2022 Ford F-550 SD: complaints, problems and recalls

I receive notice about recall 22s17. Brought to Ford service in Woodbine, NJ. After my truck was reprogramed the truck doesn't intially connect to the trailer. If I turn off ignition and turn back on the truck doesn't realize it is connected to the trailer. I must idle the truck get out of my truck unplug then plug the trailer connector back into the 7 pin plug for the truck to recognize the trailer for the trailer brakes to work. This truck is my only work truck and I need a solution quickly.

Owner-reported narrative. Look up ODI 11464645 at NHTSA ↗

I was driving about 57 mph headed NW on I270 in the north Denver metro area. I went over a bridge abutment and the vehicle started shaking violently in the front end. I let off the gas but the extreme vibration/shaking continued until I slowed down to around 20 mph. I thought I had lost something in the front end. Then it happened again when I was driving between I70 and US 50 in western Colorado. I was only going 30 miles an hour and hit a rotomilled section of asphalt(a perfect edge drop to the rotomilled pavement) and the violent shaking st…

Owner-reported narrative. Look up ODI 11549794 at NHTSA ↗

at speeds starting 40 mph the Ford 550 tends to sway and require steering changes. This is a fire truck Chassie and when weighed on certified scales it is in the required specification range. The Ford dealer says not their problem. The builder of the fire body keeps asking for more information on tires and weighing the truck.

Owner-reported narrative. Look up ODI 11565297 at NHTSA ↗

Ford Motor Company has had a known issue with the truck frames cracking on the F-550 chassis. They acknowledged it by doing a recall, which either replaced or repaired the chassis frame or installed reinforcement braces if no cracks were visible. The recall expired in September of 2023. In October 2023 we noticed a crack on the frame just outside the recall reinforcement brace that Ford-certified technicians installed. We found another in November (reinforcement brace installed) and another in January (with Ford's new and improved frame pro…

Owner-reported narrative. Look up ODI 11587798 at NHTSA ↗

The contact owned a 2022 Ford F-550. The contact stated that while driving 20 MPH, the vehicle started smoking and flames came from the left side of the engine. The vehicle inadvertently veered to the right of the road. In addition, the contact noticed smoke and flames were coming from the front passenger’s side and the rear of the vehicle. As a result, of the fire the contact sustained smoke inhalation that required medical attention. The Fire Department extinguished the fire. The contact was unaware of a Police report being filed. The vehicle…

Owner-reported narrative. 20,000 miles reported. Look up ODI 11617935 at NHTSA ↗

The contact owns a 2022 Ford F-550 SD. The contact stated that while driving on the highway at 60 MPH, the vehicle experienced a loss of automotive power, with the check engine warning light illuminated. The contact proceeded to pull over onto the side of the highway to safely park the vehicle. The contact attempted to restart the vehicle however, the vehicle failed to restart. The vehicle was towed to a local independent mechanic to be diagnosed. The contact was informed that the fuel pump was faulty and needed to be replaced. The vehicle was …

Owner-reported narrative. 150,000 miles reported. Look up ODI 11640468 at NHTSA ↗

Since I took delivery of the vehicle the dash goes completely blank at temperatures below 32 degrees and above 90. Ford has been unable or unwilling to fix the problem for over two years resulting in my driving for extended periods with no dashboard information of any kind.

Owner-reported narrative. Look up ODI 11641537 at NHTSA ↗

Went to shut vehicle off and it just kept running. No power inside the cab but the engine was still running and it could run and drive although zero inside electrical. Key was in off position. Very potentially deadly situation.

Owner-reported narrative. Look up ODI 11658117 at NHTSA ↗

Reported: 2022-03-25 (March 25, 2022)

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.

Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.

Reported: 2022-04-14 (April 14, 2022)

Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.

Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.

Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.

Reported: 2022-05-27 (May 27, 2022)

Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."

Consequence: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.

Remedy: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.

Reported: 2023-06-09 (June 9, 2023)

Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

Reported: 2023-11-09 (November 9, 2023)

Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.

Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.

Reported: 2024-12-20 (December 20, 2024)

Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.

Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.

Reported: 2025-01-31 (January 31, 2025)

Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.

Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.

Reported: 2025-02-28 (February 28, 2025)

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.

Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.

Reported: 2025-07-07 (July 7, 2025)

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Consequence: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

Reported: 2026-02-20 (February 20, 2026)

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Reported: 2026-03-17 (March 17, 2026)

Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.

Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.

Reported: 2026-03-31 (March 31, 2026)

Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.

Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.