2019 Gmc SIERRA 3500: complaints, problems and recalls

DRIVING TO WORK. POWER STEERING WENT OUT AND BRAKING SYSTEM SEEM TO BE INEFFECTIVE. INSTRUMENT PANEL SERVICE LIGHT CAME ON WITH THE BATTERY INDICATOR DISPLAYING "BATTERY CHARGING SYSTEM" FAULT.

Owner-reported narrative. 9,470 miles reported. Look up ODI 11390458 at NHTSA ↗

The contact owns a 2019 GMC Sierra 3500. The contact stated that while operating the vehicle with the air conditioner on and blowing air the occupants had experienced an acid/chemical burning sensation to the eyes and throat. The failure was intermittent and had affected multiple occupants. The vehicle was taken to the local dealer who was unable to duplicate the failure and no service was performed. The manufacturer was also contacted. The failure mileage was 27,000.

Owner-reported narrative. 27,000 miles reported. Look up ODI 11421959 at NHTSA ↗

While towing our trailer, truck went into reduced power mode, regen message displayed; check engine light came on; loud bag occurred and hissing from under the hood. Truck slowed to 3 mph so we pulled to shoulder and turned the vehicle off. Truck had blown the hose off the the turbo. We reclamped and restarted. Displayed check engine light, reduced power & regen message to keep driving however truck wouldn’t go over a 3mph crawl. Truck lost all power, everything shut down and wouldn’t restart. No dash lights, no error, no crank, no power. We we…

Owner-reported narrative. Look up ODI 11438064 at NHTSA ↗

Intermittent issue with entire dash lights and radio lights going either fully out/off or extremely dark. Adjusting dimmer does not correct the issue. Affects driver safety due to acute driver distraction while trying to correct, and disables driver warning lights and all information systems, including towing related warnings (transmission temp/coolant temp, etc) Dealer advises to bring it back when it is occurring, but occurrences are not predictable, nor do they occur on a regular basis. Cause is unknown, but since dimmer switch does not c…

Owner-reported narrative. Look up ODI 11454246 at NHTSA ↗

The trailer brake system has stopped working and displays the message "Service trailer Brakes" it does this no matter if several different tralers are hooked to the truck. These trialers test fine in other trucks and with meters. The trailer brake controller does not work. There are many owners reporting the same thing. It is a critical safety feature to stop the truck & trailer and probably already has led to some fatalities. Please issue a recall. Thank You.

Owner-reported narrative. Look up ODI 11488836 at NHTSA ↗

Service brake brake system comes on randomly. have to hit reset when driving. constantly

Owner-reported narrative. Look up ODI 11591194 at NHTSA ↗

Bought the vehicle new in 2019 currently at a dealership to have the third in tank electric fuel pump installed. When it was in the shop for the second fuel pump installation the technician informed me that the pump can go out at any time causing a potential accident. Fortunately truck wouldn’t start and was diagnosed at dealership.

Owner-reported narrative. Look up ODI 11620902 at NHTSA ↗

The other day approximately 5 minutes after leaving my house I noticed a smell and saw some slight smoke coming from my rear window. I immediately turned off the rear defrost and my rear window shattered. The next day I discovered other Chevy/gmc vehicles have a recall for a short circuit in the rear defrost. Unfortunately the dealership will not help me until there is a recall with my vin as there is not an open recall on my vehicle.

Owner-reported narrative. Look up ODI 11643748 at NHTSA ↗

Reported: 2019-04-25 (April 25, 2019)

General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

Consequence: A short-circuit may damage the engine components and increase the risk of fire.

Remedy: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

Reported: 2021-07-01 (July 1, 2021)

General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

Consequence: An electrical short-circuit can increase the risk of a fire.

Remedy: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

Reported: 2023-02-02 (February 2, 2023)

General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

Consequence: An engine stall increases the risk of a crash.

Remedy: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

Reported: 2024-10-10 (October 10, 2024)

General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.

Reported: 2025-06-26 (June 26, 2025)

General Motors (GM) is recalling certain 2018 GMC Sierra 1500, 2019 Sierra 2500, 3500, Chevrolet Silverado 3500, and Chevrolet Silverado 2500 and 2018 Chevrolet Silverado 1500 Crew Cab vehicles. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increases the risk of injury or crash.

Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed July 23, 2025. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252513060.

Reported: 2026-03-19 (March 19, 2026)

General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 Crew Cab vehicles. The left or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.

Remedy: Dealers will replace the left and right-side RRAB modules, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262549710. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

Reported: 2026-05-21 (May 21, 2026)

General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles. The left-side or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.

Remedy: Dealers will replace both RRAB modules, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262557310. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 21, 2026. This recall expands previous NHTSA recall number 26V166.