1987 Ford TAURUS: complaints, problems and recalls

I AM DRIVING AND MY CAR STOPS RUNNING. IT JUST DIES, I PUT IT IN PARK AND IT STARTS AGAIN. THIS IS DANGEROUS ESPECIALLY WHEN I AM IN HEAVY TRAFFIC.*JB

Owner-reported narrative. 66,673 miles reported. Look up ODI 10010119 at NHTSA ↗

I WAS DRIVING AND THE TRANSMISSION SLIP AND THEN WENT OUT AND NOW CAN'T EVEN DRIVE IT. *NLM

Owner-reported narrative. 50,198 miles reported. Look up ODI 10013858 at NHTSA ↗

FAILURE OF IGNITION SWITCH AND PLUG ASSEMBLY DUE TO OVERHEATING. SWITCH MELTED AND SO DID PLUG ASSEMBLY. THIS SAME REPAIR WAS PREVIOUSLY DONE AT APPROXIMATELY 100,000 MILES. WHEN VEHICLE WAS PURCHASED AT APPOXIMATELY 87,000 MILES, IT WAS OBSERVED THAT THIS REPAIR HAD BEEN DONE PREVIOUS TO THAT TIME AS WELL. THIS IS A CHRONIC FAILURE. ANY TSB'S OR RECALLS ON THIS MATTER? RELATED PROBLEM: EXCESSIVE CURRENT DRAW ON ALTERNATOR OUTPUT WIRE TO STARTER SOLENOID (BATTERY) CAUSING WIRE TO RUN HOT (WITH ALTERNATOR TURNING). THIS HAS RESULTED I…

Owner-reported narrative. 156,000 miles reported. Look up ODI 10070753 at NHTSA ↗

DUE TO A KNOWN DEFECT AND FAILURE OF THE SEAT BELT OF MY 1987 FORD TAURUS, I WENT HEAD FIRST INTO THE WINDSHIELD, MY KNEES HIT THE DASHBOARD, AND I SUFFERED INJURIES. IT WOULD BE A SIMPLE FIX FOR FORD TO CORRECT THE KNOWN DEFECT IN THIS VEHICLE. THE MANUFACTURER DID NOTHING TO PROTECT THE PUBLIC. I COULD HAVE EASILY BEEN KILLED. *JB

Owner-reported narrative. 145,000 miles reported. Look up ODI 10098686 at NHTSA ↗

DT: THE CONTACT STATES THAT THE 1987 FORD TAURUS STATION WAGON EXPERIENCED A VERY VIOLENT ACCELERATION. WHILE DRIVING ALONG AT 30 MPH THE VEHICLE RACED. THE CONTACT THEN PUT FOOT ON THE BRAKE AND THE CAR SKIDDED AND THE CAR WOULD NOT STOP, AND BEGAN GOING FASTER. THE HAND BRAKE WAS PULLED. THE BRAKE WAS PULLED SO HARD THAT SOMETHING BROKE AND STARTED LEAKING. THE CONTACT PULLED IT OUT OF DRIVE AND PUT IT INTO PARK, AND THE CAR WAS STILL GOING. THE CONTACT MADE IT TO A GAS STATION AND WAS FINALLY ABLE TO STALL THE CAR. THE CAR WAS LEFT…

Owner-reported narrative. 53,000 miles reported. Look up ODI 10139691 at NHTSA ↗

1987 FORD TAURUS. CONSUMER STATES SUB FRAME BOTH LEFT SIDE AND RIGHT SIDE OF THE FRONT END BROKE OFF WHILE DRIVING *TGW THE DEALER INFORMED THE CONSUMER HIS MODEL YEAR HAD BEEN RECALLED FOR THE EXACT PROBLEM HE EXPERIENCED. FORD MOTOR CO. STATED THEY WOULD ASSUME NO RESPONSIBILITY. *JB

Owner-reported narrative. Look up ODI 10433370 at NHTSA ↗

PREMATURE WEAR OF TORQUE CONVERTER DUE TO DESIGN, CAUSING TRANSMISSION TO STICK IN GEAR. *AK

Owner-reported narrative. Look up ODI 480039 at NHTSA ↗

BENT TIE ROD ENDS, CAUSING PREMATURE WEAR ON TIRES/MISALIGNMENT. *SKD

Owner-reported narrative. Look up ODI 481298 at NHTSA ↗

Reported: 1986-10-28 (October 28, 1986)

STEERING SHAFT ASSEMBLIES CONTAIN LOWER SHAFTS OF INSUFFICIENT LENGTH FOR PROPER ATTACHMENT TO THE SHAFT INSULATOR FLANGE. CONSEQUENCE OF DEFECT: SHAFT COULD SEPARATE, RESULTING IN TOTAL LOSS OF STEERING CONTROL AND A POSSIBLE ACCIDENT.

Remedy: REPLACE STEERING SHAFT ASSEMBLY, AS NECESSARY.

Reported: 1986-11-07 (November 7, 1986)

LEFT AND/OR RIGHT REAR SPINDLE ASSEMBLIES MAY HAVE BEEN IMPROPERLY HEAT TREATED. CONSEQUENCE OF DEFECT: IF SPINDLE STEM SEPARATES, LOSS OF VEHICLE CONTROL COULD OCCUR WITHOUT PRIOR WARNING.

Remedy: REPLACE REAR SPINDLE.

Reported: 1987-02-19 (February 19, 1987)

ROAD SALT INDUCED EROSION OF THE WIPER MOTOR CONDUCTOR STRIPS COULD CAUSE LOCALIZED THERMAL STRESS WITHIN THE GLASS.

Consequence: GLASS COULD FRACTURE WHILE STATION WAGON IS BEING DRIVENOR PARKED, CREATING A RISK OF INJURY TO OCCUPANTS OR SUDDEN DISTRACTION TO THEDRIVER.

Remedy: APPLY SEALANT TO CONDUCTOR STRIPS AND PROTECTIVE TAPE TO LOWER BACKLITES.

Reported: 1987-09-04 (September 4, 1987)

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Consequence: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

Reported: 1991-08-06 (August 6, 1991)

FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.

Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.

Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.

Reported: 1992-05-11 (May 11, 1992)

CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.

Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.

Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.

Reported: 1993-06-23 (June 23, 1993)

VEHICLE DESCRIPTION: TAURUS AND SABLES BUILT FROM 10-14-85 THROUGH 8-19-88, AND LINCOLN CONTINENTALS BUILT FROM 11-4-87 THROUGH 9-30-88 (EXCEPT 1989 - 1991 2.5L TAURUS AND 1989 - 1992 SHO). THE AFFECTED CARS WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, MAY BECOME DETACHED DUE TO CORROSION OF THE SUBFRAME MOUNT RETAINING PLATE. THIS WOULD ALLOW THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence: IF ONE OF THE REAR CORNERS DROPS, ONLY MINOR INDICATIONS OF A MALFUNCTION SUCH AS A CLUNKING NOISE OR SLIGHT CHANGE IN STEERING WHEEL ALIGNMENT ARE NOTICEABLE. HOWEVER, IF BOTH REAR CORNERS OF THE SUBFRAME DROP, STEERING BECOMES VERY DIFFICULT, WHICH COULD ADVERSELY AFFECT VEHICLE CONTROL AND POSSIBLY RESULT IN AN ACCIDENT.

Remedy: INSTALL A CORROSION-RESISTANT REINFORCING PLATE AND A NEW BOLT ON BOTH REAR SUBFRAME MOUNTS. THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY RECALL 98V-323.

Reported: 1998-12-16 (December 16, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.