1997 Hyundai TIBURON: complaints, problems and recalls

WHILE DRIVING THE HOOD LATCH FAILED AND THE HOOD FLEW UP ONTO THE WINDSHIELD, DESTROYED THE HOOD AND LATCHES, DAMAGED THE ROOF, AND INJURED DRIVER. *NLM

Owner-reported narrative. 71,000 miles reported. Look up ODI 10018530 at NHTSA ↗

CONSUMER STATED DRIVER'S FRONT SEAT BELTS DID NOT HOLD THE PASSENGER IN THE SEAT. DEALER INDICATED THERE WAS NO RECALL ON FRONT SEAT BELT. *AK

Owner-reported narrative. Look up ODI 10059170 at NHTSA ↗

CONNSUMER STATED ELECTRICAL SYSTEM FAILED. *AK

Owner-reported narrative. 103,000 miles reported. Look up ODI 10097505 at NHTSA ↗

CHECK ENGINE LIGHT CAME ON WHILE DRIVING AND CAR BEGAN TO HEAT UP, THE DRIVER SIDE AIRBAG CAME ON AS WELL;TOOK IT IN FOR MAINTENANCE AND THE ALTERNATOR WAS REPLACED HOWEVER THE AIRBAG PROBLEM WAS NOT CORRECTED AND REMAINS ON. *JB

Owner-reported narrative. Look up ODI 10104616 at NHTSA ↗

SMELLED GAS FUMES STRONGLY UPON FILL-UP FOR SEVERAL DAYS, CHECK ENGINE LIGHT. TOOK CAR IN. MECHANIC SAID RECALL #00V095002 WAS IN EFFECT ON MY VEHICLE. TOOK IT TO DEALERSHIP TO HAVE THEM REPLACE DEFECTIVE PARTS (TANK & CAP). DEALERSHIP ONLY REPLACED CAP BUT DID NOT TELL ME AT THE TIME. WENT TO SMOG CAR NEXT YEAR AND COMES UP WITH EVAPORATIVE LEAK. TOOK BACK TO DEALERSHIP WHO TOLD ME "THERE IS A HUGE LEAK ON THE TOP OF YOUR GAS TANK." WILL NOT REPLACE FOR FREE. CALLED MANUFACTURER WHO SAID THAT DEALERSHIP CLAIMS THERE WAS NO LEAK AT TIME…

Owner-reported narrative. 83,539 miles reported. Look up ODI 10137351 at NHTSA ↗

TL*THE CONTACT OWNS A 1997 HYUNDAI TIBURON. WHILE DRIVING APPROXIMATELY 50 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND A LEAK IN THE FUEL TANK AS DETERMINED BY A PRESSURE CHECK. HYUNDAI WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 125,000.

Owner-reported narrative. 125,000 miles reported. Look up ODI 10222386 at NHTSA ↗

TL* THE CONTACT OWNS A 1997 HYUNDAI TIBURON. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE IT REPAIRED ACCORDING TO RECALL CAMPAIGN ID NUMBER 00V095002 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THERE WAS NOT A REMEDY REPAIR PERFORMED ON THE VEHICLE. AFTER THE INSPECTION THE "CHECK ENGINE" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE AUTHORIZED DEALER WAS NOTIFIED OF THE MALFUNCTIONS. THE TECHNICIAN STATED THAT THERE WAS AN INSPECTION PERFORMED UNDER THE PRIOR RECALL, SO THE VEHICLE WAS DENIED A FREE REMEDY REPAIR. THE CUR…

Owner-reported narrative. Look up ODI 10290954 at NHTSA ↗

TL* THE CONTACT OWNS A 1997 HYUNDAI TIBURON. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE SERVICED UNDER NHTSA CAMPAIGN NUMBER: 00V095001 (FUEL SYSTEM, GASOLINE), THERE WAS A PERSISTENT STRONG SMELL OF FUEL. THE CONTACT REMOVED THE BACK SEAT TO INSPECT THE ACCESS PORT FOR THE FUEL TANK AND DISCOVERED A 4 INCH FRACTURE ON THE STEEL FUEL TANK. THE CONTACT REACHED OUT TO THE DEALER TO INFORM THAT NHTSA CAMPAIGN NUMBER: 00V095001 (FUEL SYSTEM, GASOLINE) HAD NOT BEEN PERFORMED. THE DEALER DECLINED TO SERVICE THE VEHICLE. THE MANUFACTURER WAS MAD…

Owner-reported narrative. 243,420 miles reported. Look up ODI 10596491 at NHTSA ↗

Reported: 2000-03-28 (March 28, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.

Reported: 2000-07-21 (July 21, 2000)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.

Reported: 2001-11-06 (November 6, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST IN THE D-RING GUIDES AND MAKE IT INCONVENIENT TO EXTEND AND RETRACT THE SEAT BELTS.

Consequence: IF THE SEAT BELTS ARE INCONVENIENT TO USE, THE SEAT OCCUPANT MAY NOT BE INCLINED TO WEAR THE SEAT BELTS PROPERLY, INCREASING THE RISK OF INJURY IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL INSTALL A STOPPER OVER EACH FRONT SEAT BELT D-RING GUIDE TO ASSIST THE SEAT BELT TO SMOOTHLY EXTEND AND RETRACT. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

Reported: 1997-02-26 (February 26, 1997)

THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.

Consequence: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.