2014 Freightliner CASCADIA: complaints, problems and recalls

WITH MERITOR WABCO ONGUARD CRUISE CONTROL EQUIPPED FROM THE FACTORY. THE CRUISE CONTROL UNIT OFTEN TIMES SLAMS ON THE BRAKES AFTER ERRONEOUSLY DETECTING AN IMMINENT COLLISION. IT FREQUENTLY HARD BRAKES AFTER DETECTING ITEMS THAT ARE WELL OUT OF THE TRAVEL PATH OF THE VEHICLE. THIS BEHAVIOR IS NOT PREDICTABLE TO EITHER THE DRIVER OR NEARBY VEHICLES, AND WILL EVENTUALLY LEAD TO A CRASH OR A DANGEROUS SHIFTED LOAD. I HAVE EXPERIENCED THIS IN 4 DIFFERENT FREIGHTLINER CASCADIAS OF RECENT VINTAGE (2012 OR NEWER), ALL EQUIPPED WITH THE ONGUARD CRUISE …

Owner-reported narrative. 1,000 miles reported. Look up ODI 10578648 at NHTSA ↗

I PUT THE TRUCK IN THE SHOP ON 07/22/14 FOR SEVERAL REASONS ON THIS DAY BUT THE TWO MOST IMPORTANT REASONS WERE: 1) TRUCK LEANING VERY NOTICEABLY ON THE DRIVERS SIDE AND 2) TRUCK POPS UNDER THE FLOORBOARD BENEATH THE DRIVER (AND NOW ON PASSENGER SIDE AS WELL) WHEN HAULING A LOADED TRAILER. IT'S BEEN POPPING/TWISTING SINCE APRIL 2014. IT SOUNDS LIKE FRAME IS POPPING AND TWISTING. IT HAS ALSO HAPPENED WHEN THE TRUCK WAS SITTING STILL, PARKED. I POINTED OUT TO THE FREIGHTLINER SERVICE WRITEUP THAT I NOTICED THAT A FRAME MOUNT WAS LOOSE AND SH…

Owner-reported narrative. 71,108 miles reported. Look up ODI 10630909 at NHTSA ↗

WE WERE ASLEEP IN THE TRUCK WITH THE CURTAINS CLOSED. THE ENGINE WAS RUNNING SMOOTHLY AND THE AIR CONDITIONING WAS BLOWING COLD AIR. WE WERE AWAKENED BY SOMEONE POUNDING ON OUR DOOR. WHEN I OPENED THE CURTAIN, THE LEFT SIDE OF THE WINDSHIELD WAS A SHEET OF FLAMES COMING OUT FROM UNDER THE HOOD. FLAMES WERE ALSO COMING OUT OF THE LEFT SIDE HOOD LATCH ACCESS HOLE AND COVERING THE LEFT SIDE WING WINDOW. WE EXITED THE TRUCK BY THE RIGHT SIDE DOOR AND TOOK A PICTURE OF THE FIRE WITHIN TWO MINUTES OF GETTING OUT. THIS PICTURE IS AVAILABLE. ANOTHER P…

Owner-reported narrative. 276,000 miles reported. Look up ODI 10704799 at NHTSA ↗

THIS SET OF CIRCUMSTANCES OCCURS EVERY TIME I PASS UNDER THE RAILROAD OVERPASS, GOING SOUTHBOUND, ON A WEEK DAY (BETWEEN 10 AND 20 TIMES SO FAR). FREIGHTLINER ALWAYS ACTED LIKE THEY HAD NEVER HEARD OF THIS BEFORE. WHEN I TOLD THEM TO CHECK THE GPS AND THEY WOULD SEE THAT IT ALWAYS OCCURS IN THE EXACT SAME LOCATION THEY'D GIVE ME SOME MUMBO JUMBO. ON SEVERAL OCCASIONS FREIGHTLINER OVERRODE THE FAULT CODES AS I WAS TALKING TO THEM. BUT CERTAIN THINGS WERE CHANGED BY FREIGHTLINER. AFTER ABOUT THE FIRST 10 OF THE EVENTS I NO LONGER RECEIVED EMAILS …

Owner-reported narrative. Look up ODI 10733153 at NHTSA ↗

THIS IS THE FIRST TIME I HAVE EXPERIENCE AN IMMEDIATE STALL WITH NO RESTART IN THE 45 YEARS OF PROFESSIONAL DRIVING. I WAS JUST BEGINNING TO GO DOWN HILL AT MM138 ON INTERSTATE 5, WHEN ALL THE SUDDEN THE DASH LIGHTS AND GAUGES STARTED TO QUIVER AS IF THE ELECTRICAL SYSTEM WAS LOOSING CURRENT. MORE IMPORTANTLY, THE TRUCK LOST ALL ENGINE AND TRANSMISSION FUNCTIONS TO INCLUDE JAKE AND POWER BRAKING, LOSS OF POWER STEERING. I WAS ABLE TO MAINTAIN CONTROL ALL THE WAY DOWN TILL THE ROAD LEVELED OUT. AFTER WAITING SEVERAL MINUTES, I WAS ABLE TO R…

Owner-reported narrative. Look up ODI 10838295 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 FREIGHTLINER CASCADIA. WHILE THE VEHICLE WAS SHUT OFF, THE CONTACT SMELLED SMOKE AND NOTICED FLAMES COMING FROM THE VEHICLE. THE CONTACT EXTINGUISHED THE FIRE. THE CONTACT CALLED TOM NEHL TRUCK COMPANY (417 EDGEWOOD AVE S, JACKSONVILLE, FL 32254, [phone removed]) AND WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER A WARRANTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 538,123.

Owner-reported narrative. 538,123 miles reported. Look up ODI 11162468 at NHTSA ↗

IMMEDIATE STALLS WITH NO RESTART. DOWNSHIFTING AS APPROACHING A STOPLIGHT, DASH LIGHTS AND GAUGES STARTED FLICKERING.TRUCK LOST ALL ENGINE AND TRANSMISSION POWER, INCLUDING POWER STEERING WHILE TRUCK IS IN MOTION. TRUCK THEN SHOWS ICU FAULT. AFTER APPROXIMATELY AN HOUR FAULT WILL NO LONGER SHOW AND TRUCK WILL START WITHOUT PROBLEM. PROBLEM HAS ALSO OCCURRED APPROACHING STOP SIGNS. I HAVE HAD THE TRUCK INSPECTED TODAY AND TOLD IT MAY HAVE BEEN PNDB. *DT*JB

Owner-reported narrative. 519,140 miles reported. Look up ODI 11191031 at NHTSA ↗

FUEL HIGH PRESSURE PUMP FAILED AND CONTAMINATED ALL SYSTEM AND REPLACED FUEL PUMP AND FILTERS SYSTEM ALL LINES, CLEANING FUEL TANKS BECAUSE DEBRIS FROM FUEL PUMP!

Owner-reported narrative. 842,000 miles reported. Look up ODI 11195609 at NHTSA ↗

Reported: 2013-03-18 (March 18, 2013)

Daimler Trucks North America (DTNA) is recalling certain model year 2012-2014 Freightliner Cascadia tractors manufactured from April 12, 1210, through March 2, 2013, and equipped with a SAMCAB software version 6.2. On vehicles configured to have the turn signals operate as Daytime Running Lights (DRLs) and the 'Turn-Tip' turn signal function activated, the DRLs may not illuminate properly after using the 'Turn-Tip' function while driving.

Consequence: Failure of the DRLs to illuminate reduces visibility to other drivers and increases the risk of a vehicle crash.

Remedy: DTNA sent notification to owners on May 6, 2015, instructing them to contact their dealers and arrange to have the free SAMCAB software updated to correct the operation of the DRLs and "Turn Tip" feature. Owners may contact DTNA at 1-800-547-0712.

Reported: 2013-04-09 (April 9, 2013)

Daimler Trucks North America (DTNA) is recalling certain model year 2012-2014 Cascadia and Coronado vehicles manufactured between November 21, 2011, and April 3, 2013. In the affected vehicles, when the ignition is off and the door is opened without the parking brake applied, the dashboard does not display the correct message of "Park Brake Off Door Open."

Consequence: Without the proper warning, a driver may not be reminded to apply the parking brake which may lead to a vehicle roll away, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will update then display software. The safety recall began on June 6, 2013. Owners may contact DTNA at 1-800-547-0712. Daimler's recall campaign number is FL-642.

Reported: 2013-09-05 (September 5, 2013)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014 Freightliner Cascadia trucks manufactured January 21, 2013, through May 10, 2013; and equipped with Wabco Maxxus Brakes. The brake caliper mounting bolts may be incorrectly torqued, which could result in the bolts loosening.

Consequence: The bolts may not provide adequate clamping force between the brake caliper and brake anchor plate, resulting in the caliper detaching and thus reduced brake effectiveness. Reduced brake effectiveness increases the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect and tighten the caliper mounting bolts, as needed, free of charge. The recall began on November 8, 2013. Owner's may contact Daimler at 1-800-547-0712. Daimler's recall number is FL-644.

Reported: 2013-11-29 (November 29, 2013)

Daimler Trucks North America (DTNA) is recalling certain model year 2014 Freightliner 108SD, 114SD, 122SD, Coronado, Argosy, Cascadia, M2 Business Class, and Western Star 4700, 4900, and 6900 vehicles manufactured August 5, 2013, through November 15, 2013; and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: DTNA will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall is expected to begin by January 26, 2014. Owners may contact Daimler at 1-800-385-4357. DTNA's number for this campaign is FL-654.

Reported: 2013-12-17 (December 17, 2013)

Daimler Trucks North America (DTNA) is recalling certain model year 2013-2014 Freightliner Cascadia trucks manufactured December 11, 2012, through November 27, 2013 and equipped with a Meritor Wabco electronically controlled air suspension (ECAS) system. In the affected vehicles, the wiring harnesses for the ECAS may have been reversed.

Consequence: If the wiring harnesses are connected in reverse, it may adjust the suspension axle height incorrectly, reducing driving traction and parking brake effectiveness. Either result increases the risk of a crash.

Remedy: DTNA will notify the owners, and dealers will inspect the ECAS wiring, correcting it as necessary, free of charge. The recall began on February 24, 2014. Owners may contact Daimler at 1-800-547-0712. DTNA's number for this recall is FL-656.

Reported: 2014-02-21 (February 21, 2014)

Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins Westport Model ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.

Consequence: The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.

Remedy: Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.

Reported: 2014-03-28 (March 28, 2014)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014 Freightliner 108SD, 114SD, 122SD, Coronado, Argosy, Cascadia, Columbia, and M2 Business Class, and Western Star 4700, and 4900 vehicles manufactured August 5, 2013, through November 15, 2013, and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: DTNA will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on May 22, 2014. Owners may contact Daimler at 1-800-385-4357. DTNA's number for this campaign is FL-661. Note: This is an expansion of recall 13V-604.

Reported: 2014-09-23 (September 23, 2014)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2015 Freightliner Cascadia vehicles manufactured May 5, 2014, to August 18, 2014. The affected vehicles are equipped with certain 1100W, 1500W, or 2000W inverters sold as a standalone option with both the Thermo King TriPac EVOLUTION and TriPac-e Auxiliary Power Units ("APU"). The Thermo King inverters provide 120V AC household power to a tractor cabin. The inverters may spark or overheat, resulting in a potential fire.

Consequence: An inverter fire may result in a vehicle fire.

Remedy: DTNA will notify owners, and Thermo King will either replace the inverter free of charge or refund the full purchase price. The recall began on November 14, 2014. Owners may contact Thermo King customer service at 1-866-766-2708. Owners may also contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-668.

Reported: 2014-10-29 (October 29, 2014)

Daimler Trucks of North America LLC (DTNA) is recalling certain model year 2011-2015 Freightliner Cascadia and M2 trucks manufactured June 2, 2011 to October 23, 2014. The vehicles are not in compliance with the requirements of the Federal Motor Vehicle Safety Standards No. 303, "Fuel System Integrity Of Compressed Natural Gas Vehicles." Specifically, the tail pipe on these vehicles terminates under the compressed natural gas (CNG) tank and can overheat the fuel system.

Consequence: Due to the area of its placement, the exhaust system forces heat around, and may overheat, the fuel system components, increasing the risk of a vehicle fire.

Remedy: DTNA will notify owners, and dealers will extend the tailpipe beyond the cabinet, free of charge. The recall began Feburary 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-671.

Reported: 2014-11-10 (November 10, 2014)

Daimler Trucks North America LLC (Daimler) is recalling certain model year 2014-2015 Freightliner 122SD, Argosy, and Cascadia trucks manufactured July 22, 2013, to October 13, 2014, equipped with Wabco Quick Release Valves with Double Check manufactured February 6, 2013, to April 19, 2014. The affected vehicles may have been produced with a defective valve seat installed.

Consequence: Improper seating can result in the valves improperly adjusting air pressure levels, thereby reducing the braking performance of the vehicles and increasing the risk of a crash.

Remedy: Daimler will notify owners, and dealers will inspect, and replace the valves, free of charge. The recall began on December 30, 2015. Owners may contact Daimler customer service at 1-800-745-8000. Daimler's number for this recall is FL-673.

Reported: 2015-02-23 (February 23, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2015 Freightliner Cascadia trucks manufactured November 19, 2013, to July 14, 2014, and equipped with certain model Side-Mount compressed natural gas (CNG) Fuel Systems, Part No. 23736011, manufactured August 1, 2013, to August 21, 2014 and Motion Industries T1700-06 flexible fuel hoses. The stainless steel braid hose reinforcement may corrode prematurely near the fitting crimp inside the slave tank enclosure.

Consequence: If the corrosion progresses and goes undetected, the hose could begin to leak CNG, increasing the risk of a fire in the presence of an ignition source.

Remedy: DTNA will notify owners and dealers will replace the defective hose, free of charge. The recall began on April 1, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-678.

Reported: 2015-10-01 (October 1, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2011-2014 Cascadia, Business Class M2, Coronado, and Columbia Glider vehicles manufactured April 5, 2010, to June 15, 2013. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.

Consequence: If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.

Remedy: DTNA will notify owners, and DTNA authorized service facilities will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 20, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-692.

Reported: 2015-12-07 (December 7, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2013-2015 Freightliner Cascadia vehicles manufactured March 27, 2015, to November 4, 2014, and powered by compressed natural gas (CNG). The affected vehicles have a tailpipe that allows hot exhaust to exit near the CNG tank pressure relief device (PRD).

Consequence: Hot exhaust in close proximity to the PRD may cause the PDR to activate and CNG to be unexpectedly released from the tank. Discharge of CNG in the presence of an ignition source can increase the risk of a fire.

Remedy: All the vehicles involved in this recall campaign have been repaired. The recall is began on March 13, 2015. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-695.

Reported: 2016-08-31 (August 31, 2016)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2017 Freightliner M2 Business Class, 108 SD, 114 SD, Cascadia, Coronado, Western Star 4700, 4800, and 5700 XE trucks manufactured March 15, 2013, to July 29, 2016 and equipped with Conmet aluminum non-high capacity hubs. These vehicles specify a front axle weight limit that may be greater than that of the hub capacity. As a result, the hub may fail and the wheel may separate from the axle.

Consequence: If a wheel separates from the axle, there would be an increased risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the front axle hubs, free of charge. The recall began during November 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-718.

Reported: 2016-09-13 (September 13, 2016)

Daimler Trucks North America, LLC. (DTNA) is recalling certain model year 2013-2017 Freightliner Cascadia vehicles manufactured September 24, 2012, to May 27, 2015 and equipped with compressed natural gas (CNG) engines. The affected vehicles have a Power Distribution Module (PDM) that is mounted near the CNG fuel tank. Due to its location, the PDM may be sprayed with water and contaminants from the road, possibly causing the PDM to short circuit.

Consequence: If the PDM short circuits, there would be an increased risk of a fire, especially if the nearby CNG tank leaks.

Remedy: DTNA will notify owners, and dealers will relocate the PDM, free of charge. An interim notice was mailed to owners on November 7, 2016. The recall began on March 3, 2017. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-721.

Reported: 2017-11-27 (November 27, 2017)

Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.

Consequence: If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.

Reported: 2017-12-15 (December 15, 2017)

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.

Reported: 2018-07-31 (July 31, 2018)

Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2015 Freightliner Cascadia, Coronado, Business Class M2, 114SD, and Western Star 4900 trucks. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the tie-rod tube.

Consequence: A tie-rod failure would cause a disconnect between the front wheels, resulting in a loss of steering ability, thereby increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the brake linings, brake spider, and tie-rod, free of charge. The recall began March 22, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL782.

Reported: 2019-02-12 (February 12, 2019)

Daimler Trucks North America LLC (DTNA) is recalling certain 2013-2016 Freightliner Cascadia vehicles equipped with Hendrickson 5" drop axles. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the tie-rod tube.

Consequence: A tie-rod failure would cause a disconnect between the front wheels, resulting in a loss of steering ability, thereby increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the stamped brake spiders and the tie-rod, free of charge. The recall began April 12, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-807.

Reported: 2019-05-14 (May 14, 2019)

Daimler Trucks North America LLC (DTNA) is recalling certain 2004-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Columbia, Classic, FL80, FLD 120SD, Business Class M2, Western Star 4700, 4900, 6900, Sterling Acterra, L7500, LT7500, L8500, LT8500, L9500, and LT9500 vehicles. The vehicles may have an insufficient service brake air reservoir capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: An insufficient air reservoir volume may reduce brake effectiveness, increasing the risk of crash.

Remedy: DTNA will notify owners, and dealers will add air reservoir capacity to the affected vehicles. Owner letters were mailed on November 29, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-815.

Reported: 2020-04-14 (April 14, 2020)

Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: The vehicle's rearward visibility may be reduced, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.