2012 Gmc SIERRA 3500: complaints, problems and recalls

TRAVELING AT 60MPH ON TURNPIKE PULLING LONG HEAVY TRAILER IN RAIN AT NIGHT WITH MODERATE TO HEAVY TRAFFIC. SUDDEN SHUTDOWN OF ALL SYSTEMS. ENGINE SHUT OFF AND ALL ELECTRICAL SYSTEMS SHUT DOWN. UNABLE TO RESTART OR GET ELECTRICAL SYSTEMS TO WORK. WORKED VEHICLE TO SHOULDER AND HAD IT TOWED TO A DEALERSHIP. WAITING FOR THEM TO OPEN TO DIAGNOSE AND REPAIR. THIS MECHANICAL AND ELECTRICAL FAILURE HAD THE POTENTIAL FOR A CATASTROPHIC INCIDENT. *TR

Owner-reported narrative. 90,200 miles reported. Look up ODI 10500581 at NHTSA ↗

THIS STARTED JUST A FEW WEEKS AFTER I PURCHASED THE TRUCK, STILL UNDER WARRANTY. IT HAS BEEN IN THE SHOP TWICE FOR THIS. IT HAS HAPPENED 3 TIMES. WHILE DRIVING THE TRUCK WILL SHUT OFF LIKE YOU TURNED THE KEY OFF. VERY DANGEROUS WHEN DRIVING IN TRAFFIC. HAS BEEN IN SHOP TWICE FOR THIS PROBLEM, GMC HAS FAILED TO FIND OR FIX THE PROBLEM. I TOLD THEM THAT I WOULD NOT PUT MY FAMILY BACK INTO A TRUCK THAT HAS THE POSSIBILITY OF CAUSING A WRECK AND GETTING THEM HURT. FILED A CLAIM [XXX] WITH GMC CUSTOMER SERVICE, TRYING TO GET SOME HELP. NOTHING HAPPE…

Owner-reported narrative. 29,958 miles reported. Look up ODI 10520844 at NHTSA ↗

WHILE PULLING MY FIFTH WHEEL TRAILER 12500# AT HIGHWAY SPEED 65 MPH PULLING A GRADE THE CHECK ENGINE LIGHT CAME ON AND THE REDUCED ENGINE POWER MESSAGE APPEARED ON THE DASH. THIS REDUCED AND LIMITED THE SPEED TO 50 MPH AND STEPS THE TRUCK DOWN FROM THERE UNTIL YOU CAN ONLY DO 20 MPH ON THE INTERSTATE. THIS ISSUE HAS HAPPENED THREE TIMES IN THREE MONTHS. *TR

Owner-reported narrative. 16,400 miles reported. Look up ODI 10531497 at NHTSA ↗

DRIVING FROM GM DEALER FOR TWO MILES CHANGE FUEL FILTER MESSAGE APPEARED AND ENGINE DIED. TOWED TO A DEALER DIAGNOSED AS A HIGH PRESSURE INJECTOR PUMP FAILURE WITH METAL CONTAMINATION TO FUEL SYSTEM. I HAVE FOUND A BULLETIN DATED 2009 FROM EQUIPMENT MANUFACTURERS. THIS JOINT STATEMENT HAS INFORMATION ABOUT THE FUEL USED IN THE USA THAT I WAS NOT AWARE OF AND MAY HAVE AVOIDED THIS FAILURE. THIS IS A VERY EXPENSIVE REPAIR AS I USE MY TRUCK FOR WORK. *TR

Owner-reported narrative. 140,000 miles reported. Look up ODI 10607796 at NHTSA ↗

WHILE DRIVING ON HIGHWAY, TRANSMISSION SHIFTS HARD TO HIGHER GEAR. THIS STARTED ALL OF A SUDDEN WILL TAKE TO DEALERSHIP. *JS

Owner-reported narrative. 31,200 miles reported. Look up ODI 10681860 at NHTSA ↗

THE VEHICLE WILL NOT SHIFT PROPERLY WHEN TOWING A TRAILER. WHILE GOING UP A HILL, THE TRANSMISSION WILL NOT DOWNSHIFT PROPERLY. WHILE GOING DOWNHILL, THE VEHICLE DOWNSHIFTS TO 2ND GEAR WHILE GOING 60 MPH. I HAVE CONTACTED GM SEVERAL TIMES (THEY HAVE IT ON FILE) THAT THERE IS A PROBLEM WITH THE TRANSMISSION. THEY UNDERSTAND BUT SAID THAT THEY CANNOT DO ANYTHING ABOUT IT. THIS HAS BEEN HAPPENING SINCE IT WAS BRAND NEW. OVER AND OVER AGAIN.

Owner-reported narrative. 150 miles reported. Look up ODI 10949976 at NHTSA ↗

THE GMC SIERRA 3500HD WHILE IN REGENERATION MODE FUNNELS EXHAUST DIRECTLY INTO THE CAB THROUGH THE VENTS. WHILE GM RECOGNIZED THIS AS A FLAW AND CAME UP WITH A FIX FOR IT, THEY WILL ONLY REPAIR IT IN A 5 YEAR OR 100,000 MILE WINDOW. HOW IS THIS NOT A SAFETY ISSUE WITHOUT AN EXPIRATION?

Owner-reported narrative. 35,900 miles reported. Look up ODI 11032885 at NHTSA ↗

The service brakes lights has come on a d disabled my brake controller. This is a safety issue while towing and completely unacceptable.

Owner-reported narrative. Look up ODI 11455127 at NHTSA ↗

Reported: 2017-10-19 (October 19, 2017)

General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.

Consequence: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

Remedy: GM has notified owners, and dealers will replace the rear tank fuel pump or update the fuel-level sensor software, as well as inspect the front tank, replacing it as necessary, free of charge. The recall began December 11, 2017. Owners may contact GM customer service for Chevrolet 1-800-222-1020 or for GMC customer service at 1-800-462-8782. GM's number for this recall is 17399.

Reported: 2018-04-26 (April 26, 2018)

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

Reported: 2021-02-05 (February 5, 2021)

General Motors, LLC (GM) is recalling certain 2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328770.

Reported: 2021-02-05 (February 5, 2021)

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.