2017 Jayco Fifth Wheel PINNACLE: complaints, problems and recalls

BOTH AXLES, SPRINGS AND HARDWARE ON THE FIFTH WHEEL TRAILER ARE FAULTY. THE LEAF SPRINGS AND AXLES ARE NOT THE CORRECT WEIGH RATED FOR THIS MODEL. THE TOP OF THE TIRES RUB AGAINST THE CAMPER FLOOR WHILE IN MOTION. JAYCO HAS APPROVED THE REPLACEMENT OF THE SPRINGS AND U-BOLTS. THE AXLES NEED TO BE UPGRADED FROM A 7000 LB AXLE TO A 8000 LB AXLE. THERE HAS BEEN MANY JAYCO 36 FBTS OWNERS HAVE HAD THIS SAME ISSUE. SOME OWNERS HAVE EXPERIENCED MAJOR DAMAGE AND LOSS. I FEEL THIS NEEDS TO BE INVESTIGATED AND A MANDATED RECALL AND REPAIR BE MADE BY JAYC…

Owner-reported narrative. 3,000 miles reported. Look up ODI 11114672 at NHTSA ↗

REAR LEAF SUSPENSION FAILED WHILE TRAVELING AT HIGHWAY SPEEDS CAUSING TRAILER TO SWAY AND NEARLY OVERTURN. UNIT DROPPED ONTO TIRE CAUSING IT TO FAIL. *DT*JB *BF *JB

Owner-reported narrative. 8,000 miles reported. Look up ODI 11114695 at NHTSA ↗

II AM THE OWNER OF A 2017 JAYCO PINNACLE 36 FBTS. IT HAS A RESIDENTIAL REFRIGERATOR INSTALLED BY JAYCO AT THE FACTORY. THERE HAS BEEN MANY OWNERS OF THE SAME MODEL WITH RESIDENTIAL REFRIGERATORS EXPERIENCING SUSPENSION LEAF SPRING AND AXLE FAILURES. SOME PEOPLE HAVE REGISTERED WITH YOU ABOUT THIS PROBLEM. SOME HAVE HAD THE WEIGHT OF THE RV MEASURED AND THE STOCK SPRINGS ARE NOT IN ACCORDANCE TO THE WEIGHT THEY ARE SUPPORTING AT 60 MPH HAVING THE LEAF SPRING SNAP OFF THE RV BODY AND THE TIRES RUBBING ON THE UNIT. MANY OWNERS HAVE HAD THR…

Owner-reported narrative. 300 miles reported. Look up ODI 11115594 at NHTSA ↗

TWO OF MY FOUR LEAF SPRINGS BROKE, MY OTHER TWO LEAF SPRINGS SHOW CRACKS FORMING AND SEVERE STRESS. WHEN MY LEAF SPRINGS BROKE, MY TRAILER BRAKES ALSO FAILED TO WORK. I DID NOT REALIZE MY LEAF SPRINGS HAD BROKE UNTIL I PULLED INTO MY CAMPSITE AND SAW MY REAR WHEELS IN A VERY WEIRD POSITION. I CRAWLED UNDER AND REALIZED WHAT HAD HAPPENED. I HAVE THE LEAF SPRINGS IN MY POSSESSION AND HAVE PICTURES, BUT I CANNOT UPLOAD THEM FROM THIS COMPUTER. *DT*DT*JB BOTH LEFT AND RIGHT REAR LEAF SPRINGS BROKE, OTHER TWO ARE STARTING TO CRACK. CONSUMER STAT…

Owner-reported narrative. 10,000 miles reported. Look up ODI 11205972 at NHTSA ↗

MY SPRINGS AND AXLES ARE NOT UP TO THE TASK OF HOLDING MY CAMPER UP. THE TIRES ARE HITTING THE BOTTOM OF THE CAMPER, CAUSING THEM TO HAVE A BIG GROOVE CUT INTO THEM AND DAMAGING THE BOTTOM OF THE CAMPER. *DT *BF CARFAX CANNOT PROCESS THIS REQUEST. PHOTOS ATTACHED.*JB THIS DAMAGE WAS CAUSED DURING DELIVERY, UNLOADED, TO THE DEALERSHIP BEFORE I PURCHASED IT. HAD I KNOWN THAT, I WOULD NOT HAVE PURCHASED IT! *DT CARFAX CANNOT PROCESS THIS REQUEST. VIN INVALID. *JB

Owner-reported narrative. 200 miles reported. Look up ODI 11207981 at NHTSA ↗

WELDS BROKE ON CONNECTION BETWEEN LEAF SPRINGS AND BODY FRAME CAUSING TRAILER TO NEARLY TOPPLE

Owner-reported narrative. 25,000 miles reported. Look up ODI 11221931 at NHTSA ↗

WHEELS RUBBING BOTTOM OF CAMPER, RV IS TO HEAVY TO STOP WITH FACTORY INSTALLED BRAKES. *DT *DT INVALID VIN *JB CONSUMER JAYCO HAS REPLACED OUR SPRINGS, WE ASKED FOR AN AXLE UPGRADE BUT THEY DECLINED. ITS TRULY AN EPIDEMIC WITH THESE HEAVY RV UNITS ROLLING OUT OF PRODUCTION WITHOUT THE RIGHT EQUIPMENT.*JB

Owner-reported narrative. 2,000 miles reported. Look up ODI 11232128 at NHTSA ↗

TL* THE CONTACT OWNS A 1999 FORD F-350 TOWING A 2017 JAYCO PINNACLE FIFTH WHEEL. THE CONTACT STATED THAT THE WHEELS ON THE FIFTH WHEEL WERE RUBBING AGAINST THE UNDERBELLY AND THE SPRINGS THAT HELD THE RV WERE FLATTENED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SPRING AND BUSHINGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE VIN WAS UNKNOWN.

Owner-reported narrative. Look up ODI 11254101 at NHTSA ↗

Reported: 2019-10-03 (October 3, 2019)

Jayco, Inc. (Jayco) is recalling certain 2017 Pinnacle Fifth Wheel trailers. The suspension on these vehicles may allow the tires to contact the structure when under a certain load, which can cause damage to the tires.

Consequence: If the tire becomes damaged, causing premature tire wear, it can cause loss of vehicle control and increase the risk of a crash.

Remedy: Jayco will notify owners, and dealers will inspect the condition of the leaf spring, rubber equalizer and bump stop clearance, and provide replacement of the leave spring or rubber equalizer if necessary. This repair will be done free of charge. Interim notices notifying owners of safety risk were mailed December 2, 2019. The recall began December 20, 2019. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901443.

Reported: 2021-06-04 (June 4, 2021)

Jayco, Inc. (Jayco) is recalling certain 2017-2018 Jayco Designer, 2017-2021 Eagle HT, Eagle, Jay Feather, Jay Flight SLX, Jay Flight, North Point, Octane Superlite, Pinnacle, White Hawk, 2017-2020 Eagle HT, 2018-2021 Jay Flight Bungalow, 2017-2019 Octane, and 2019-2020 Eagle HTX travel trailers and fifth wheels equipped with a Winntec model 6020 two-stage propane regulator. The regulator may fail, causing an increase in propane pressure.

Consequence: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.

Remedy: Dealers will replace the regulator and test the propane system for leaks, free of charge. Owner notification letters were mailed August 3, 2021. Owners may contact Jayco customer service at 1-800-283-8267.