trucks manufactured January 29, 2013, to April 2, 2014, and 2013 Peterbilt 587 trucks manufactured on August 8, 2012. The affected trucks are built with a driveshaft that may not transmit power to the wheels due to weld failure from corrosion.

Consequence: If the weld fails causing a loss of power to the rear wheels, the vehicle operator may be unable to move the vehicle, or may experience deceleration if the vehicle is in motion, increasing the risk of a vehicle crash.

Remedy: PACCAR will notify owners, and dealers will replace the defective driveshafts, free of charge. The recall began on July 15, 2015. Owners may contact Kenworth customer service at 1-425-828-5000, or Peterbilt customer service at 1-940-591-4000. PACCAR's number for this recall is 15KWJ and 515-H.

Reported: 2015-07-22 (July 22, 2015)

PACCAR Incorporated (PACCAR) is recalling certain model year 2011-2016 Kenworth T440, T470, T660, T680, and T880 trucks manufactured January 14, 2010, to May 22, 2015, and equipped with HID Headlamps and the option for Daytime Running Lamps (DRL). The DRLs are required to deactivate when the hazard warning lights are activated, however, the DRLs on these vehicles override the hazard flashing functionality after the brake pedal is pushed for more than two seconds. Normal hazard flashing functionality returns once the service brake is released. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the hazard warning lamps are overridden by the DRL, oncoming vehicles may fail to be warned, increasing the risk of a crash.

Remedy: Kenworth will notify owners, and dealers will update the cab controller software, free of charge. The recall began on September 167, 2015. Owners may contact Kenworth customer service at 1-425-828-5000. Kenworth's number for this recall is 15KWL.

Reported: 2017-02-15 (February 15, 2017)

PACCAR Incorporated (PACCAR) is recalling certain 2015-2018 Kenworth K370, T680, T880 and 2017-2018 Peterbilt 567 and 579 trucks. The plastic fuel tee fittings on these trucks may leak fuel.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kenworth and Peterbilt will notify owners, and dealers will replace the suspect fuel tees, free of charge. The recall began on April 13, 2017. Owners may contact Kenworth customer service at 1-425-828-5000 and Peterbilt customer service at 1-940-591-4000. PACCAR's numbers for this recall is 17KWA and 217-A.

Reported: 2017-07-25 (July 25, 2017)

PACCAR Incorporated (PACCAR) is recalling certain 2013-2017 Peterbilt 567 and 579 Kenworth T680 and T880 trucks equipped with optional spotlights. The spotlight circuit may not be adequately protected in the event of a short.

Consequence: A short in the spotlight circuitry may increase the risk of a fire at the cab fuse block.

Remedy: PACCAR will notify owners, and dealers will change the polyfuse switch in the spotlight circuit to a standard fuse, free of charge. The recall began on September 19, 2017. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this recall is 17KWC and 717-B.

Reported: 2018-06-01 (June 1, 2018)

PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Peterbilt 567 and 579 trucks and 2015-2018 Kenworth T660, T680, T800, T880 and W900 trucks. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."

Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.

Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on July 30, 2018. Owners may contact Peterbilt customer service at 1-918-259-3258 or Kenworth customer service at 1-425-828-5000.

Reported: 2018-11-16 (November 16, 2018)

PACCAR Incorporated (PACCAR) is recalling certain 2013-2019 Kenworth T680 and T880 and Peterbilt 579 trucks, greater than 30 feet long and equipped with side extender mounted intermediate marker lamp/turn signals that do not include a reflex reflector. Since both intermediate side marker lamps and reflex reflectors are required, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: Missing reflex reflectors can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.

Remedy: PACCAR will notify owners and dealers will install reflex reflective tape, free of charge. The recall began January 15, 2019. Owners may contact PACCAR customer service at 1-918-259-3258. PACCAR's number for this recall is 18KWF, and 18PBC.

Reported: 2020-04-06 (April 6, 2020)

PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."

Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.

Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.

Reported: 2024-02-23 (February 23, 2024)

PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2012-2021 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2009-2020 Kenworth T370, 2014-2023 Kenworth T880, 2011-2016 Kenworth T470, 2023 Kenworth T480, and 2009-2019 Kenworth W900 vehicles. The air tanks have an insufficient volume of air for the brake system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Consequence: Insufficient air volume can reduce braking performance and increase the risk of a crash.

Remedy: Dealers will install the correct volume air tanks, free of charge. Owner notification letters were mailed August 12, 2024. Additional owner notification letters were mailed October 27, 2025. Owners may contact PACCAR customer service at 1-425-828-5888. PACCAR's number for this recall is 24KWD.