2024 Ford RANGER: complaints, problems and recalls

The contact owns a 2024 Ford Ranger. The contact stated while driving 50 MPH, the brake pedal was depressed and the front driver’s side wheel locked up, causing the vehicle to pull to the left. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that there was a part missing from the wheel. The contact was informed that the wheel needed to be replaced. The manufacturer was notified of the failure and a case was opened. The failure mileage was 6,000.

Owner-reported narrative. 6,000 miles reported. Look up ODI 11615090 at NHTSA ↗

I bought this ford ranger and got it last week and went to put a topper on it and you cant - the box rails only hold 80 pounds . You have to install new brackets Ford nose about this but makers buyer pay for it . please make ford do a recall on this before someone gets hurt . thank you

Owner-reported narrative. Look up ODI 11617035 at NHTSA ↗

2024 Ford Ranger Trucks made in Michigan between January 4, 2024 to July 15, 2024 do not include the load box reinforcement bracket. Without this bracket installed, if the owner were to place more than 88lbs onto one or both bed side rails the bed could crack, warp, bend, or break. If operators of this vehicle are not aware and do load the bed side rails over 88lbs, this could pose a safety issue to the driver or other drivers on the road around the vehicle. Ford has not notified all owners of affected vehicles, and in my case I found out my…

Owner-reported narrative. Look up ODI 11617130 at NHTSA ↗

Vehicle displays “Steering Assist fault-Service required”. Failure of power steering while driving could result in loss of control of the vehicle. The earliest available appointment for the dealer to check the problem is 11/20/24.

Owner-reported narrative. Look up ODI 11621817 at NHTSA ↗

The rear seats in the 2024/2025 Ford Raptor Ranger are connected to the rear of the cab via a single latch. The single latch does not always latch. I noticed it had failed to properly latch the next day when I was installing my car seats. I figured it was user error, but than I re-tested it and struggled to properly latch it. The danger is the rear portion of the seat could suddenly fold forward during a hard break or accident, resulting in serious injury to rear passengers.

Owner-reported narrative. Look up ODI 11627625 at NHTSA ↗

I was in an area that had received snow and cold temperatures. I started my car to warm it up and began cleaning off the snow. The heat from the rear defroster caused my read window to shatter leaving glass mostly on the exterior of the truck bed but also in the back seat. This is a known problem with Ford model trucks and they refuse to repair the issue or replace my window.

Owner-reported narrative. Look up ODI 11629933 at NHTSA ↗

I purchased a new 2024 Ford Ranger yesterday. As I was researching camper shells and truck racks I found that these common items cannot be installed without first installing a load bed reinforcement bracket kit to reinforce the truck bed to the bed side rails. Apparently, nothing can be attached to the side rail which weights more that 88 lbs or the truck bed could separate from the side rails. This is an design/engineering shortcoming from Ford as these are common after market add-ons for mid-sized trucks. Also, Ford is asking customers to pa…

Owner-reported narrative. Look up ODI 11632810 at NHTSA ↗

Not sure if this is the correct channel, but here goes my concern. The safety incident has not yet occurred, but the manufacturer has stated it could/may occur if a certain fix is not performed, but are unwilling to issue a recall for said fix, or even produce the parts they say are necessary to implement the fix. I own a 2024 Ford Ranger Raptor that Ford has demonstrated has a design flaw in their bed (for vehicles produced before mid Sept, 2024) in that it cannot carry more than 88 lbs on the bed rails without the potential for failure. I n…

Owner-reported narrative. Look up ODI 11644040 at NHTSA ↗

Reported: 2024-08-09 (August 9, 2024)

Ford Motor Company (Ford) is recalling certain 2024 Ranger and 2024 Lincoln Nautilus vehicles. When closing the windows with the global closing feature, the windows may not automatically reverse after detecting an object. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Consequence: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.

Remedy: Dealers will update the driver door module (DDM) and the passenger door module (PDM) software, free of charge. Owner notification letters were mailed September 13, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C24.

Reported: 2024-10-16 (October 16, 2024)

Ford Motor Company (Ford) is recalling certain 2024 Ranger, and 2024-2025 Bronco vehicles. The front upper control arm ball joint nut may not have been installed or tightened properly, allowing the front upper control arm to detach from the knuckle assembly.

Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.

Remedy: Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly as necessary, free of charge. Owner notification letters were mailed on November 20, 2024. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S64.

Reported: 2024-11-08 (November 8, 2024)

Ford Motor Company (Ford) is recalling certain 2024 Ranger vehicles. The fuel vapor line bracket may have insufficient clearance to the fuel vapor line, which can result in fuel vapor line damage that can lead to a fuel vapor leak.

Consequence: A fuel vapor leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect for a fuel vapor line bracket and install a tie strap to secure the fuel vapor line to the bracket, free of charge. Owner notification letters were mailed November 20, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S71.

Reported: 2025-03-14 (March 14, 2025)

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.

Consequence: Unexpected vehicle movement increases the risk of a crash.

Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.

Reported: 2025-04-11 (April 11, 2025)

Ford Motor Company (Ford) is recalling certain 2024 Ranger and 2024 Lincoln Nautilus vehicles previously repaired incorrectly under recall number 24V-597. When closing the windows with the global closing feature, the windows may not automatically reverse after detecting an object. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Consequence: A closing window may exert excessive force and pinch a driver or passenger before retracting, increasing the risk of injury.

Remedy: Dealers will update the driver door module (DDM) and the passenger door module (PDM) software, free of charge. Owner notification letters were mailed May 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C10.

Reported: 2025-05-09 (May 9, 2025)

Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco and Ranger vehicles. The front upper control arm ball joint fastener may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.

Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.

Remedy: Dealers will inspect and tighten, or replace the ball joint fastener as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S45.

Reported: 2025-05-09 (May 9, 2025)

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Reported: 2025-08-22 (August 22, 2025)

Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger vehicles. The side curtain air bags may contact the B-Pillar inner reinforcements and tear during deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 226, "Ejection Mitigation."

Consequence: Air bags that deploy improperly during a crash increase the risk of injury.

Remedy: Dealers will install protective shields, free of charge. Owner notification letters were mailed September 26, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C41.

Reported: 2025-09-11 (September 11, 2025)

Ford Motor Company (Ford) is recalling certain 2024 Bronco and Ranger vehicles. The bolts securing the high pressure fuel pump may not be tightened properly, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will replace the high pressure fuel pump mounting bolts, free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S90.

Reported: 2025-10-10 (October 10, 2025)

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Reported: 2026-02-20 (February 20, 2026)

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Reported: 2026-04-14 (April 14, 2026)

Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger vehicles. The sun visor or headliner wiring harnesses may be improperly positioned or have excessive tape thickness, which can result in damaged wires.

Consequence: Damaged wires can create an electrical short and cause a fire in the A-pillar area, increasing the risk of injury or a crash.

Remedy: Dealers will inspect the wiring for damage and update the body control module software. Damaged wiring harnesses will be replaced as necessary. All repairs will be performed free of charge. This will be a Phased campaign. Phase 1 will include 2025 model year vehicles. Owners will be notified by mail the week of 5/31/2026. Phase 2 will include 2026 model year vehicles and Phase 3 will include 2024 model year vehicles. Owners will be notified by mail the week of 6/29/2026 for Phase 2 and the week of 7/27/2026 for Phase 3. Interim letters, notifying owners of the safety risk, were mailed May 5, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S29. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 17, 2026.

Reported: 2026-04-28 (April 28, 2026)

Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger and Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.

Consequence: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford’s number for this recall is 26S30. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning April 30, 2026.