2016 Freightliner 114SD: complaints, problems and recalls

Reported: 2015-06-03 (June 3, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2016 Freightliner 114SD and M2 Business Class trucks, 2008-2009 Sterling LT8500 trucks and Thomas Built Bus Saf-T-Liner HDX transit buses equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.

Consequence: If engine oil comes into contact with a hot surface, there is an increased risk of a fire.

Remedy: Cummins will notify owners on behalf of DTNA, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000 or Cummins customer service at 1-800-343-7357. DTNA's number for this recall is FL-681.

Reported: 2015-09-22 (September 22, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2016 Freightliner Business Class M2, 108SD, and 114SD trucks manufactured April 30, 2013, to September 14, 2015. Due to incorrect positioning, the rear disk brake calipers may contact the spring suspension reducing rear brake performance.

Consequence: A reduction in braking performance can increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will correct the orientation of the rear brake calipers, free of charge. The recall began on November 13, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-688.

Reported: 2015-09-30 (September 30, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2016 Freightliner Cascadia, Business Class M2, 108SD, 114SD, 122SD, Coronado Glider, and Columbia Glider vehicles manufactured June 29, 2015, to September 7, 2015. In the affected vehicles, the steering arm bolts may not be properly tightened.

Consequence: If the steering arm bolts are not properly tightened, the steering arm may separate from the knuckle causing a loss of steering and increasing the risk of a crash.

Remedy: DTNA will notify owners, and Daimler Trucks North America or Detroit Diesel authorized service facilities will inspect the steering arm bolts, tightening them as necessary, free of charge. The recall began on November 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-691.

Reported: 2015-10-01 (October 1, 2015)

Daimler Trucks North America, LLC (DTNA) is recalling certain model year 2015-2016 Freightliner Cascadia, Business Class M2, 108SD, 114SD, and Western Star 4700 trucks manufactured January 4, 2015, to April 24, 2015, and equipped with Eaton Fuller FR 10-speed manual transmissions. In the affected vehicles, when the transmission shift lever is moved from reverse to neutral, the reverse gear may stay engaged. When the transmission shift lever is moved from reverse to a forward gear position, the transmission may mechanically lock because both the reverse gear and forward gear are simultaneously engaged.

Consequence: Even though the transmission has been shifted out of reverse into neutral, the vehicle may unexpectedly move backwards, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect and repair the affected transmissions if necessary, free of charge. The recall began on November 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-693.

Reported: 2015-10-02 (October 2, 2015)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2016 Freightliner Cascadia, Business Class M2, 108SD, 114SD, and 122SD, Western Star 4700 and 4900, Thomas Built Buses Saf-T-Liner C2, and Freightliner MT55 vehicles manufactured August 7, 2015, to August 26, 2015. The affected vehicles are equipped with certain Cummins ISB6.7, ISL9, ISX12 or ISX15 engines whose engine control module (ECM) may short circuit and blow a fuse resulting in the engine stalling without warning.

Consequence: An engine that stalls without warning increases the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the ECM free of charge. The recall began on October 22, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-690.

Reported: 2015-12-22 (December 22, 2015)

Daimler Trucks North America, Inc. (DTNA) is recalling certain model year 2015-2016 Freightliner 108SD, 114SD, Business Class M2, and Western Star 4900 vehicles manufactured September 26, 2014, to November 6, 2015, and equipped with certain drive axles manufactured by Marmon-Herrington. The affected axles have hex nuts on the flange yoke that may not have been properly tightened.

Consequence: If the hex nuts are not tightened to specification, the driveshaft may disconnect from the drive axle, resulting in a loss of propulsion and increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect the hex nuts, tightening them as necessary, free of charge. The recall began on February 5, 2016. Owners may contact DTNA customer service at 1-800-745-8000, or Marmon-Herrington customer service at 1-800-547-0712. DTNA's number for this recall is FL-699.

Reported: 2016-04-12 (April 12, 2016)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2010-2017 Freightliner M2 Business Class, 108SD, 114SD, and Columbia trucks manufactured from January 6, 2010, through February 29, 2016, equipped with certain Bendix rear disk brakes and spring suspensions. The rear disk brake caliper may have been installed incorrectly, thus allowing the caliper to contact the suspension.

Consequence: Caliper contact with the spring suspension may reduce the braking effectiveness, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will correct the orientation of the rear brake calipers, as necessary, free of charge. The recall began on June 8, 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's recall number for this campaign is FL-705.

Reported: 2016-04-12 (April 12, 2016)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2016 114SD and M2 Business Class trucks manufactured from June 10, 2015, through October 1, 2015. The affected vehicles have front axles that have a 20,000 pound capacity, however, the installed Bridgestone R249 front tires have a lower maximum load capacity.

Consequence: The operator may unintentionally overload the tires, possibly causing tire failure thereby increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the front tires with tires of a higher load capacity, free of charge. The recall began on June 7, 2016. Owners may contact DTNA customer service at 800-547-0712. DTNA's recall number for this campaign is FL-706.

Reported: 2016-08-31 (August 31, 2016)

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2017 Freightliner M2 Business Class, 108 SD, 114 SD, Cascadia, Coronado, Western Star 4700, 4800, and 5700 XE trucks manufactured March 15, 2013, to July 29, 2016 and equipped with Conmet aluminum non-high capacity hubs. These vehicles specify a front axle weight limit that may be greater than that of the hub capacity. As a result, the hub may fail and the wheel may separate from the axle.

Consequence: If a wheel separates from the axle, there would be an increased risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the front axle hubs, free of charge. The recall began during November 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-718.

Reported: 2016-09-13 (September 13, 2016)

Daimler Trucks North America, LLC (DTNA) is recalling certain model year 2016-2017 Freightliner M2 Business Class and 114 SD trucks manufactured March 10, 2015, to July 11, 2016. The brake caliper mounting bolts on the affected vehicles may be incorrectly torqued, allowing the bolts to loosen and detach.

Consequence: If the brake caliper mounting bolts loosen or detach, braking ability may be reduced, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect the brake caliper mounting bolts for the proper torque and tighten them as necessary, free of charge. An interim notice was sent to owners on November 7, 2016. The final remedy is now available. A second notice was mailed to owners on January 26, 2017. Owners may contact DTNA customer service at -800-547-0712. DTNA's number for this recall is FL-722.

Reported: 2017-01-19 (January 19, 2017)

Daimler Trucks North America LLC (DTNA) is recalling certain 2016-2017 Freightliner Business Class M2, 108SD, and 114SD trucks. The affected trucks have been modified to be equipped with both left hand and right hand instrument clusters. Due to incompatibilities between the displays, the instrument clusters and/or turn signals may become unresponsive.

Consequence: Unresponsive instrument clusters and/or turn signals can increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the left instrument cluster with a cluster compatible with the right display, free of charge. The recall began on May 8, 2017. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL731.

Reported: 2017-06-26 (June 26, 2017)

Daimler Trucks North America (DTNA) is recalling certain 2015-2017 Freightliner M2 Business Class, 108SD, and 114SD vehicles. The affected vehicles might not have a required check valve installed in one of the ports of the spring brake modulation valve. Without the valve, the primary air system is not isolated from the secondary air system.

Consequence: A rapid loss of air pressure in the secondary system could cause a similar rapid loss of pressure in the primary system, which may lead to a sudden application of the parking brakes. This could increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect the vehicles, installing a check valve, as necessary, free of charge. The recall began on August 24, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-740.

Reported: 2019-05-14 (May 14, 2019)

Daimler Trucks North America LLC (DTNA) is recalling certain 2004-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Columbia, Classic, FL80, FLD 120SD, Business Class M2, Western Star 4700, 4900, 6900, Sterling Acterra, L7500, LT7500, L8500, LT8500, L9500, and LT9500 vehicles. The vehicles may have an insufficient service brake air reservoir capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: An insufficient air reservoir volume may reduce brake effectiveness, increasing the risk of crash.

Remedy: DTNA will notify owners, and dealers will add air reservoir capacity to the affected vehicles. Owner letters were mailed on November 29, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-815.

Reported: 2020-08-31 (August 31, 2020)

Fontaine Modification (Fontaine) is recalling certain 2016-2020 Autohaulers built on Freightliner 114SD chassis. Movement of the cab during operation may cause the battery cable to contact the bottom of the cab, possibly damaging the cable.

Consequence: Damage to the cable can result in an electrical short, increasing the risk of a fire.

Remedy: Fontaine will notify owners, and dealers will ensure that the cable cannot be damaged, free of charge. The recall began November 4, 2020. Owners may contact Fontaine customer service at 1-800-366-8246.

Reported: 2021-11-17 (November 17, 2021)

Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2021 Freightliner SD 108, Freightliner SD 114, 2016-2020 Freightliner Coronado, 2013 Western Star 6900, 2013-2022 Western Star 4700, Western Star 4900, and 2022 49X vehicles. The tires and rims are not approved and rated for these vehicles from the Tire and Rim Association or tire manufacturer. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims-Other Than Passenger Cars."

Consequence: Unapproved tires that are not rated for the vehicle can cause tire performance issues, increasing the risk of a crash.

Remedy: Dealer will inspect and replace, as necessary, tires and rims, free of charge. Interim owner notification letters were mailed January 14, 2022. Owner notification letters were mailed on April 22, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall FL-908.