2019 Ford F-550: complaints, problems and recalls

TRAILER CONNECTION WIRING FAULT CAUSES DASH BOARD TO FLASH MULTIPLE TIMES INDICATING TRAILER DISCONNECTED OR TRAILER LIGHT BULBS ARE NOT WORKING AND WILL REPEATEDLY FLASH ON DASH MAKING DINGING SOUNDS. THIS IS HAPPENING WITHOUT A TRAILER CONNECTED AS WELL. (TAKE NOT PREVIOUS YEARS OF FORD VEHICLES HAVE HAD THE SAME ISSUE)

Owner-reported narrative. 1,200 miles reported. Look up ODI 11175026 at NHTSA ↗

The contact owns a 2019 Ford F-550. The contact stated that two to three minutes after the engine was revved, a ticking noise was heard in the engine. The sound would stop then a rattling noise was heard. The contact stated that he works as an independent mechanic and diagnosed the vehicle and stated that the #3 cylinder had a low oil pressure. Additionally, the camshaft and follower needed to be replaced. The vehicle was not repaired. The dealer was not notified. The manufacturer was not notified of the failure. The failure mileage was 133,151…

Owner-reported narrative. 133,151 miles reported. Look up ODI 11478168 at NHTSA ↗

Vehicle was being driven at 50MPH when truck encountered pothole in road. Steering wheel began to shake back and forth violently and vehicle was uncontrollable. Truck veered to left and crashed into guardrail while being slowed to a stop.

Owner-reported narrative. Look up ODI 11496379 at NHTSA ↗

Trailer hitch is forming cracks around hitch receiver, Backing plate that the hitch is welded to is separating from the body of the utility box. this truck tows a trailer with a GVWR of 10,000 pounds.

Owner-reported narrative. Look up ODI 11506381 at NHTSA ↗

The contact's company owns a 2019 Ford F-550. The contact stated while the vehicle was stationary, an employee noticed that the cab and chassis was in a V-shape. The contact stated that a mechanic arrived at the location; upon inspection, the mechanic stated that the frame rail was fractured. The vehicle was not drivable. The contact spoke to the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was unknown.

Owner-reported narrative. Look up ODI 11526933 at NHTSA ↗

The contact's company owns a 2019 Ford F-550. The contact stated that the vehicle was inspected by a mechanic, and the contact was informed that the frame rail was fractured. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was unknown.

Owner-reported narrative. Look up ODI 11526935 at NHTSA ↗

Our company has been proactively replacing some of the older fuel filters in our fleet as part of a safety campaign. A fuel filter on VIN [XXX] was replaced yesterday (XXX) with a Ford Motocraft filter. Today (XXX), the operator was driving the unit when they started to smell smoke in the cab. By the time they pulled over, the cab had smoke inside and the operator had to get out. The operator opened the hood to let it vent and called the garage to have the unit towed. After inspection by the garage, they found that the secondary fuel filter…

Owner-reported narrative. Look up ODI 11592496 at NHTSA ↗

The contact owns a 2019 Ford F-550. The contact stated while driving at various speeds, there was an abnormal sound coming from the subframe. The contact stated that the failure recurred increasingly while driving on a bumpy road surface. The contact stated that while inspecting the frame, he noticed that the frame rail behind the cab was fractured. The vehicle was taken to the dealer, where it was determined that the frame needed to be reinforced or replaced. The vehicle was not repaired. The contact stated that the vehicle was previously take…

Owner-reported narrative. 130,000 miles reported. Look up ODI 11605627 at NHTSA ↗

Reported: 2018-12-18 (December 18, 2018)

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

Reported: 2019-03-22 (March 22, 2019)

Watts Manufacturing, LLC (Watts Manufacturing) is recalling certain 2019 First responder vehicles built on Ford F-550 chassis and equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy: Watts Manufacturing will notify owners and Whelen dealers will replace the brake lights, free of charge. The recall began March 19, 2019. Owners may contact Watts Manufacturing customer service at 1-785-404-6003.

Reported: 2019-05-29 (May 29, 2019)

LGE Coachworks, Inc. (LGE Coachworks) is recalling certain 2018-2019 Ford E-450, F-550, and Freightliner M2-based vehicles equipped with ASA Electronics Voyager back-up camera displays. The displays may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

Remedy: ASA will notify LGE Coachworks owners, and dealers will replace the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA customer service at 1-800-384-4400 or LGE Coachworks at 1-800-209-3985.

Reported: 2019-08-28 (August 28, 2019)

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.