2009 Harley-Davidson FLHRC: complaints, problems and recalls

TL* THE CONTACT OWNS A 2009 HARLEY DAVIDSON ROAD KING CLASSIC. THE CONTACT STATED THE REAR BRAKE LIGHT SWITCH MELTED DUE TO THE LIGHT BEING BUILT NEXT TO THE ENGINE EXHAUST SYSTEM. THE FAILURE ALSO CAUSED THE REAR BRAKES TO STOP WORKING. THE VEHICLE WAS NOT TAKEN TO THE DEALER, BUT THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 5,200.

Owner-reported narrative. 5,200 miles reported. Look up ODI 10424304 at NHTSA ↗

I RECENTLY BOUGHT THIS BIKE USED, I BOUGHT IT FROM A NATIONAL MOTORCYCLE COMPANY WHO DEALS IN RENTAL BIKES. I WAS UNAWARE THIS BIKE YEAR (2009) HAD AN ISSUE WITH THE THROTTLE BY WIRE SYSTEM, AS OF TODAY'S DATE I'VE HAVE HAD THREE INSTANCES WHERE THE BIKE HAS WENT INTO BREAK DOWN MODE BECAUSE OF THIS FAULTY SYSTEM. THE PRIOR TWO INCIDENTS WERE DIAGNOSED AND APPARENTLY FIXED BY MY LOCAL BIKE SHOP, BUT THE SAME PROBLEM KEEPS OCCURRING. DURING THE FIRST INCIDENT, MYSELF AND PASSENGER WERE TRAVELING ON INTERSTATE 95 IN SOUTH FLORIDA AT NIGHT, THE B…

Owner-reported narrative. 36,750 miles reported. Look up ODI 10432529 at NHTSA ↗

AFTER DRIVING FOR APPROXIMATELY 10 MINUTES, MY MOTORCYCLE DID NOT RESPOND TO THROTTLE INPUT. THE ENGINE RAN, BUT WENT INTO "LIMP MODE", WHICH IS A LOW RPM ONLY MODE. I COULD NOT MAINTAIN THE POSTED SPEED LIMIT. I PULLED OVER, SHUT THE BIKE ON AND OFF SEVERAL TIMES AND THE ISSUE CEASED. THIS SITUATION OCCURRED ONE OTHER TIME LATER THAT SAME DAY BUT REQUIRED AT LEAST 5 ATTEMPTS AT TURNING THE POWER ON AND OFF BEFORE I COULD REGAIN THE FULL RANGE OF THROTTLE RESPONSE REQUIRED TO DRIVE ON THE ROAD. I TOOK THE BIKE INTO THE LOCAL HD DEALER. …

Owner-reported narrative. 4,100 miles reported. Look up ODI 10455386 at NHTSA ↗

WHEN DECELERATING, AND BIKE IS BETWEEN 35-45 MPH, A HARSH FRONT END WOBBLE OCCURS. CAN BE LIMITED BY TIGHTLY GRIPPING THE BARS. DEALER INDICATED IT WAS THE TIRES, THOUGH THEY WERE NEW. HAVE REPLACED THE TIRES TWICE SINCE AND STILL NO FIX. DEALER'S SOLUTION NOW IS TO SUSTAIN A HARD GRIP ON THE BARS AT ALL TIMES, WHICH IS UNSAFE AND NOT A PRACTICAL SOLUTION. IN THE INCIDENT ON 6/16/11, IT CAUSED LOSS OF CONTROL AND A SLOW-SPEED TUMBLE FROM THE BIKE, IN WHICH MY ELBOW WAS INJURED. *TR

Owner-reported narrative. 18,000 miles reported. Look up ODI 10494660 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 HARLEY DAVIDSON ROAD KING MOTORCYCLE. THE CONTACT STATED THAT THE THROTTLE WARNING LIGHT ILLUMINATED AND THE VEHICLE ENGAGED INTO IDLE MODE. THE CONTACT STATED THAT THE VEHICLE DID NOT STALL, BUT DID BECOME UNRESPONSIVE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE THROTTLE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 17,000. *TR UPDATED 8/5/13 *CN

Owner-reported narrative. 17,000 miles reported. Look up ODI 10510385 at NHTSA ↗

WHILE MOVING THE BIKE IN THE GARAGE UNDER POWER, THE FRONT BRAKE LEVER WOULD NOT MOVE. NO FRONT BRAKES!! LIFTED FOOT TO USE REAR BRAKE AND BIKE AND MY SELF FELL OVER AS BIKE HIT ANOTHER MOTORCYCLE IN GARAGE. THE BRAKE ARE FROZEN IN THE NON BRAKING POSITION. BIKE WAS LAST USED 4 DAYS AGO AND NO BRAKE PROBLEMS NOTED AT THAT TIME. HAVING BIKE TOWED TO SHOP FOR REPAIRS. *TR

Owner-reported narrative. 28,663 miles reported. Look up ODI 10566734 at NHTSA ↗

ABS QUIT WORKING, HAD TO REPLACE. START BIKE AND THE BRAKE HANDLE WAS FROZEN IN PLACE. IF YOU FORCE IT USING BOTH HANDS IT WOULD BEGIN TO WORK. WOULD WORK UNTIL TURN OFF THE BIKE. WHEN STARTING BIKE AGAIN, SAME PROBLEM. DEALERSHIP SAID "ABS HCU FAILED, MUST REPLACE..

Owner-reported narrative. 25,800 miles reported. Look up ODI 10885064 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 HARLEY-DAVIDSON FLHRC ROAD KING CLASSIC. WHILE PULLING INTO THE DRIVEWAY AT APPROXIMATELY 5 MPH AND ATTEMPTING TO APPLY THE BRAKES, THE ABS FAILED. THE CONTACT CRASHED INTO THE GARAGE DOOR. THE CONTACT RECEIVED INJURIES TO HIS FOOT, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE DEALER DIAGNOSED THAT THE ABS MODULE NEEDED TO BE REPLACED. THE MOTORCYCLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THE ELECTRONIC THROTTLE CONTROL SENSOR FAILED. WHILE THE VEHICLE WAS COVE…

Owner-reported narrative. 12,000 miles reported. Look up ODI 10893536 at NHTSA ↗

Reported: 2009-12-01 (December 1, 2009)

HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 TOURING FAMILY MOTORCYCLES, INCLUDING CVO TOURING AND TRIKE PRODUCTS, MANUFACTURED FROM JUNE 6, 2008 THROUGH NOVEMBER 19, 2009. THE FRONT FUEL TANK MOUNTS MAY DISTORT IN REACTION TO SEVERE FRAME DAMAGE FROM A FRONTAL COLLISION. THIS CONDITION MAY CAUSE A FUEL LEAK AT THE WELD OF THE FRONT BRACKET TO THE TUNNEL.

Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE, WHICH COULD LEAD TO INJURY OR DEATH TO THE RIDER.

Remedy: DEALERS WILL INSTALL A LEFT AND RIGHT BRACE, WHICH ARE INTENDED TO REDUCE FRONT MOUNT DISTORTION DURING CERTAIN CRASH CONDITIONS. THIS REPAIR WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Reported: 2011-10-19 (October 19, 2011)

HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009-2012 TOURING, CVO TOURING AND TRIKE VEHICLES MANUFACTURED FROM JUNE 6, 2008, THROUGH SEPTEMBER 16, 2011. SEE THE ABOVE LIST FOR THE MODELS INCLUDED IN THE RECALL. THE REAR BRAKE LIGHT SWITCH MAY BE EXPOSED TO EXCESSIVE HEAT FROM THE EXHAUST SYSTEM.

Consequence: THE EXCESSIVE HEAT MAY CAUSE THE SWITCH TO NOT ACTIVATE THE BRAKE LAMP OR ACTIVATE THE BRAKE LAMP WHEN NO BRAKE IS APPLIED AND/OR CAUSE A BRAKE FLUID LEAK AT THE BRAKE LIGHT SWITCH, AFFECTING REAR BRAKE PERFORMANCE. EITHER CONDITION MAY INCREASE THE RISK OF A CRASH.

Remedy: HARLEY-DAVIDSON WILL NOTIFY OWNERS, AND DEALERS WILL A INSTALL A REAR BRAKE LIGHT SWITCH KIT, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 31, 2011. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Reported: 2018-01-29 (January 29, 2018)

Harley-Davidson Motor Company (Harley-Davidson) is recalling all 2008-2011 Touring, CVO Touring and VSRC motorcycles equipped with anti-lock brakes (ABS), including Road King (FLHR), Road King Police (EFI) (FLHP), Road King Police (EFI) (FLHPE), Electra Glide Standard Police (EFI) (FLHTP), Electra Glide Classic (EFI) (FLHTC), Electra Glide Ultra Classic (EFI) (FLHTCU) and Street Glide (EFI) (FLHX), 2008 VROD (VRSCAWA), CVO Road King 4 (FLHRSE4), Night Rod (VRSCDA), CVO Ultra Classic 3 (FLHTCUSE3), Night Rod Special (VRSCDXA), 2008-2010 Road King Classic (EFI) (FLHRC), 2008-2009 Road Glide (EFI) (FLTR) and Electra Glide Standard (EFI) (FLHT), 2009-2010 V-Rod (VRSCAW), 2009 CVO Ultra Classic (FLHTCUSE4) and CVO Road Glide 3 (FLTRSE3), 2009-2011 Night Rod Special (VRSCDX) and V-Rod Muscle (VRSCF), 2010 CVO Ultra Classic 5 (FLHTCUSE5) and CVO Street Glide (FLHXSE), 2010-2011 Electra Glide Ultra Limited (FLHTK) and Road Glide Custom (FLTRX), 2011 Road Glide Ultra 103 (FLTRU103), Street Glide 103 (FLHX103), Road King Classic 103 (FLHRC103), CVO Ultra Classic 6 (FLHTCUSE6), CVO Road Glide Ultra (FLTRUSE), Road Glide Custom 103 (FLTRX103), and CVO Street Glide 2 (FLHXSE2) motorcycles. Deposits may form on components within the brake system if the DOT 4 brake fluid is not replaced for a prolonged period of time beyond the 2-year maintenance schedule specified in the Owner’s Manual.

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.